Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2005 Dodge Durango, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Dodge Durango year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA has issued a do-not-drive warning covering 2 recalls on this make, model and year. Repairs are free at any franchised dealer.
Recalls are issued per model. Confirm whether this specific car has already been repaired using its VIN, free, at any franchised dealer or on nhtsa.gov/recalls.
NHTSA lists 9 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.
Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.
Campaign 16V352000
Issue: Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.
Campaign 15V313000
Issue: Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Chrysler will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. For vehicles that were sold, or are currently registered, in Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, owners were notified and the recall began on December 5, 2014. For all other vehicles, Chrysler notified owners and the recall began on February 3, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P40 Expanded. Note: This recall has been superseded by recall 16V-352. This recall superseded the passenger air bag portion of recall 14V-354.
Campaign 14V770000
Issue: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000
Issue: CHRYSLER IS RECALLING 18,951 MY 2005 DODGE DURANGO VEHICLES. THE FUEL TANK FILLER TUBE INLET CHECK VALVE MAY NOT FULLY CLOSE AT THE END OF REFUELING. THIS COULD ALLOW SOME FUEL TO ESCAPE FROM THE VEHICLE THROUGH THE FILLER NECK AT THE END OF REFUELING.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK INLET CHECK VALVE. VEHICLES FOUND TO HAVE A SUSPECT INLET CHECK VALVE WILL HAVE THE FUEL TANK ASSEMBLY REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 09V003000
Issue: ON SOME SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, AN INTEGRATED CIRCUIT IN THE INSTRUMENT CLUSTER THAT CONTROLS INTERIOR LIGHTING MAY OVERHEAT.
Risk: THIS COULD POTENTIALLY CAUSE AN INSTRUMENT PANEL FIRE.
Remedy: DEALERS WILL INSPECT THE CLUSTER FOR DAMAGE AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-140.
Campaign 07V092000
Issue: ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Risk: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 06V067000
Issue: ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Risk: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 05V460000
Issue: ON CERTAIN SPORT UTILITY VEHICLES, THE FUEL TANK FILLER TUBE INLET CHECK VALVE MAY NOT FULLY CLOSE AT THE END OF REFUELING. THIS COULD ALLOW SOME FUEL TO ESCAPE FROM THE VEHICLE FILLER NECK.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE INLET CHECK VALVES AND REPLACE THE FUEL TANK ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 05V034000
NHTSA frontal crash test
10 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2005 Dodge Durango 4-DR.
The parts named most often across 1,567 owner complaints filed with NHTSA for this make, model and year.
2 injured
3 injured
1 crash · 2 fires
3 crashes · 4 injured
13 crashes · 11 injured
13 fires · 1 injured
1 crash · 2 injured
1 crash · 2 fires
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
3 complaint-reported fatalities on this model.
My car is having identical symptoms to a recall for it, but dodge is saying my vehicle is "Not affected", despite having identical symptoms from an identical cause. The check valve on my fuel tank has failed, and it overflows when I fill it with gas
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the contact became aware that gasoline was spilling out of the fuel filler neck. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline); however, the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.
See attached document from complainant
The carseat will not lock into the base proper in any recline position except 1. 1 is supposed to be for a newborn. When you place the seat (till you hear it "lock" into place per the manual and a CPST) in 2, 3, or 4 then the seat drops down into the 1 position while driving down the road. We've contacted evenflo repeatedly and no help from them. Now it's to the point it doesn't even lock into 1. We've had this seat since Jan 17, 2023. I have checked online and am able to find 30+ reviews of parents with the same issue across reddit, Amazon, and Walmart. A recall on the seat needs issued immediately. This has been going on since Jan 21st, 2023.
The contact owns a 2005 Dodge Durango. The contact received notification of NHTSA Campaign Number: 16V352000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2005 Dodge Durango. The contact stated while refueling the vehicle, the fuel started leaking from the filler neck. The contact waited for a while to refuel the vehicle. Additionally, the contact stated that a message was displayed on the instrument cluster "Gas Cap". The contact stated that she checked the gas cap and was properly placed then replaced the gas cap however, the message recurred. The dealer was notified of the failure and confirmed that the VIN was not included in a recall. The vehicle was not repaired. The contact refenced the NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline. The manufacture was not notified of the failure. The failure mileage was approximately 126,337.
The contact owns a 2005 Dodge Durango. The contact stated upon starting the vehicle, the instrument cluster was not operating properly. The speedometer displayed 50 MPH while the vehicle was parked and the odometer turned blank, and the vehicle was stuck in FWD. The contact stated that the interior lights failed to turn off upon depressing the light switch. Additionally, the contact stated while driving at an undisclosed speed, there was an abnormally strong electrical wiring burning odor inside the vehicle. The contact veered to the side of the road. The contact stated that the burning odor was coming through the A/C vents on both sides of the instrument panel. The vehicle was taken to a nearby independent mechanic, where it was diagnosed that the failure was related to NHTSA Campaign Number: 07V092000 (Electrical system). The dealer was notified of the failure and informed the contact that the recall repair was previously completed on the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 252,000.
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the fuel tank spilled gasoline to the vehicle. The fuel also leaked onto the driveway while the vehicle was parked. Additionally, the vehicle lost motive power while driving with the air bag warning light illuminated. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the vehicle had previously been repaired under NHTSA Campaign Numbers: 09V003000 (Fuel System, Gasoline), 15V313000 (Air Bags), and 16V352000 (Air Bags). The failure mileage was approximately 152,000.
This vehicle will slip in and out 4 wheel drive on its own. This can occur when driving and I’m concerned it will create a dangerous situation, especially if driving at high speeds. When this issue is occurring, making tight turns (parking, neighborhood driving) becomes very dangerous as the wheels become locked and you have to press the accelerator down creating a lot of power and the vehicle becomes dangerously uncontrollable. This is very common while parking, when often pedestrians are present and the vehicle becomes unpredictable due to this issue. This will also occur at a 2 way stop when turning right in front of on-coming traffic. The vehicle will again be unpredictable and can’t turn smoothly impairing traffic coming from behind.
Was on a delivery order with Doordash suddenly the truck started bucking back and forth it had felt as if someone was slaming into the back of truck anyway I was on the highway in traffic when this had started leaving me 1st and 2nd gear than final with no gears cause the transmission was burning hot to the touch causing burns on my hand when I tried to check out I was told my truck went into some kind of limp mode cause of transmission control module and shifted solenoid A on the transmission someone needs to hold Dodge responsible for its failures
The contact owns a 2005 Dodge Durango. The contact stated that fuel spilled out of the filler neck at the end of refueling. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was previously repaired under NHTSA Campaign Number: 05V034000 (Fuel System, Gasoline). However, the contact related the failure to NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline) but the VIN was not included in the recall. The failure mileage was approximately 120,000.
My 2005 Durango all of a sudden has decided to stall while driving . I've bought this vehicle almost 2 years ago, and this is by far the scariest experience I've had in it. The first time it happened was as I was slowing down to stop at a red light on January 17th. Since then it has been stalling one at least 3 to 5 times a week . Something isn't right. I did receive a code from my Milewise ins OBD reader today, that said P1794 URGENCY UNKNOWN - contact your mechanic . That's one of 3 I got . The other two are p 0700 Transmission control system ( MIL request ) Urgent - have checked ASAP AND - P0430 CATALYST system efficiency below threshold. Urgent - have checked ASAP This tells me something is seriously wrong and it's going to cost me a fortune. Which for me is impossible to even try to contemplate. I am disabled and my income is not enough. I can not afford to fix this, nor can I afford to buy something else. This is a real problem that I can't afford and it should have been fixed before when it was brought to your attention back in 2005.
Showing 12 of 1,567 complaints.