ELECTRICAL SYSTEM,UNKNOWN OR OTHER07/01/2026
The front facing camera and the rear backup camera and the entire camera system is intermittent. Sometimes it works and sometimes it does not. You become a bit dependent on the backup camera and when it does not work & it causes undue stress especially if you are handicapped in the neck turning area. The problem has not been taken to a dealer yet because they cost is prohibitive to just drive it in the door. When the failure occurs, there is a red triangle and a camera with a red circle with a red line through it. This is a documented problem (TSB 23-NA-062) with this model vehicle and should be made a recall. Many others have reported this same issue. Chevrolet will not fix it without cost of up to $1500 or more if the car is out of the 36K warranty
STEERING06/27/2026
STEERING NOT RETURN TO CENTER. DEALER DIAGNOSED STEERING GEAR NEEDING REPLACEMENT. DANGEROUS ON TURNING ON A CORNER AS HAVE TO PULL WHEEL BACK TO CENTER MANUALLY.
STEERING03/26/2026
There's a very common issue with these vehicles where the steering rack breaks and causes a number of issues including a clunking noise when driving over bumps and a rattle in steering wheel when turning left and right. However the most important and dangerous issue is that the steering wheel stops returning to center after making a turn. The steering wheel will move about 1/2 of the way back to center and then just stop and I have to manually turn it the rest of the way. You can imagine how dangerous this could be if someone doesn't realize what's happening and the car continues turning and goes into oncoming traffic. I have to manually turn the steering wheel back to center to avoid the car veering into the oncoming lane of traffic after making a turn. GM can fix it by replacing the rack, but it's a $4k repair and will happen again after replacing it.
ELECTRICAL SYSTEM02/27/2026
The contact owns a 2022 Chevrolet Bolt EUV. The contact stated that while driving at an undisclosed speed, the electrical system became inoperable. The contact stated that the seat belt warning chime failed to function when the seat belt was not fastened. Additionally, the instrument panel became inoperable while attempting to reverse, and the rearview camera failed to function properly. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The vehicle was then taken to the dealer, where it was diagnosed, and it was determined that the radio system and instrument panel screen had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 50,000.
STEERING10/06/2025
Steering has been become stiff at lower speeds and does not return to center. There is also a knocking noise when making turns. Chevrolet dealer has indicated that the steering rack/gear needs to be replaced. Vehicle is at 115,000 miles, and the problem started happening around 112,000 miles. Although the vehicle does have a lot of miles, I've owned vehicles way past 200,000 miles and have never had to replace a steering rack at a cost of over $3,000.
VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE08/18/2025
On Thursday, August 14th, while pulling into a parking space my car accellerated speed by itself and the engine sounded like it was reving up loud. I had to slam the brakes to get the car to stop. i narrowly missed hitting two other vehicles.
UNKNOWN OR OTHER08/07/2025
On Wednesday, July 30, 2025, while driving home from routine shopping errands, I suddenly heard a loud “pop” from above the vehicle. Importantly, there was no collision, no debris, no road hazard, and no indication that anything had struck the vehicle. I was not involved in any incident that could have caused external damage. When I pulled into my garage and inspected the vehicle, I immediately noticed severe damage to the sunroof: Multiple large cracks radiating across the glass Shattered and fractured areas near the center A small hole in the glass with loose shards visibly protruding outward, suggesting that the force originated from inside the panel Loose glass pieces resting above the interior fabric sunroof shade, which fortunately prevented debris from falling into the cabin The outward-facing damage pattern is critical: it clearly indicates the sunroof did not break due to an object hitting it from the outside, but rather due to internal pressure, stress, or a structural failure in the glass—likely a manufacturing defect or flaw in materials. I documented the damage with both photos and video from above the sunroof, capturing the direction of the glass break and the area affected. This was an unprovoked, spontaneous failure under normal driving conditions and poses a serious safety concern. Given these facts—lack of impact, direction of the force, supporting evidence, and the coverage of my extended warranty—this should reasonably be considered a warranty-covered issue due to product defect or failure. I brought my vehicle to my nearest Chevrolet dealership on Saturday 8/1 for their inspection. No action on their part was taken. Follow-up with the service manager confirmed they would not fix / non warranty issue. Driving home from the service appointment, shards of glass broke loose from the sunroof. This created an immediate and serious driving hazard—not only to me and my passengers, but to other drivers and potentially even pedestrians.
FORWARD COLLISION AVOIDANCE07/25/2025
Three times while using the Adaptive Cruise Control, the car applied the brakes without cause (“phantom braking”.) Two of the times there were cars behind me that could have rear ended me given the unexpected, rapid deceleration. The problem has not been reviewed by the car dealer (because they won’t return my calls.). No other parties have inspected. No warning lamps or messages. Incident dates: 5/9/2025, 6/22/2025, and 7/19/2025.
STEERING07/09/2025
Steering wheel would bind up when returning to center after turning, requiring sudden additional force to go in the intended direction. Occurred on a regular basis, verified by the dealer and required steering gear replacement. Steering was also generally stiffer than normal.
STEERING06/23/2025
steering wheel does not return to center after a turn. I have to force center the wheel after a turn. This is a common issue known to bolt euv owners online and should be a recall by the manufacturer due to poor steering rack build.
STEERING06/06/2025
Steering does not return to center after making turns at slower speeds. Upon reviewing complaints from numerous other Chevrolet Bolt owners it appears to be a faulty steering rack that needs to be replaced.
STEERING05/28/2025
The steering does not return to center at lower speeds. This appears to be a very common problem affecting these cars after about 40k miles due to faulty part. Repair can cost $3k. Worried that the steering could lock up and cause an accident. My wife didn't even notice until I drove her car and brought it up. Some people could be driving for years without knowing.
Showing 12 of 23 complaints.
