ELECTRICAL SYSTEM04/17/2026
Component Involved: Hybrid Propulsion System High Voltage Battery / EV Battery Electrical System Power Train Incident Summary: I am reporting a serious and repeated safety defect involving my 2015 Hyundai Sonata Hybrid. This vehicle has experienced three separate incidents where warning messages related to the EV/hybrid battery system appeared, followed by a sudden loss of forward propulsion. During these events, the vehicle would not move properly or lost the ability to accelerate safely. This defect creates a major safety hazard because it can occur while driving, increasing the risk of being rear-ended, stranded in traffic, collision, injury, or property damage. I transport my small children in this vehicle and no longer feel it is safe. Detailed Timeline: Initial Incident: Vehicle displayed warning messages involving the EV/hybrid battery system and lost the ability to move forward properly. Vehicle had to be shut off and restarted. Independent Mechanic Inspection: Vehicle was inspected by an independent mechanic who advised the hybrid battery system likely needed repair or replacement and recommended service through Hyundai dealership. Dealer Visit #1 – Stew Hansen Hyundai (3/18/2026): Vehicle was taken to authorized Hyundai dealer for diagnosis. Dealer stated they could not duplicate the issue and no repair was made. Second Failure: After release from dealer, same dangerous loss-of-power condition occurred again, resulting in towing and additional inconvenience. Dealer Visit #2 – Stew Hansen Hyundai (4/8/2026): Vehicle returned to dealer for same issue. Dealer performed software update and stated this should correct problem. Dealer advised vehicle had been driven approximately 40 miles and was safe to release. Third Failure (4/12/2026 approx.): Only two days after picking vehicle up on 4/10/2026, same warning messages and propulsion failure occurred again. Safety Concern: This repeated loss of propulsion without warning is extremely dangerous.
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM04/11/2026
Idle and warning to not drive, 2025 very subtle cut off now full warning
ELECTRICAL SYSTEM,AIR BAGS,SERVICE BRAKEScrash02/12/2026
We pulled up at Hillgreen circle Cockysville MD To drop my boyfriend off at his apartment. I went to pull in the parking spot.I went to put the car into park and it had no brakes. I was slamming them and pumping them. It excellerated and took off. Jumped the curb,went down the hill and into the apartment building. A red light had came on the dash, right before it took off. Seemed like it was changing to gas or the electric mode,or the other way around. The airbag on the passenger side came out deflated,and filled with smoke going into the car. He was the belted front passenger and his elbow went in to the front window. You can tell by looking at it,the hole and spidered around it. He broke his right elbow. It is available anytime at the moment. It's at Hyundaii in Glen burnie. I need to get it to state farms lot,to get the Kelly blue book value. We look forward to hearing from you
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLINGfire04/10/2025
The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving 5 MPH and making a left turn, the vehicle made an abnormal knocking sound. The contact stated that upon pulling into an apartment complex parking lot, the contact noticed that there was smoke coming out from underneath the hood. There was no warning light illuminated. The contact immediately parked and exited the vehicle. The contact stated that upon opening the hood, the contact noticed a small fire and was able to extinguish the fire with a water bottle. The contact was able to push the vehicle into a parking space with the assistance of her son. There was no injury sustained. No police report was filed. The vehicle was towed to an independent mechanic, where it was diagnosed that a fluid leak from an unknown hose had caused the fire, and there was a hole in the engine block. The contact also stated that there was a puddle of fluid on the ground. The vehicle was not repaired. The contact became aware that the VIN was included in NHTSA Campaign Number: 23V651000(Service Brakes, Hydraulic), which the contact related to the failure. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 115,395.
ELECTRICAL SYSTEM,ENGINE AND ENGINE COOLING10/09/2024
The contact owns a 2015 Hyundai Sonata Hybrid. The contact took the vehicle to the dealer to be repaired under NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) and Manufacturer recalls: 964 (Auxiliary Canister Installation), 966 (Engine Monitoring Module, ECU Software Update), and 994 (Hybrid Safety Fuse). The contact stated that after the repairs were completed while attempting to start the vehicle at the dealer, the vehicle failed to start. The vehicle remained at the dealer who was unable to determine the cause of the failure. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the vehicle was not covered under warranty for any further repairs. The failure mileage was 170,000.
ELECTRICAL SYSTEM07/29/2024
The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, a message advising to pull over and to park the vehicle was displayed. The vehicle was taken to the dealer for diagnostic testing several times. The dealer replaced the HECU and the battery inverter assembly; however, the failure persisted. Additionally, the contact stated that while his son was driving at an undisclosed speed, the contact's son noticed that there was white smoke coming from the rear middle seat of the vehicle. An unknown warning light was illuminated. The contact's son pulled to the side of the road and turned off the vehicle. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the hybrid battery pack had failed, causing the hybrid battery to melt. The dealer determined that the hybrid battery pack needed to be replaced. The vehicle was not repaired. The contact related the failure to Hyundai Campaign Number: 994. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 37,000.
SERVICE BRAKES, HYDRAULIC04/22/2024
The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving 45 MPH, the vehicle started overheating, and smelled an abnormal electrical burning odor inside the cabin. Several unknown warning lights were illuminated. The contact veered to the side of the road, turned off the vehicle and inspected under the hood. The contact stated that the vehicle failed to restart and was towed to the residence. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) which he related to the failure. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
SERVICE BRAKES, AIR,POWER TRAIN04/16/2024
The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the message "Turn off the Engine Immediately" was displayed. Several unknown warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. Later, the contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart with several unknown warning lights illuminated. The vehicle was towed back to the dealer, who then diagnosed failures with the ABS and transmission. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.
SERVICE BRAKES, HYDRAULIC01/10/2024
The contact owns a 2015 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available. A person stated the wrong email address is listed, never filed a complaint.
POWER TRAIN11/27/2023
The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, several unknown warning lights were illuminated. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard. The contact stated that the warning light to turn off the vehicle was illuminated. The contact turned the vehicle off and the vehicle failed to restart. The vehicle was towed to the dealer; however, the dealer refused to service the vehicle. The vehicle was then towed to the residence. The vehicle was towed to another Hyundai dealer where the vehicle was diagnosed with a failed transmission and battery. The contact was informed that the transmission and battery needed to be replaced. The vehicle was repaired. The contact stated while driving away from the dealer, she heard an unusual knocking sound coming from the engine compartment. The vehicle was taken back to the dealer. The service technician accompanied the contact for a test drive and confirmed the knocking coming from the engine compartment. The contact was informed that the new transmission that was installed was defective, and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,680.
SERVICE BRAKES, HYDRAULIC11/27/2023
The contact owns a 2015 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
SERVICE BRAKES, HYDRAULIC,HYBRID PROPULSION SYSTEM11/20/2023
The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while stopped in traffic, the vehicle independently jolted with a message indicating a Hybrid System safety failure. Additionally, there was a message to stop driving the vehicle with an alarm sounding. The contact veered to the side of the road. The contact was able to continue driving. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) the following day; however, the part to do the recall repair was not yet available. The contact stated that the failure recurred while driving. The contact veered to the side of the road. The vehicle was then taken to an independent mechanic, where it was test-driven; however, the mechanic was unable to duplicate the failure. The local dealer was contacted and informed the contact that the earliest availability was on December 23, 2023. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,500. VIN tool confirms parts not available.
Showing 12 of 50 complaints.