POWER TRAIN,ENGINE07/14/2026
This 2025 Chevrolet Tahoe has experienced three separate and recurring engine-related failures. The first failure occurred at approximately 41,350 miles and required replacement or repair of the lifters and camshaft. The vehicle remained at the dealership for approximately 15 days. The second failure occurred at approximately 54,619 miles and involved another lifter failure along with traction control problems. The third failure occurred at approximately 65,140 miles. The Check Engine warning light illuminated while the vehicle was being driven, and the vehicle again experienced engine-related problems. The vehicle has now been at the dealership for more than one week, and no repair or permanent solution has been provided. I am concerned that these repeated engine failures and traction control problems create a serious safety risk, particularly because the vehicle is driven on public roads and highways. Despite previous repairs, the engine problems continue to recur. I am requesting that NHTSA investigate these repeated safety-related failures.
ENGINE AND ENGINE COOLING,COMMUNICATION07/09/2026
See attached document for complaint.
ELECTRICAL SYSTEM,SEATS07/06/2026
ON JUNE 2ND 2026, the air conditioning in my 2025 Chevrolet Tahoe failed without warning. The system began blowing warm air instead of cold air, making the vehicle uncomfortable to drive. At the same time, I noticed that both front ventilated (cooled) seats had also stopped working. Although the seat cooling indicator lights illuminated when activated, the seats did not produce any cooling. I called to schedule an appt and took the vehicle to the dealership for diagnosis and repair on june 4, 2026. The dealership determined that the A/C condenser had failed and replaced it. I was advised that the repair had been completed, and I picked up the vehicle believing the issue had been resolved. Shortly after the repair, it became apparent that the problems had not been fully corrected. While the air conditioning initially appeared to function, the ventilated seats continued to provide no cooling despite appearing to operate normally. This marked the beginning of an ongoing series of HVAC-related failures that ultimately required multiple return visits to the dealership.
FORWARD COLLISION AVOIDANCEcrash07/01/2026
Driving in bumper to bumper traffic in my 2025 Tahoe and the automatic braking system slammed on the brakes at 10 mph causing me to get rear ended.The light turned green and traffic started moving forward and I'm hitting the gas pedal when my truck just slams on the brakes causing the girl behind to rear end me. The car in front of me was moving forward and never hit their brakes but my car still slammed on the brakes for no reason. I was probably 6 or 7 feet away from the car in front. This isn't the first time this car has slammed on the brakes for no reason. It always seems to happen in the summer during sunny mornings as I'm headed east driving towards the sun. I got lucky the other 6 or 7 times this has happened up until today
ENGINE06/24/2026
On May 19, 2026, my 2025 Chevrolet Tahoe suffered a sudden, catastrophic engine failure while traveling at 60 mph on a public roadway. I originally took retail delivery of this vehicle brand new on October 29, 2025, with only 14 miles on the odometer; at the time of the failure, the vehicle had only accumulated 10,049 total miles. The failure resulted in an immediate, complete loss of motive power at highway speeds, creating a severe, life-threatening safety hazard to myself, my passenger, and surrounding traffic. The vehicle was towed to an authorized GM dealership for emergency service. Upon removing the oil pan, dealership technicians discovered a high volume of metal debris and fragments, indicating a severe internal mechanical failure (likely failed engine bearings). General Motors corporate subsequently mandated secondary diagnostic teardowns. Following these tests, GM confirmed a total, non-repairable engine failure requiring a complete engine assembly replacement. This vehicle has remained entirely out of service and non-operational since the date of the incident. On June 24, 2026, with the vehicle out of service for 36 consecutive days, I issued a formal demand letter to General Motors Customer Relations, demanding that they adhere to New York State Lemon Law statutory requirements and initiate an immediate vehicle buyback. Due to this severe defect, this vehicle is now deemed entirely unsafe and unreliable for my family, as our confidence in its mechanical integrity is permanently destroyed. Furthermore, a vehicle requiring a complete engine replacement at this mileage has suffered severe diminished financial value. A catastrophic engine failure on a low-mileage, current-generation vehicle poses an immediate, critical manufacturing defect and an unacceptable risk of high-speed collisions.
ELECTRICAL SYSTEM06/15/2026
The air conditioning/climate control system failed. I initially brought the vehicle to the dealership on June 4, 2026, because it was blowing hot air. The dealership replaced the condenser on June 5, 2026. On June 12, 2026, the driver's side again began blowing hot air while the passenger side remained cold. By June 13, 2026, both sides were blowing hot air. The vehicle is being returned to the dealership on June 15, 2026, for an additional repair attempt related to the recurring air conditioning failure. The excessive heat created a safety concern because the cabin temperature exceeded 100°F despite the air conditioning being turned on. I developed hives and a rash on my face, neck, trunk, and arms from the heat exposure. Excessive cabin temperatures can impair driver concentration and increase the risk of heat-related illness. Yes. An authorized Chevrolet dealership diagnosed the issue and replaced the condenser on June 5, 2026. The problem reoccurred within approximately one week of that repair. The vehicle has been inspected by an authorized Chevrolet dealership and remains available for inspection by the manufacturer or its representatives. There were no warning lights or messages. The only symptom was the air conditioning blowing hot air instead of cold air.
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE06/15/2026
On June 12, 2026, while operating my 2025 Chevrolet Tahoe, I experienced an apparent powertrain or transmission-related issue. At the time, the vehicle was already exhibiting another defect involving the air conditioning system, with the driver's side blowing hot air and the passenger side blowing cold air. While attempting to accelerate and pass another vehicle, the engine RPM suddenly increased to approximately 6,000 RPM. The RPM remained elevated momentarily before gradually decreasing. The vehicle's response was abnormal and inconsistent with normal acceleration. Because I was close to home, I continued driving but remained concerned about the vehicle's operation. Since that incident, the same condition has occurred approximately two to three additional times. The problem is intermittent and does not occur every time I accelerate, making it difficult to predict when it will happen. This condition creates a safety concern because sudden, unexpected increases in engine RPM while attempting to accelerate can affect vehicle performance and driver confidence, particularly when passing other vehicles or merging into traffic. The vehicle is being returned to the dealership for evaluation, and the defect remains unresolved.
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE05/22/2026
***SAFETY/DANGER*** On April 12th at around 5:30 p.m. my family of five, to include three minor children were returning home from visiting family which live about an hour and a half away and as we're traveling on the freeway at highway speeds, in traffic, our new Tahoe unexpectedly and without warning went into reduced power mode and cut speed down to approximately 35 MPH in active traffic, which out my family and every other car around me in danger and in jeopardy of causing a collision and even worse, a multiple car pile-up as I dodged full speed traffic in front and behind me while traveling at approximately half their speed. I managed to exit the freeway and heard a loud knocking noise from the engine and saw the reduced power mode indicator, all of which had not happened before but again, the Tahoe is relatively new and was just over 5 months and at 8,889 miles at failure. I proceeded to contact GM roadside assistance. They sent a tow truck and I had to make arrangements for my family to return home, an hour away. I made it to the dealership with the tow truck driver after 9 p.m. ***CATASTROPHIC DAMAGE**" After the dealership inspected close to a week later they did determine that the entire engine and turbocharger had to be replaced, which they did in a little over a month, the dealership did their part but confidence is lost. Now I am hesitant to drive the Tahoe as it's the family vehicle but really put my kids, wife, myself and everyone around us on the road in danger as it, out of nowhere, cut speed drastically in active highway traffic.
ENGINE05/18/2026
I was leaving my neighborhood on Saturday night 5/16 around 5:30 and on the way out all of a sudden the dashboard started lighting up and the speed was dropping despite me being on the gas. The screens kept flashing then the car stopped and went into park and I could not get it out of park. I was at the front of my nieghborhood entrance and it made it hard for others to come in and out. I tried to restart it. My husband tried to jump it. I tow truck came about two hours later only to realize it could not tow it since the vehicle was stuck in park and could not be powered to move it to neutral. They had to call a new tow truck. I was sitting in my car stuck in the entrance of my neighborhood impeding traffic for close to 4.5 hours. A new tow truck finally arrived at close to 9:45pm. It was towed on dollies to the dealership. They inspected it today and said the starter and the engine had both failed/blown and needed full replacement. I am waiting to hear back from them on the estimated time for replacement biut could take weeks which is devastating. My vehicle is the 2025 Chevy Tahoe High Country with the 6.2 L V8 engine that I now understand has issues prior to 2025 and was recalled but nothing yet for the 2025. My car is only 9 months old and has 12,100 miles on it. I am devastated. Prior to this I had no issues and there were no sounds or issues it just happened. It was dark by the end and I was sitting in the middle of the road and the lighting in the area is limited so I had to have someone bring me lamps so other drivers could see me as the car is black and it was very dark. Someone almost hit me pulling into the neighborhood as a result thankfully I was able to get lamps.
FORWARD COLLISION AVOIDANCE,LANE DEPARTURE05/11/2026
The issue is related to Super Cruise hands free driving. During a recent long trip multiple times the Super Cruise signaled for lane change and tried to move into the passing lane with a car directly beside me. I have 8,500 miles on this car and have used Super Cruise extensively on highway driving only and until this last trip never had any issue with the system seeing cars in lanes beside me before. I only avoided a collision because I prevented the lane change by grabbing the steering wheel. This software bug will end up with injury or death of individuals unless Chevy fixes this immediately. Your help in investigating this is appreciated. I will add my son has a 2025 Suburban and has experienced the car trying to pull into traffic beside him.
VISIBILITY/WIPER05/04/2026
On Friday May 1, 2026 while parked at my home, the rear glass lift gate burst into multiple shards. I have taken a few photos of the outside as I found it. In my surprise, I failed to photograph the glass in the interior of the vehicle. I have owned this car since new, since near the end of July of 2025. I had unloaded some groceries from the back area, raising and lowering the large metal lift gate. The glass lift gate was NOT used. As a matter of recording, I have only lifted the glass once or twice since owning the vehicle. The main metal lift gate is the unit used most often. Apparently, this is a known issue with several reports online. What I found online seems similar in that no impact or accident occurred to cause the glass to shatter. What is odd, instead of a typical safety glass experience of a "spider web" type of fracture and the glass staying intact, this was "exploded" with the glass found in multiple shards both in the car and outside on the ground. When I called my local Chevrolet dealer, they denied knowledge of this as a problem within the fleet. Because this is a use issue and weather issue, I am having to personally pay for repair. The new window will cost almost $1000.00 to repair.
UNKNOWN OR OTHER05/04/2026
As i was driving down the road at approximately 40-45mph the sunroof spontaneously exploded. Sounded like a shotgun going off. Fortunately i had the sun shade shut but still tiny glass shards came in and fell on my child and the entire interior in the mid section of vehicle. There was no vehicle in front of me, it was night time with temps in mid 70’s no reason it should've exploded outward as if a gun shot from inside of vehicle which also implies nothing hit glass. Vehicle is at mcconnel automotive dealership where they are telling us that warranty will not cover this and we must claim on our insurance. I also called GM headquarters and they denied claim as well (case# 95312600) have spoke with several other owners on a facebook group this has happened to and GM has and is denying warranty coverage on them as well.
Showing 12 of 36 complaints.
