ELECTRICAL SYSTEM07/20/2026
The forward dash instrument panel is completely out. Unable to see miles per hour, charge settings, odometer, cruise control etc. Completely blank.
FUEL/PROPULSION SYSTEM07/13/2026
My F150 will, on occasion, not accelerate when I am going slow and making a right turn. There are no fault lights, just the engine does nothing when I press the gas pedal. I coast to the intersection, apply the breaks, start the right turn, then press the accelerator to speed up. For about 6 seconds nothing happens (regardless of how hard I press the pedal), then the engine engages and the truck accelerates. I have mentioned this to my dealer several times, but they just keep explaining that they have not heard of the issue and they cannot replicate. I fear this may cause a serious accident if not resolved.
FUEL SYSTEM, GASOLINE07/02/2026
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
UNKNOWN OR OTHER06/24/2026
In April 2026 the recall on this truck was done to correct a fault for the Trailer Disconnect. I hooked up my travel trailer for the 1st time here in June and the false warning still came on 5 times during my trip. The software update that was done is not solving the problem. Warning light comes on, says trailer disconnected while the trailer is still connected and all connections are plugged in.
POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL06/10/2026
Highway Incident: While traveling at highway speeds, a sudden evasive braking maneuver caused the truck to drop power. Upon attempting to re-accelerate, the throttle pedal went to the floor with zero response, and the vehicle continued to decelerate on an active highway. Multiple trailing vehicles had to make emergency maneuvers to swerve around the decelerating truck to avoid a high-speed, rear-end collision. Subsequent Incidents: The vehicle repeatedly forces an uncommanded speed limit of 11 mph while attempting to accelerate from a complete stop or merge from stop signs. This severe lack of predictable acceleration creates an immediate risk of being T-boned or rear-ended by cross-traffic, making the vehicle entirely unsafe to operate in normal traffic conditions. An authorized Ford dealership has confirmed the underlying failure of the hybrid system. They kept the vehicle for approximately one month to replace the entire hybrid drive unit. Following that repair, the vehicle was returned to the dealer a second time, where technicians confirmed a software communication failure between the electric and gas systems, attempting to resolve it by flashing/reprogramming the ECU. The vehicle’s hybrid system and software have been extensively inspected and worked on by manufacturer-certified technicians at an authorized Ford dealership. It has not been inspected by police or insurance, as no physical collision has occurred yet. No warning lamps or messages.
STEERING,SUSPENSION06/03/2026
Component Failed & Inspection Status: The front-left upper and lower control arms, ball joints, wheel hub assembly, steering knuckle, and front axle shaft have failed. Severe environmental corrosion has completely seized and fused the steering knuckle inside the wheel hub. All original failed components are currently intact and are fully available for physical inspection upon request. Safety Risk: This severe structural corrosion causes the steering knuckle and axle to seize, creating an imminent risk of primary steering component separation while driving. A steering separation on a heavy electric vehicle (over 6,000 lbs curb weight) causes a sudden, complete loss of directional control, creating an immediate life-threatening hazard to the occupants and surrounding traffic. Confirmation & Testing:The failure and severe structural corrosion were officially diagnosed and confirmed by a certified technician at an authorized Ford dealership service center. Warning Signs & Symptoms: The symptom appeared as a very noisy, distinct creaking sound coming from the front-left suspension. This noise occurred specifically when turning the steering wheel and when operating the vehicle at speeds below 40 mph. The sounds may have been present but obscured by road noise at higher speeds. There were no dashboard warning lamps or error messages prior to the diagnostic inspection. Systemic Concerns: This 2022 model is experiencing a severe vulnerability to premature environmental corrosion that causes the steering knuckle, axle, and control arms to seize to the point of failure. This demonstrates a critical structural durability issue under heavy EV loads in road-salt regions that warrants federal safety tracking for the 2022 model year.
POWER TRAIN,ENGINE05/19/2026
In the second year of ownership I noticed that occasionally I would get no throttle response from the gas pedal when trying to accelerate. After several occurrences I began to pay close attention as to when this was occurring. I found that this occurs mostly, not exclusively, when I am slowing the vehicle to a near stop, not a full stop and then accelerating to continue, like slowing to round a corner on a green light and getting into traffic. For example, I was exiting a Home Depot parking lot, the driveway exits to the roadway. As I approached the driveway to enter the roadway I slowed, preparing to stop. Seeing no traffic on the roadway I then pushed the accelerator to enter the roadway. The pedal was dead, I got absolutely no acceleration. I pushed the pedal down slowly, nothing. I pushed the pedal to the floor, nothing. The truck rolled out onto the road, I coasted to the side of the road. Had there been traffic I'd have been hit. This has happened 20 times in two years and 80K miles. The most recent event was this week with my wife present, very scary, dead pedal, not throttle response. If you research "Dead Pedal" on GOOGLE, you will get the following response: The "dead pedal" in the Ford F-150 PowerBoost—a dangerous lag or total loss of throttle response—is a widely reported issue, particularly when accelerating from low speeds, turning, or right after starting. [1, 2, 3] The cause can range from a software glitch to transmission issues or failing sensors. Ford said there was a TSB, however the work performed had no effect on the dead pedal on my truck. Invoice attached from March 2026, it just occurred again this week. I am going to trade the vehicle in but I doubt that Ford will disclose this flaw to the next buyer, it will be their's to discover, hopefully not by "accident". I am going to trade this vehicle in and I'm sure the new buyer will have no idea of this potentially deadly flaw.
POWER TRAIN,FUEL/PROPULSION SYSTEM04/09/2026
I just started the truck, put it in gear, and began driving slowly through the parking lot. The gas pedal was unresponsive—even when pressed all the way to the floor, the truck would not accelerate or move. This has happened multiple times, both while rolling slowly and sometimes from a complete stop. It occurs intermittently.
UNKNOWN OR OTHER02/17/2026
Vehicle: 2022 Ford F-150 Lightning Pro VIN: [XXX] This vehicle is subject to a fire-related battery recall issued by Ford Motor Company. The vehicle has been at an authorized Ford dealership (West Herr, New York) since December 26 for recall repair. As of today, it has been out of service for 53 days. The dealership has stated that the delay is due to EV battery lift capacity limitations and that my vehicle is waiting behind another truck because they only have one lift capable of performing the repair. No firm repair completion date has been provided. For over seven weeks, I have received no proactive communication from the dealership regarding repair status. All updates have required me to initiate contact. This complaint is being filed to document prolonged failure to complete a fire-related safety recall due to dealership capacity constraints. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ELECTRICAL SYSTEM,EXTERIOR LIGHTING11/05/2025
The rear lightbar assembly on our 2022 Ford F-150 Lightning Lariat has developed micro-cracks in the outer lens, allowing moisture to accumulate inside. This has caused flickering or inoperative reverse lamps and now appears to be impacting the rear passenger blinker, which functions intermittently. We are concerned that the moisture has begun to corrode the rear wiring harness or electrical system, creating additional safety risks. When we reported the issue, a Kendall Ford representative told us the rear lightbar replacement was “mainly cosmetic,” but that assessment contradicts both Ford’s recall documentation and our experience. Moisture intrusion has already led to intermittent lighting failures that reduce signaling visibility to other drivers, posing a real risk of collision. The problem has been confirmed by the dealer and a Ford Field Service Engineer dispatched from Dearborn, who inspected the truck in 2025 after the same recall repair (23S30) failed. Ford has since issued a new recall (25V731 / 25S86) acknowledging improper dealer repairs as the cause. Visible condensation, flickering lights, and intermittent “charging system fault” and “sensor unavailable” messages began shortly after the 2023 recall repair and have continued to worsen. The vehicle remains in our possession and is available for inspection by NHTSA or Ford corporate upon request.
EXTERIOR LIGHTING10/20/2025
The light bar on the tailgate that is the brake lights and reverse lights is known to get moisture inside and stop working. It is a known problem with Ford as they recalled them 2 years ago and replaced it under warranty. However the replacement part suffers from the same issue. So, my replacement light bar has stopped working, and even though I have Fords Premium Care extended warranty that includes all LED lighting, they will not cover the repair. This part is a safety item (brake lights and reverse lights) that is known to fail, it should be a safety recall item covered out of warranty anyway, and SURELY covered with an extended warranty (Ford Premium Care with Lighting added) but it apparently is not .... It seems that this safety issue should be covered and replaced Thanks
EXTERIOR LIGHTING10/20/2025
I own a 2022 Ford F-150 Lightning Lariat (VIN [XXX] ). Around June 6, 2025, I brought my truck to Apple Ford Shakopee for a scheduled appointment because I noticed moisture collecting inside the rear light bar. The service representative told me Ford considers that moisture normal, likely from a car wash, and that it would dry out on its own. At that time the truck had fewer than 36,000 miles and was still under the bumper-to-bumper warranty. The moisture never went away, and the light bar is now failing — my backup lights are dimming and flickering. I’ve since learned there was a recall (23S30) on 2022–2023 F-150 Lightning Lariat and Platinum trucks for micro-cracks in the rear light-bar lens that allow moisture in. My VIN currently shows no open recalls, but this failure appears identical to what the recall described. Additionally, owner forums are full of reports from other Lightning owners experiencing the same issue — including those who already had the recall repair completed, whose replacement light bars are now showing moisture again. This suggests the defect may persist even after recall repairs. I’m reporting this because the issue compromises the rear lighting and visibility of the vehicle. I hope Ford and NHTSA will review whether the recall scope or remedy should be expanded to include affected vehicles like mine and ensure owners aren’t left with expensive out-of-pocket repairs for a known manufacturing defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Showing 12 of 289 complaints.
