Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2008 Ford F-150, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford F-150 year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 1 recall for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
Risk: THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
Campaign 08V523000
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2008 Ford F-150 Supercab
The parts named most often across 369 owner complaints filed with NHTSA for this make, model and year.
1 injured
3 crashes · 1 fire · 3 injured
9 crashes · 4 injured
14 crashes · 23 injured · 1 death
2 crashes · 3 fires · 1 injured
2 injured
4 fires
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
2 complaint-reported fatalities on this model.
The driver side air bag went off while reversing out of my home. The air bag went off while my arm was across the steering wheel. Powder went in my eyes from it and my arm was bruised and burned from the impact. It hurt so bad that my I had someone pick me up from home and drive me to the hospital. I also had my ear drums ringing for a good while. No police has inspected it as it happened at my home and there were no warning lights for it on. I didn’t hit anything either. I was simply reversing when it went off.
The mirrors are not convex, the do not meet safety standards for viewable angles. Impossible to use to back up.
Walmart Auto Center installed the incorrect tire size 255/70R17 on my factory setup with factory wheels. Westlake SU318 All Season 255/70R17 112T SUV/crossover tires were installed in place of the correct size 245/70R17 tires. Walmart is refusing to fix my truck and I had the brake lines blow out 3 weeks after installing the tires. I am a current threat to the public and myself driving with these incorrect tires. Walmart will not replace the tires. Walmart is attempting to coverup this by not providing the information to carfax. I have submitted a carfax update case#XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2008 Ford F-150. The contact stated that after turning off the vehicle, the contact attempted to restart the vehicle and became aware that the gear shifter was not in park(P). The contact inspected the gear shift lever, and the gear shifter was in the park(P); however, the contact was unable to move the gear shift lever. The contact depressed the brake pedal, moved the gear shift lever, and was able to restart the vehicle. A mobile mechanic arrived at the residence and replaced the shifter cable, and the vehicle was repaired. The contact stated that on a separate occasion, while arriving at her sister's residence, the failure reoccurred. The shift indicator displayed that the vehicle was not in park(P). However, the gear shifter lever was in park(P). A neighbor stopped by and assisted the contact by going underneath the vehicle and manually shifting the gear. The vehicle was restarted and driven to the residence. The failure had progressively worsened, and the vehicle was no longer driven. The vehicle was parked at the residence. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 135,000.
The grab handle on drivers side that is put there to assist the driver to enter the vehicle is the issue. On 4/17/2025 I was attempting to enter my truck. I am severely disabled. I grabbed the handle that is attached to the A pillar as I have hundreds of times since I bought the truck in 2008. I am the original owner. Vehicle only has about 36,000 miles on it. As I was pulling myself in the entire handle detached from the A pillar sending me into a bad fall onto my driveway. Luckily I was not seriously injured. I'm 6'4 190 pounds, so its not like I'm terribly heavy. The next day I went to see just what happened and removed the the handle assembly. I was shocked to find that it is not attached to the steel A pillar. A steel plate is attached to the pillar under the handle but the handle is anchored to that plate only by two plastic wells that the screws go through. Both of the bottoms of those wells broke clean off which then allowed the entire assembly to pull away from the A pillar. I did some research and there is like a 5 year period of this being a known issue. I found dozens of examples of the exact same failure online. There is no "better" replacement part available either. I'm shocked that Ford would not secure this handle into the frame. Something thats meant to assist people entering the vehicle that will be pulled on anchored with PLASTC?? Ford needs issue a recall for this and provide a fix. If i had been 4 inches closer to my brick wall corner of my house I would not be here now to report this. I have included pics. the red circled parts are the plastic that hold the handle to the pillar that broke.
The truck has a body frame that was cracked in several spots and welded back together in more then 5 different spots and the welding job is very poor. The truck has a power steering line leak, cvs axle leaks and a exhaust manifold leak. The dealership fixed upper ball joints when we agreed on lower and upper in the front. They added a exhaust but did not do the job correctly with completing the job and the welding of it. Ive made a complaint with the loan company and i as well have talked to the owner of the dealership and he fights that none of those things are wrong with the truck and im lying but i have had a inspection done on the truck. When i got the truck i looked it over and so did my brother i pointed the issues of what needed fixed that i could see and that was not done. I then started having issues with the truck and took it to a mechaninc and had an inspection done
Door fails to close and latch shut. Several other recalls on this issue but my vin was not included. I am currently not able to drive the car with out the door falling open Related recalls provided to me by Ford 17s33 19n06 18n03
See attached document for complaint.
My 5.4 v8 triton motor timing came phasers are bad the truck runs fine when cold when it gets warmer up it rattles and shakes and stalls air bag light stays on I had to pull the fuse bc it beeps and warning light so it's not active
Vehicle will not go into reverse. After research and reviews of this transmission in this year model, the reverse band is a known issue by Ford. Even the transmissions installed for replacement have bad reverse bands. There was a service advisory put out by ford but the advisory is no longer available. The reverse band is weak and the incorrect part was installed from factory.
The defroster does not blow. There is an issue with the actuator and although the air can be heard blowing, the air is restricted at the firewall. Per the dealership, it is a known issue. I can't drive my truck in winter because it won't defrost. I live in Fargo, ND.
I experienced a loss in power while driving and not driving, as well as locking my keys in the vehicle once It would not unlock. The gear shifting knob stopped due to what seemed like resistance an the damaged caused by sales man to the top plunger cap just after i paid. Recently the battery and the alternator are not working and when power is ran through the vehicle, an obvious sound of a live cable buzzing in the rear cab exterior light and seemed to be spliced in a n unsafe way.
Showing 12 of 369 complaints.