FUEL/PROPULSION SYSTEM07/13/2026
My F150 will, on occasion, not accelerate when I am going slow and making a right turn. There are no fault lights, just the engine does nothing when I press the gas pedal. I coast to the intersection, apply the breaks, start the right turn, then press the accelerator to speed up. For about 6 seconds nothing happens (regardless of how hard I press the pedal), then the engine engages and the truck accelerates. I have mentioned this to my dealer several times, but they just keep explaining that they have not heard of the issue and they cannot replicate. I fear this may cause a serious accident if not resolved.
FUEL SYSTEM, GASOLINE07/02/2026
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
UNKNOWN OR OTHER06/24/2026
In April 2026 the recall on this truck was done to correct a fault for the Trailer Disconnect. I hooked up my travel trailer for the 1st time here in June and the false warning still came on 5 times during my trip. The software update that was done is not solving the problem. Warning light comes on, says trailer disconnected while the trailer is still connected and all connections are plugged in.
POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL06/10/2026
Highway Incident: While traveling at highway speeds, a sudden evasive braking maneuver caused the truck to drop power. Upon attempting to re-accelerate, the throttle pedal went to the floor with zero response, and the vehicle continued to decelerate on an active highway. Multiple trailing vehicles had to make emergency maneuvers to swerve around the decelerating truck to avoid a high-speed, rear-end collision. Subsequent Incidents: The vehicle repeatedly forces an uncommanded speed limit of 11 mph while attempting to accelerate from a complete stop or merge from stop signs. This severe lack of predictable acceleration creates an immediate risk of being T-boned or rear-ended by cross-traffic, making the vehicle entirely unsafe to operate in normal traffic conditions. An authorized Ford dealership has confirmed the underlying failure of the hybrid system. They kept the vehicle for approximately one month to replace the entire hybrid drive unit. Following that repair, the vehicle was returned to the dealer a second time, where technicians confirmed a software communication failure between the electric and gas systems, attempting to resolve it by flashing/reprogramming the ECU. The vehicle’s hybrid system and software have been extensively inspected and worked on by manufacturer-certified technicians at an authorized Ford dealership. It has not been inspected by police or insurance, as no physical collision has occurred yet. No warning lamps or messages.
POWER TRAIN,ENGINE05/19/2026
In the second year of ownership I noticed that occasionally I would get no throttle response from the gas pedal when trying to accelerate. After several occurrences I began to pay close attention as to when this was occurring. I found that this occurs mostly, not exclusively, when I am slowing the vehicle to a near stop, not a full stop and then accelerating to continue, like slowing to round a corner on a green light and getting into traffic. For example, I was exiting a Home Depot parking lot, the driveway exits to the roadway. As I approached the driveway to enter the roadway I slowed, preparing to stop. Seeing no traffic on the roadway I then pushed the accelerator to enter the roadway. The pedal was dead, I got absolutely no acceleration. I pushed the pedal down slowly, nothing. I pushed the pedal to the floor, nothing. The truck rolled out onto the road, I coasted to the side of the road. Had there been traffic I'd have been hit. This has happened 20 times in two years and 80K miles. The most recent event was this week with my wife present, very scary, dead pedal, not throttle response. If you research "Dead Pedal" on GOOGLE, you will get the following response: The "dead pedal" in the Ford F-150 PowerBoost—a dangerous lag or total loss of throttle response—is a widely reported issue, particularly when accelerating from low speeds, turning, or right after starting. [1, 2, 3] The cause can range from a software glitch to transmission issues or failing sensors. Ford said there was a TSB, however the work performed had no effect on the dead pedal on my truck. Invoice attached from March 2026, it just occurred again this week. I am going to trade the vehicle in but I doubt that Ford will disclose this flaw to the next buyer, it will be their's to discover, hopefully not by "accident". I am going to trade this vehicle in and I'm sure the new buyer will have no idea of this potentially deadly flaw.
POWER TRAIN,FUEL/PROPULSION SYSTEM04/09/2026
I just started the truck, put it in gear, and began driving slowly through the parking lot. The gas pedal was unresponsive—even when pressed all the way to the floor, the truck would not accelerate or move. This has happened multiple times, both while rolling slowly and sometimes from a complete stop. It occurs intermittently.
ELECTRICAL SYSTEM09/20/2025
When I started my 2022 Ford F-150 equipped with the Bang & Olufsen (B&O) sound system, a sudden extremely loud “sonic boom” noise came through the speakers without warning. The sound was so intense it caused immediate pain in my ears, and I am concerned about the possibility of permanent hearing damage. This occurred at startup, before I adjusted any audio settings. This is a serious safety hazard because: The volume level was far beyond normal operation. It caused physical harm (ear pain). Such an unexpected loud noise could startle the driver, leading to loss of vehicle control. I believe this defect poses a risk of injury and should be investigated.
FUEL SYSTEM, GASOLINE09/03/2025
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 30 MPH downhill, the vehicle stalled. The contact shifted to neutral(N), and the vehicle rolled to a stop. There was no warning light illuminated. The vehicle was able to restart, and the contact resumed driving. The contact stated that the failure had recurred several times while driving. Additionally, the contact stated that while driving at various speeds, the vehicle hesitated to respond upon depressing the accelerator pedal. The dealer was contacted and informed the contact that the vehicle could not be diagnosed because the parts for the recall repair were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and advised the contact to wait for a second recall letter. The manufacturer advised the contact that the vehicle was safe to drive. The failure mileage was approximately 34,000.
EXTERIOR LIGHTING08/28/2025
The contact owns a 2022 Ford F-150. The contact stated that the front driver’s side headlamp failed to illuminate as needed. The contact stated that the dealer had previously replaced the passenger’s side headlamp. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 40,000.
STRUCTURE08/13/2025
The moonroof leaks causing water to spill into the cabin thru the headliner flowing onto the dash and coming into contact with electrical equipment dome lights infotainment system and could cause a potential issue with water and electrical system!!!
POWER TRAIN08/11/2025
I was driving down the road and heard a loud clunking noise. Then I had lost power and the rear wheels were spinning out of control. There was a grinding/spinning/whirring noise coming from beneath the vehicle, sounded like from behind. I was fortunately able to regain control of the vehicle by shifting it into 4WD and avoided an accident. I brought the Vehicle to Gaudin Ford for repair and was informed it was a recalled part failure recall number 23S65. I had previously requested the recall repairs to be performed during routine maintenance, but was informed parts were not available. At this time, I've been 6 weeks without my truck and there is no end in site. It was insinuated that they might not even be making this part anymore, but the Ford recall center was unable to confirm or refute this. In the interim, I do not have a suitable replacement. I have been provided a small vehicle as a loaner, but I am unable to use this to drive >50 mile radius, I can't leave the state, can't loan it to my children, can't tow or haul. All the things I need my truck for, I'm unable to do. Either, I need access to a rental with similar capability to my truck without all the restrictions, or fix the truck in a timely manner, or provide me a suitable loaner without all the restrictions, or buy back my truck, or something. Instead I feel like I'm being held hostage by a company who is refusing to fulfill the recall responsibility in a timely and suitable manner. I have contacted the dealer, Ford customer service, and the Ford recall center on numerous occasions and have been told that other than getting an update when the part is available, there's nothing else they can do. The Ford case number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
SERVICE BRAKES,FORWARD COLLISION AVOIDANCEcrash08/05/2025
Was stopped behind a car in line in the parking lot. The truck was in drive with the auto hold brake feature enabled. The auto hold disengaged and the car rolled forward rear ending the car in front of me. Collision alert didn't sound as expected. A similar recall came out August 6 for 2025 F150s.
Showing 12 of 201 complaints.
