SEAT BELTS05/11/2026
Attempting to purchase a Midwest Automotive Designs, Patriot RV on Ford Transit chassis. The rear seat belts installed by the RV manufacturer for rear passenger seating have been removed but dealership refuses to replace them. The dealer is offering this vehicle for sale without required safety equipment. I believe this is a violation of DOT law ?
SUSPENSION,WHEELS05/01/2026
The rear axle snapped and rear tire separated and rolled behind vehicle on the expressway causing the potential for injury/fatalities to our driver and surrounding passenger vehicles by recall 24S05. At no point did we receive communication from Ford that the vehicle should not be operated. We scheduled the recall repairs for next week, 5/4/26 however this morning, 5/1/26 the rear axle snapped and the tire fell off of the vehicle. The vehicle has been towed to Roche Ford in Bensenville for repairs. The recall has been well documented and has thus far caused 285 incidents and 1 accident prior to our issue this morning. There were no indicator lights or messages to indicate an issue.
POWER TRAIN,ELECTRICAL SYSTEM,ENGINEfire04/01/2026
On March 11, 2026, a 2024 Ford Transit (VIN: [XXX] ) was being operated under normal driving conditions when the check engine light began intermittently activating. Shortly thereafter, the vehicle experienced a sudden loss of dashboard functionality. While attempting to safely maneuver to the shoulder, the operator experienced loss of power steering and reduced braking capability. During this time, flames were observed originating from the engine compartment. The operator was able to safely pull the vehicle over, exit, and contact emergency services. The vehicle subsequently became fully engulfed in flames and was completely destroyed. No injuries were reported. A preliminary fire investigation determined the area of origin to be the passenger side of the engine compartment, with evidence of possible electrical involvement. The specific failed component has not yet been identified. This incident created a significant safety hazard due to the sudden loss of vehicle control systems combined with an active vehicle fire during operation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
STRUCTURE03/17/2026
Fuel filler door hinges continues to break and the consumer has to pay for a new housing unit. The hinges can break at anytime and the fuel door can become a potential issue while driving. It can break all the way off and hit another vehicle while traveling on the road/ Highway. The problem has been confirmed by the dealerships as they always have back-stock of new units to replace. There is no warning as to when it breaks at all.
POWER TRAIN01/16/2026
While traveling straight at approximately 30 miles per hour, the front differential locked, causing the front wheels to lock and abruptly stopped the vehicle. Vehicle was towed to a Ford dealership, which verified the differential failed, and not due to lack of lubricant. There were no symptoms prior to failure. The abruptness of the stop caused the operator to suffer whiplash like symptoms.
WHEELS11/18/2025
See the attached video..the car was not serviced before..this the assembly factory negligence..they didn't secure the nodes properly
UNKNOWN OR OTHER10/09/2025
My backup camera goes black and radio buttons do not work when this happens. They replaced apim and harness wires but did not solve the problem. They say they cannot replace radio because not on recall list. My van is under warranty. My van has the same issue as the recalls but not on the list. I've been having this issue since I bought the van. It needs to be on the recall list so I can get this issue fixed.
BACK OVER PREVENTION09/12/2025
The contact owns a 2024 Ford Transit. The contact received notification of NHTSA Campaign Number: 25V315000 ( BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
AIR BAGS,STRUCTURE,SERVICE BRAKES09/10/2025
A car dealership sold me a brand new vehicle that had an open recall.
BACK OVER PREVENTION08/28/2025
The contact owns a 2024 Ford Transit. The contact stated that he was unable to rent the vehicle on Turo. The contact received information on NHTSA Campaign Number: 25V315000 (Back Over Prevention). The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was contacted; however, only a recorded message was available. The contact had not experienced a failure.
BACK OVER PREVENTION08/26/2025
The contact owns a 2024 Ford Transit. The contact stated that while in reverse(R), the rearview camera displayed either a blank or a distorted image. The vehicle was taken to a dealer, where a software update was performed on the vehicle; however, the failure returned soon after the software update. The contact then received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 6,174.
FUEL SYSTEM, GASOLINE07/22/2025
The contact owns a 2024 Ford Transit. The contact stated that while driving at various speeds; an abnormal fuel odor would leak into the interior cabin, which caused health issues. In addition, the contact stated that while stopped around other vehicles in daily traffic, the exterior exhaust fumes would leak into the interior cabin of the vehicle. No warning lights illuminated. The contact sought medical attention for vomiting and severe dehydration due to a high carbon monoxide poisoning level of 2.6 as a non-smoker. Upon further inspection, the contact noticed a leak on the passenger side manifold and under the flexing coupling. The vehicle was taken to 3 separate dealers, where the vehicle was declined to be diagnosed. The vehicle was then towed to a local dealer, where it was diagnosed; however, no failures were identified. The manufacturer was made aware of the failure. The failure mileage was approximately 12,000.
Showing 12 of 26 complaints.