SERVICE BRAKES06/23/2026
The Ford Maverick has a known issue with "grabby brakes." I recently took my vehicle in for service and was advised the vehicle had an outstanding service bulletin to solve this problem. The repair given by Ford is ineffectual. There is a potential problems, even at low speeds, for sudden braking and collisions. This is ongoing at every stop and experienced by other Maverick owners.
POWER TRAIN,ELECTRICAL SYSTEM06/21/2026
12 volt electrical system no power. Dealer changed battery cable wiring harness. Received vehicle back. One week later vehicle exhibited no 12 volt power. Informed that it could be the Thinkware dash cam. Which was purchased from Ford and Ford dealer installed. Now informed that it could be the dash cam itself. The dash cam was installed via the OBD port which is always powered. This will drain the 12 volt battery unless vehicle is driven for extended periods. Ford is aware of the issue but no remedy for over 3 weeks. I have told the Ford dealer to have the dash cam installed so that when the ignition is on the dash cam is also powered on and off when the ignition switch is turned off. Using this method negates the parking mode on the dash cam. Another issue is when the drivers side door is opened the interior lights do not activate. Ford notified. Problem not resolved. Low 12 volt battery issue?
ELECTRICAL SYSTEM06/19/2026
12-Volt battery gets extremely hot and gives off invisible fumes. Model number is BAGM-H14. Vehicle was towed to dealership for diagnostic evaluation. Also, dashboard shows various warning messages. Battery could not be charged, plus does not maintain charge.
STEERING,WHEELS,UNKNOWN OR OTHER06/06/2026
This vehicle has chronic clicking when turning , when taken to a mechnanic i was informed the CV Axles both were torn and that it was a common issue for the 22 ford mavericks and they issue replacements for free. However when it comes to this they don’t cover it. The issue is still present and left untreated could be a dangerous issue.
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM06/03/2026
Receiving daily Battery Saver Mode notices telling me some remote features including lock/unlock may temporarily be unavailable. Not to use my AC and go for longer rides, which I have done with no change. My interior lights are not coming on. My radio powers off and on while driving. Constant clicking and noises come from the vehicle when turned off. Difficulties starting the vehicle at times. Feel power losses when driving and accelerating, feel like I could be rear ended when this happens. In doing some online research, I am clearly not alone in this issue, when I contacted Ford and the dealership they both acted as if this is not a current issue and I would have to it inspected by a Ford dealership with no guarantee that the inspection would be covered. I found a recall 24S24 that sounds like my exact issue, yet they say it's not been authorized for my vehicle.
POWER TRAIN,ENGINE06/01/2026
Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.
VISIBILITY/WIPER05/22/2026
Recall 24S51 from Ford says that 87,000 Maverick trucks have had the wiper motor fail due to moisture getting into the housing due to a sealant problem with the supplier. The recalled VINs can have a free inspection and replacement. I believe my VIN is also impacted by this problem because 37 months and 31,000 miles into my car, my wipers failed. I was driving in light rain and the wipers would only go up about 6" from their resting position before returning to the resting position, then repeat the same thing. Thankfully the rain wasn't so heavy that I had to stop and could continue driving home (very carefully!). We've had a very dry winter, so I haven't used my wipers in months. The prior week before the failure, we had a big snow/rain storm spanning two days with about 1.5" of moisture coming down. Hence, I think this storm precipitated, literally, my issue. I took my Maverick to the Ford dealership for a hitch recall, asking about this wiper motor recall problem at the same time. I picked up my truck today and after it's been sitting in the sun, my wipers work again. It sure seems that when moisture is getting into the housing, the wipers fail, then the sun dries it out, then the wipers work. Note, my truck is not garaged. I believe my VIN should be part of the 24S51 or 24-594 recall. Since in my almost 60 years of driving, I've never had a failure of a windshield wiper motor in this way, it seems to be a very rare thing to occur. With a recall of this part in other Mavericks similar to mine, I think mine is actually affected as well.
POWER TRAIN05/17/2026
While driving the vehicle at low speed (roughy 25mph) a loud sqeek was heard. This occured a few more times so I stopped to inspect. I countinued my trip after not finding the source of the noise. When it occured again, I pulled into a parts store and had them run codes. After finding none I purchased a code scanner so that I could monitor while under way. Once on the highway the sound became more frequent, after just a few miles warning lights appeared on my dash and the vehicle had a complete loss of power. I was able to coast to the side of the road. At that time the vehicle did have code P1061. Dealer diagnosted the truck with a failed transmission. I removed the trasmission and disassembled it. The main shaft had been stripped of it's splines on the gear that connects to the engine. I have a video of the gears and shaft here: [XXX] I saved the parts and will be happy to provide them for investigation if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
UNKNOWN OR OTHER05/08/2026
CV axles bad, intense shuddering during acceleration and between 25-55mph. Severe enough to shake side to side in my lane on occasion. Serious safety concern and seems to be a ubiquitous issue.
POWER TRAIN04/19/2026
Both front CV axles on my 2023 Ford Maverick Hybrid are failing at approximately 60,000 miles. The vehicle experiences violent shaking and vibration during acceleration, most noticeably at speeds above 30 mph and on inclines. The shaking is severe enough to affect steering control and reduce driver confidence, particularly during highway merging and uphill acceleration. The problem was diagnosed and confirmed by San Leandro Ford dealership, which identified both front CV axles as defective and in need of replacement. No warning lamps or message appeared prior to or during the issue. The vehicle is available for inspection upon request. This appears to be a widespread manufacturing defect. Numerous owners of 2022-2023 Ford Mavericks have reported identical premature CV axle failures at mileages ranging from 10,000 to 60,000 miles, as documented in online forums and prior NHTSA complaints. Some owners have had axles replaced multiple times. The defective CV axles pose a safety risk as the severe vibration compromises vehicle control during normal driving conditions.
POWER TRAIN03/20/2026
The contact owns a 2023 Ford Maverick. The contact stated that while driving 5 MPH and making a right turn, the vehicle lost power, and the transmission slipped into neutral(N). While driving 25 - 30 MPH and approaching a red light, the transmission slipped into neutral. The contact associated the failure with NHTSA Campaign Number: 24V330000 (Power Train) and 25V133000 (Power Train). The local dealer was contacted and confirmed that the VIN was included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 17,000.
ENGINE03/18/2026
The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was a fuel odor on the exterior and interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured fuel seal. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was informed that a diagnostic test was needed to determine the cause of the failure. The dealer declined to provide a free diagnostic test. The contact referenced the notification of NHTSA Campaign Number: 23V380000 (Engine); however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 45,300.
Showing 12 of 73 complaints.