SERVICE BRAKES07/01/2026
Trailer brakes continuously fault due to known problem GM technical bulletin 23-NA-149 This should be a recall. Nothing but the runaround getting it fixed by GM.
ELECTRICAL SYSTEM,AIR BAGS,STRUCTUREfire06/12/2026
While driving I saw smoke and when I pulled over I seen fuel leaking from the gas tank area. Where it was leaking it ignited and the fire department had to put out the fire and the truck is totaled
UNKNOWN OR OTHER,ENGINE04/22/2026
Coolant leak observed at the upper radiator hose quick-connect fitting. The leak appears to originate from the internal seal at the radiator inlet connection. This issue developed without warning and is consistent with a known defect in the radiator hose seal design used in 2023 GMC Canyon vehicles. Vehicle experienced coolant loss and visible residue at the connection point. No visible external damage to the radiator or hose assembly was observed. GM has issued a Special Coverage program for similar radiator inlet hose seal failures in related vehicles using the same component design. Concern is that this defect may lead to coolant loss and potential engine overheating if not addressed.
ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE03/05/2026
The contact owns a 2023 GMC Canyon. The contact stated while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the automatic emergency braking (AEB) unexpectedly engaged. The message "Reduce Acceleration Proceed with Caution”, and the check engine warning light was illuminated. The vehicle was turned off and restarted and returned to normal functionality. The contact stated that the vehicle was nearly rear-ended. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V133000 (ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 9,300.
ENGINE02/25/2026
The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 37K miles). You can check the Colorado Chevy and GMC Canyon forums, youtube, Facebook, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and that I am responsible for the repair. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.
ENGINE02/17/2026
Upper radiator hose gasket leaks at connection point to radiator and no gasket replacement part. GMC forces you to buy entire hose
UNKNOWN OR OTHER,ENGINE02/17/2026
Top radiator hose is leaking coolant. Radiator hose O ring appears to be faulty.
UNKNOWN OR OTHER,ENGINE01/19/2026
Upper radiator hose is leaking
ENGINE12/18/2025
Noticed a coolant leak on drivers side and took to dealership was told was the upper radiator hose but was unable to make repairs due to national backorder and only suggestion was to drive until parts come in and keep a check on the coolant level, My truck only has 28,708 miles and shouldn't have to keep an eye on coolant level I feel that is very unsafe
ENGINE12/08/2025
The upper radiator hose on a significant number of these trucks is failing prematurely. In my case, the failure occurred at just over 35,000 miles. Numerous reports on owner forums (such as the Colorado Chevy / GMC Canyon forum), YouTube, and other platforms document the same issue, indicating this is not an isolated incident but a widespread defect. Because this hose is part of the cooling system, its failure can quickly lead to engine overheating and potentially catastrophic engine damage. The root cause appears to be an engineering flaw in the sealing method: GM uses a rubber seal instead of a durable, high-quality o‑ring to connect the upper hose to the radiator. Despite the seriousness of this defect, my local GMC dealer informed me that—since it is not currently a recall item—they could only schedule service for the following week, requiring me to leave the truck with them for 7–10 days before repairs would be completed. This is unreasonable for consumers who rely on these vehicles daily. Given the safety implications and the potential for engine failure, this issue warrants immediate attention. It should be classified as a recall item. Thousands of examples are already documented online, and GM’s own repair data would likely reveal thousands more instances of this same failure.
ELECTRICAL SYSTEM11/28/2025
The whole radio screen and dashboard have gone completely black and will not come on. Can not see anything. Took it to GMC dealership mechanic. Mechanic did diagnostic and said he didnt know what was wrong with it. Update did not work.
STEERING,VEHICLE SPEED CONTROL,SERVICE BRAKES11/07/2025
While driving at 70–75 mph on an interstate, my vehicle suddenly displayed a “Brake Failure” warning and limited speed to 62 mph. Power steering failed completely, and braking became ineffective despite hard pedal pressure. Multiple warnings followed: ABS, engine, and others. I was in heavy traffic with vehicles at full speed. Loss of braking and steering control forced me to coast across lanes to the shoulder, narrowly avoiding collision. My safety and that of others was at extreme risk. After stopping, I turned the vehicle off for ~30 seconds. Upon restart, all systems returned to normal—no warnings or issues. This indicates a transient software malfunction, not mechanical failure. No prior warnings or symptoms occurred. The problem has not been reproduced or confirmed by a dealer/service center. I have not scanned or inspected the vehicle. It has not been examined by the manufacturer, police, or insurance. The vehicle is in my possession and available for inspection upon request.
Showing 12 of 54 complaints.