POWER TRAIN,SERVICE BRAKES07/15/2026
Following a software update by Ford in the past 6-8 months, upon start-up my vehicle asks me which drive mode I wish to be in but then after 15-45 seconds "forgets" my answer and changes drive modes. This results in regenerative braking being disabled, at random, in the middle of a drive. This is a major safety issue, as I will expect braking to applying while easing up on the accelerator but that simply doesn't happen. This could cause an accident, injury or worse.
UNKNOWN OR OTHER07/14/2026
Vehicle: 2024 Ford F-150 Lightning Flash — 17,240 miles ▎ Current software version: itrm-25.B04 ▎ ▎ Following an over-the-air software update in November 2025, my truck will not stay in the drive mode I select. At every startup the vehicle prompts me to confirm Sport mode and I select Yes. The truck then reverts to Normal mode on its own, without my input. ▎ ▎ This happens every single time I drive the truck. I drive it at least three times a week and it has occurred on every trip since the update. The timing is unpredictable — sometimes immediately after Android Auto connects, sometimes at the end of my driveway, sometimes at the end of my road, sometimes several minutes into the drive. The randomness is part of the hazard: I cannot anticipate when the vehicle's braking behavior will change. ▎ ▎ There is no warning of any kind when the mode changes — no chime, no message, no alert. The only indications are that the small "S" disappears from the instrument cluster and the truck's driving characteristics change. The most safety-critical difference is regenerative braking: lifting off the accelerator produces substantially less deceleration in Normal mode than in Sport. I drive to the braking behavior I selected, and the truck silently takes it away from me. ▎ ▎ I have had two close calls as a direct result: ▎ ▎ 1. A vehicle ahead of me made a late right turn onto a side road. I lifted off the accelerator expecting Sport-mode regenerative braking to slow me. The truck had silently reverted to Normal. It did not decelerate at the rate I expected and I had to slam on the brakes to avoid a collision. ▎ 2. At a blinking light at the end of my road, a vehicle ahead stopped short. Again I lifted off expecting the Sport-mode regen I had selected, again the truck had changed modes on its own, and again I had to slam on the brakes. ▎ ▎ In both cases I was relying on the deceleration characteristics of the mode I set, and the vehicle had changed them without telling me. This be
UNKNOWN OR OTHER,SERVICE BRAKES07/14/2026
Ford provides various driving modes for this truck, by their own description this setting changes the responsiveness of the steering, acceleration, and regenerative braking. This mode defaults to "Normal" at startup, with a short on-screen prompt to return to the previous mode. While this is incredibly frustrating, on its own probably doesn't rise to the level of a reportable issue. However sometime in November the truck received an OTA update that has introduced a bug that causes the truck to make an uncommanded return to the Normal drive mode. Regardless of how the truck is put into Sport or another mode (either the "return to mode" prompt, or going into the vehicle menu and selecting another mode) after a few minutes of driving the truck will return to Normal mode. This causes a change in steering responsiveness, and since I usually drive in Sport mode, also reduced the regenerative braking, meaning letting off the accelerator doesn't slow the truck as much as expected. A for representative mentioned on the FordLighting forums that Ford engineers were aware of the problem and looking for a solution back in January, but we haven't seen anything more from them since.
VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,BACK OVER PREVENTIONcrash06/26/2026
I was the only person in the truck and there was no one nearby. I was slowly backing the Ford 150 Lighting into my driveway, going straight back. I was going slow because another car was parked at the back end corner. As I was rolling slowly back, the truck started to accelerate on its own, I had not increased pressure on the pedal. The truck was not making any beeping noises or alerts on the screen indicating that there was another car parked behind it. NO safety alerts at all. The truck was completely out of my control other than my ability to turn the steering wheel. I had lifted my foot off the gas pedal entirely at one point to make sure it was not me pressing it and the car kept moving faster without my foot. I tried to steer the truck straight back but upon realizing it would not stop and was only getting faster, I veered the steering wheel to avoid hitting our other small car and turned the truck which backed up directly into the south west corner of our house. The house is what stopped the truck. Upon impact with the house- NO airbags inflated. The truck touchscreen temporarily shined red and audibly said that it would “call 911” and no call was ever made. After this, and after I had gotten out of the truck, I realized that the entire truck shut down mechanically. The turn on button did nothing, the key did nothing, the gears would not shift - it was in a locked position. The driver's seat that I was in- got dislodged and crooked by the force of the truck to the house. My right calf is still sore because my right foot was on the pedal when the truck hit the house. My left side of my neck is very sore and I have a headache around tension around my temples and top of head, my forearms, wrists, trapezius muscles, and rhomboid muscles - all were sore after the crash.
POWER TRAIN06/10/2026
See attached document for complaint.
VEHICLE SPEED CONTROLcrash06/02/2026
The contact owns a Ford F-150. The contact stated that the vehicle unexpectedly accelerated while in a drive through, a vehicle was ahead, the vehicle appeared to be rolling forward even though the foot was on the brake pedal. The front grill fender area was impacted. The other drivers vehicle the trunk and rear bumper were impacted. No additional property damage. No airbags deployed. No warning lights illuminated including any collision indicators. No injuries were sustained. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate mileage 15,002.
SERVICE BRAKES,FORWARD COLLISION AVOIDANCE05/28/2026
I was driving by and received multiple warnings about brakes. Brake assist, one pedal driving, reverse brake assist, general brake warning. After the came on the brake were spongy with a hard brake after applying more pressure to the pedal. I needed to apply more pressure because the car was not stopping. I almost hit various cars on the way home because there is certainly an adjustment needed to my braking habits. Very dangerous and unsafe. I took the truck to the dealership and quoted me around $2,500. This is something I have no control over and see that there is a recall on this issue for a 2025 model, but my vehicle does not fall under this recall.
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER04/28/2026
While driving on a surface road in Columbia, MD at approximately 40 mph, the dash display of the 2024 Ford Lightning Flash went completely blank, leaving no indication of vehicle speed, battery percentage, battery temp, motor temp, cruise control status etc. Zero information was displayed, and the dash was completely cold and dark. This failure, while traveling at speed, represents a gross safety hazard, especially because the same LCD displays automatic emergency braking informaion etc. Immediately, I was able to pull over, and establish an OBD-2 connection to the ECM, and pull error logs. I also took screenshots of critical components and voltages. I cleared the codes, re-checked for codes and saved another error log showing a couple of codes. I then cycled power to the truck several times, hoping for a reboot to clear the error. I also performed a manual reset of the Ford SYNC system. Using the OBD-2 virtual dash on my reader, I was able to safely display speed and battery data, and drive immediately to the nearest Ford Dealer (Koons Ford). On the way, I phoned Crossroads Ford (Apex, NC) who did a remote error check using the vehicle's modem. The dealer may have saved this data. Upon arrival to Koons, service writers and technicians were able to witness and verify inoperability of the dash unit, and cycle the vehicle power, whereafter the problem persisted. They then took it back for service and evaluation. After approximately 4 hours, I was told that the "dash reset itself after a couple hours" and they could not get it to repeat the error after it came back. Before this, there were no warning signs of dash failure, nor since.
VEHICLE SPEED CONTROLcrash11/10/2025
I was making a road trip in my 2024 F150 Lightning Lariat. I pulled up to a Tesla supercharger. I turned the car off and attempted to plug in but the cable was about three inches too short. So I got back in the truck, turned it back on and put it in gear for the last three inches of travel. The truck accelerated dramatically. It clipped two charging stations, hopped a curb and went into a field, headed for a major lane of traffic. I rode the brake as hard as I could and it continued to accelerate. I threw it in neutral and finally got control of it, just short of the road. I turned the vehicle off and back on and drove out of the field, the truck behaving normally. I finished the trip and returned home without incident. In reviewing the experience in my mind, I can't make mistaking the accelerator for the brake pedal make sense. You can't turn the vehicle on without pressing the brake pedal. You can't put it in gear without pressing the break pedal. And the fact that it continued to accelerate after hitting the charger doesn't sound like a pedal mistake. I have never found the human factors of the F150 to be challenging - it is very straight forward to drive. I also don't think I could have accidentally hit the cruise control. You can't accidentally engage the cruise control from a standing stop. I do always use one-pedal driving.
SERVICE BRAKES10/04/2025
Hi There, i wanted to report a situation with my Ford F150 Lightning I brought this monster truck last December'24 and everything worked until today when i hit a issue with the break Me and my wife went to Costco for weekend Shopping, i was trying to park to a very comfortable parking position; after getting in, I reversed the car to make it align with the parking line. Right after that i changed the position to drive slowly role it forward to adjust my parking, the truck started accelerating forward. I pressed the break hard and hard it would not stop. Imagine its Costco, lot of people around me, luckily it was trees and mulch area Infront, and Imagine its Costco, lot of people around me, luckily it was trees and mulch area Infront, and there was a traffic board. The Truck hit the traffic pole and stopped hanging over the mulch area. Everyone around me was screaming and looking at me. Through traffic stopped and took diversion, i pulled back slowly, guess what, the car would not come back to the parking lot again. I press the reverse and accelerate to get back to the parking space, but car is still going forward, scary. I stopped the engine and again tried to reverse; it worked. I swear to God that i never hit the acceleration since it's a parking spot, why would i do that... Car still went forward, so it's a genuine bug in the Ford 150 which needs to be fixed, otherwise its going to hurt or kill people I still have loan to pay for this car, but after todays incident i will not take his car out again , Unless Ford give me proper explanation and fixes. I read many similar stories in Rediit, so i think this is real issue. Other wise why the car wont stop even i press th break pedal, remember i configure this car with one pedal, but still nothing worked. Any help in sorting this out is higly appreciated, i am more worried about the risk of the public's life with this kind of issues where i cannot stop the car even after pressing the break, its really scary
ELECTRICAL SYSTEMfire08/25/2025
The contact owned a 2024 Ford F-150 Lightning BEV. The contact stated that while the vehicle was parked and unoccupied, it caught on fire. The contact stated that the Police knocked on the door and informed the contact that fire was shooting out of the vehicle. The fire department arrived and extinguished the fire. The vehicle was towed to a local tow yard. The vehicle was deemed a total loss. In addition, the vehicle was parked in a secluded area of the tow yard. The contact stated that the Fire Department, Police, and Insurance Agent unofficially referred to the failure as electrical or battery-related. The manufacturer was made aware of the failure. The failure mileage was 5,000.
UNKNOWN OR OTHER08/13/2025
I was on the on-ramp and accelerated to get to freeway speed nothing crazy. The truck took off even with my foot off the pedal. I braked hard to avoid rear ending the vehicle in front.. Started slowing down took my foot off the brake and it did it again... braked hard again, hit the hard shoulder then it went back to normal. Lucky it was a 5 lane freeway...
Showing 12 of 27 complaints.
