ELECTRICAL SYSTEM06/24/2026
This is a Ford Palladium Van, year 2024, the secondary alternator charging circuit that Thor has installed has a lot of problems. Specifically, the alternator from Balmar fails and you cannot charge lithium batteries while the van is in motion. The whole point of the secondary alternator is to charge these batteries while in motion. Its a safety issue when traveling with children or pets because battery voltage drops if you have to run AC while in a store or something. You proceed down the road and the battery is not recharged. Next stop you may not be able to run AC at all.
UNKNOWN OR OTHER05/30/2026
This vehicle is subject to Recall 25V860 / Ford Recall 25SD9 involving the left rear half shaft. On several occasions, the vehicle has rolled after being placed in Park. I was forced to quickly reenter the vehicle and apply the brake to prevent a collision, property damage, or personal injury. Due to these repeated incidents, I no longer believe the vehicle can be operated safely. I have attempted to obtain the recall repair through authorized Ford dealerships but have been unable to obtain a permanent remedy. As a result, the vehicle remains subject to a serious safety defect that creates a risk of unintended vehicle movement. I am concerned that the condition described in Recall 25V860 has affected my vehicle and presents an ongoing safety hazard to myself, my passengers, and the public.
POWER TRAIN05/08/2026
Transmission, drive shaft and rear axle "grenaded" and shut down the vehicle. Symptoms included erratic shifting at highway speed, clunking sounds, hard downshifts at low speeds, mis-shifting gears causing performance issues. No warning lights. Codes appeared in FordPass app after vehicle shut down.
POWER TRAIN,BACK OVER PREVENTION,ELECTRICAL SYSTEM04/06/2026
The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and offered a buyback, but no assistance was provided. The failure mileage was approximately 23,459.
POWER TRAIN03/04/2026
The contact owns a 2023 Ford Transit. The contact received notification of NHTSA Campaign Number: 25V860000 (POWER TRAIN). The contact stated that while driving at an undisclosed speed, the gear shifter independently shifted from drive(D) to reverse(R). The contact stated that before the failure occurred, the message "Hill Assist" was displayed on the screen. The contact clicked "OK," and shortly afterwards, the gear shifter shifted independently. The vehicle was taken to the dealer, and the contact was informed that it might be an electrical failure; however, the vehicle was not inspected or diagnosed. The contact stated that the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
UNKNOWN OR OTHER02/25/2026
Water enters under the hood because the “cowl” has separated from the windshield near the wipers.
STRUCTURE,ENGINE02/24/2026
The contact owns a 2023 Ford Transit. The contact stated that while driving approximately 25 - 60 MPH, the check engine warning light illuminated, and the vehicle started to decelerate. During the most recent failure, the contact was able to drive to the dealer before the vehicle lost power. The vehicle was diagnosed, and the contact was informed that water was leaking into the engine, causing a shortage with the spark plugs and other electrical systems. The #4 spark plug was replaced. The contact researched and became aware of an issue with the cowl allowing water and debris to enter the engine and causing the #4 spark plug to be short-circuited. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 45,000.
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER11/14/2025
My cargo van has no rearward windows. It has front/rear/left/right exterior cameras which generate a simulated, 360-degree, overhead view on a monitor. The right camera functions about half of the time. Once it generated an all-orange view. Now it often generates an all-blue view. I know other Ford vehicles are subject to a recall for this software issue and Ford has (or is generating) a fix for the problem. The 2023 Transit is not part of that recall group, but it should be.
BACK OVER PREVENTION11/10/2025
The contact owns a 2023 Ford Transit. The contact stated that while attempting to reverse, the rearview 360° camera became inoperable. The contact stated that the rearview image was blank. The contact previously received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention). The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the accessory protocol interface module (APIM) had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 31,000.
UNKNOWN OR OTHER10/03/2025
The dealership has done everything within their power to address my camera failure, and I want to be absolutely clear: this is not a dealer issue. This is a Ford issue. There is an active safety recall on the camera system, yet Ford has failed to provide a true fix. Selling vehicles with a known safety defect, acknowledging it with a recall, and then leaving customers without a resolution is unacceptable and irresponsible. The cameras were a deciding factor in my purchase, and their ongoing failure directly compromises safety. A recall without a repair is nothing more than empty words. Ford must deliver a real solution immediately, not continue to stall while customers are left driving unsafe vehicles.
BACK OVER PREVENTION10/01/2025
The contact owns a 2023 Ford Transit. The contact received notification of NHTSA Campaign Number: 25V315000 (BACK OVER PREVENTION). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the part was not yet available for the recall repair. The contact had not experienced a failure.
ELECTRICAL SYSTEM09/09/2025
This will be our second Balmar alternator that failed. The original alternator was replaced in March 2025 after the alternator basically melted. In April the new alternator was no longer charging the battery. It was finally serviced in July 2025. The dealership replaced a sensor and the recall to reduce the alternator output was performed. The recall was supposed to prevent the alternator from failing,however, two days later the alternator was no longer working. August 2025, the dealership has been discussing the issue with Winnebago and Balmar. September 2025 it was confirmed that the alternator needs to be replaced. This is a huge safety issue since the alternator will create a fire under the hood which was the case in our first incidence. This is also a continuos problem with the Winnebago Ekko’s and a solution should not be to keep replacing the alternator with the same exact make and model.
Showing 12 of 53 complaints.