ELECTRICAL SYSTEM,ENGINE07/11/2026
The car is suffering random shutdown and intermittent times. The battery is no longer holding a charge and when it shuts down this places me at extreme risk. Ford is unable to fix it so this is no longer happening without replacing the High Voltage battery - battery from ford alone is 11k. I cannot be the only one who is dealing with this car doing this.
SERVICE BRAKES10/31/2025
Brake lights stay on even after turning off car. According to my research the problem is a brake pedal bumper that deteriorated. I actually found the rubber piece on the floor. Prior to finding out my brakes remained on, the red engine light turned on. I checked recalls for this problem, and there was one, but it was only valid for high humidity States. I live in California so I didn't qualify. Now, due to not knowing what the red light was about, and it being smog time, I cleared the engine light. Well, I didn't know that disqualifies my smog test because other codes were erased.now I have a car that is battery disconnect since I can't drive it due to not smog certified. All because of a rubber brake part falling off. I?called my dealer if it was covered by recall, they said no, even though there IS a recall for humid areas. I don't live in a humid area. So my case shows that it DOES NOT have to be humidity related. It's just a cheap quality part. I'm hoping this changes to include ALL areas. Thank you.
BACK OVER PREVENTION09/10/2025
The contact owns a 2014 Ford Fusion Hybrid. The contact stated that the rearview camera displayed a distorted image while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The vehicle was not diagnosed or repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure. The failure mileage was unknown.
ENGINE07/29/2025
On cold startup, a significant amount of white exhaust is sometimes observed coming out of the tailpipes. The exhaust has a sweet aroma and after checking the coolant levels, it appears that the coolant levels have dropped and the exhaust smoke is being caused by a coolant intrusion into the engine block. No warning lights have been observed and it only happens about half of the time.
STEERING07/21/2025
The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was a loud clunking sound coming from the steering wheel while attempting to make a turn. There were several unknown warning lights illuminated. The contact stated that the steering wheel was difficult to turn. The vehicle was taken to the dealer, where it was diagnosed and determined that the electric rack and pinion had failed and needed to be replaced. The contact ordered the parts and had the dealer install the parts. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the same diagnostic was provided. The contact was informed that the electric rack and pinion needed to be replaced. The parts were ordered by the dealer. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the same diagnostic was provided. The contact was informed that electric rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 208,864.
STEERING07/17/2025
The contact owns a 2014 Ford Fusion. The contact stated that upon starting the vehicle, the messages "Service - AdvanceTrac Off", "Hill start Assist Unavailable", and "Steering Assist Fault - Required" were displayed. The vehicle was towed to the dealer, where it was diagnosed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however the VIN was not included in the unknown recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.
STEERING07/14/2025
I am submitting this complaint regarding a complete loss of power steering on my 2014 Ford Fusion. The issue occurred without warning and was accompanied by multiple dashboard alerts including: “Steering Loss – Stop Safely” “Service AdvanceTrac” “Hill Start Assist Not Available” The steering became extremely heavy and difficult to turn, creating a major safety concern—especially while driving at low speeds or attempting to park. I have since researched this issue and found numerous reports from other 2014 Ford Fusion owners experiencing the exact same failure. While Ford issued a Customer Satisfaction Program (15N01) covering similar issues on 2011–2013 Fusion models, no such support appears to be available for the 2014 model—even though the symptoms and system design are identical. Dealers are quoting repairs in excess of $3,500 to replace the rack-and-pinion steering system, which is believed to be the source of the failure. Given the abrupt and dangerous nature of the malfunction, I am requesting that NHTSA investigate this issue as a potential safety defect and consider whether Ford should expand coverage or issue a formal recall for affected 2014 vehicles. This is a critical steering safety issue that could easily lead to accidents or injury if it happens at higher speeds or in traffic. I urge the NHTSA to take this seriously and evaluate Ford’s handling of this problem in 2014 Fusion models. Thank you for your attention to this matter. Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
SERVICE BRAKES07/13/2025
My brake fluid line ruptured and the dealer refused repair and told me that even if they did repair it I would take 2 days and wouldn’t provide a loaner/rental so I had took to a different shop that I had to pay out of pocket for and was done in an hour.and also this is a recall for my year make and model and isn’t on my vin
EXTERIOR LIGHTING07/02/2025
I left my car at Ford to do the recalls, they just called me telling me they won’t fix the brake light on because in Florida it doesn’t cover the repair, something about the humidity here. It doesn’t make sense for me, they were trying to charge me around 400 bucks to fix it. They will give me my car back without fixing the problem. My car is at Matthews-Currie Ford in Venice.
STEERING06/28/2025
Steering gear in rack in pinion grinding and felt like car stalled and steering went hard..no warnings or indications prior to..67,000 miles on Car …now there is a continuous grinding sound coming from steering wheel and Ford had a recall on 2014 Fusion but my car doesn’t show any …afraid steering may lock up without warning
SEAT BELTS06/26/2025
The contact owns a 2014 Ford Fusion. The contact stated that while wearing the driver's side seat belt, the seat belt failed to retract and was locked. The contact stated that the failure mostly occurred after the vehicle had been parked outside in extreme heat, but the seat belt operated as needed in the morning after the vehicle had been parked in the garage overnight. The contact was unable to secure herself inside the vehicle using the seat belt. There was no warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 16V875000 (Seat belts); however, the VIN was not included. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 65,000.
LATCHES/LOCKS/LINKAGES06/17/2025
The contact owns a 2014 Ford Fusion. The contact stated while the vehicle was parked, the front driver's side door latch failed to operate as intended and the door failed to close securely. The contact stated that due to the failure the vehicle was driven to work with an open door. The vehicle was taken to the dealer where it was determined that the front driver's door latch was inoperable. The contact was informed that the front driver's door latch needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that a week later, the rear passenger's door latch failed to latch as intended. The vehicle was scheduled to be inspected. The vehicle was not yet diagnosed or repaired by an independent mechanic or the dealer. The contact referenced NHTSA Campaign Number: 23V775000 (Latches/Locks/Linkages); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 121,198.
Showing 12 of 1,347 complaints.
