ELECTRICAL SYSTEM06/22/2026
I purchased this vehicle pre-owned approximately two years ago and have since developed concerns about its reliability, particularly related to the electrical and hybrid systems. In hindsight, I suspect these issues may be part of the reason the original owner traded it in to a CarMax dealer. Shortly after purchasing the vehicle, I began experiencing recurring problems with the 12V battery, including frequent instances requiring battery resets. Interestingly, these issues were significantly less frequent during colder weather. More recently, as temperatures have increased, the problem has worsened considerably. For about the past month, the vehicle loses power and dies immediately after each drive once the ignition is turned off. This situation escalated yesterday when the “Check Hybrid System” warning light signalled while I was driving on a busy road. I had not encountered this warning before, but after researching the issue, I discovered that other Hyundai hybrid owners have reported similar problems. In some cases, these issues have led to dangerous situations, including vehicles shutting off unexpectedly while driving at highway speeds. While I cannot determine the extent of this issue across all Hyundai hybrid vehicles, the frequency of similar reports suggests a systemic defect affecting at least a subset of Hyundai Sonata Hybrid models. Regardless of scale, these battery issues present a significant inconvenience and a serious potential safety concern. I am requesting a formal review of this issue and guidance on potential remedies or corrective action.
ELECTRICAL SYSTEM05/22/2026
The vehicle’s 12-volt electrical system repeatedly loses power within about 1 hour of sitting. The car becomes completely unresponsive (cannot unlock or start) and requires use of the built-in 12V battery reset button to restore power. This occurs frequently and makes the vehicle unreliable and potentially unsafe, as the car may become inoperable without warning. This appears to be an electrical system defect or parasitic power drain. The issue has been ongoing.
ENGINE AND ENGINE COOLING04/09/2026
See attached document for complaint.
ELECTRICAL SYSTEM08/11/2025
Owned car since 09/2024 with 64K miles. Battery system (12V/hybrid system) has shut down and died 47 times since 04/2025 - no shut downs before then. Car with ~69K miles at that time. Dealer had car six weeks (05/17 to 07/05/2025) and it died “a number” of times and report that Hyundai claims this is “what the car is supposed to do.” Since 07/05 it has died 12 times just sitting in my driveway or the lot at work. This is NOT normal. Internet blogs show DOZENS of other Hyundai hybrid owners reporting the exact same issue. Car now with 75K miles and under warranty. Dealer will not replace battery system.
ELECTRICAL SYSTEM07/28/2025
This is on my 2021 Hyundai Sonata Hybrid Limited - for the 7th time the vehicle has been completely dead and unresponsive. I have had to gain entry to the vehicle using the manual key and press the "jump" button to get the vehicle to start. The Hyundai dealership ran a bunch of battery updates to the 12 volt battery several weeks ago and said that should hopefully fix the issue. Several weeks later on 07/19/2025 the vehicle was dead again. I had to use the key to manually gain entry and jump the car again. The dealership said that the 12 volt battery may need to be replaced and said that it is fully integrated with the hybrid battery system which is covered for 10 years/100K miles whichever comes first. I am still within the warranty period so hopefully Hyundai will fix the issue. From an online search, it appears this is not an uncommon issue with the Hyundai Sonata Hybrid. I am waiting on Hyundai for a fix and for .
ELECTRICAL SYSTEM07/10/2025
What component or system failed or malfunctioned, and is it available for inspection upon request? RANDOM TOTAL ELECTRICAL FAILURE (DOORS WON'T UNLOCK, CAR UNRESPONSIVE) How was your safety or the safety of others put at risk? DIFFICULT TO GAIN MANUAL ENTRY TO CAR, PARTICULARLY IN DARK SITUATIONS Has the problem been reproduced or confirmed by a dealer or independent service center? NO, I HAVE TAKEN THE CAR IN FOR SERVICE TWICE AND THE ISSUE HAS NOT BEEN CORRECTED. THE CAR IS BACK AT THE DEALERSHIP NOW FOR A THIRD ATTEMPT. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO As a reference: [XXX] Key Takeaways from the Thread: Several 2021 Hyundai Sonata Hybrid owners (and a few Ioniq and Elantra Hybrid owners) are reporting the exact same symptoms: Random total electrical failure (doors won’t unlock, car unresponsive) Requires manual key to enter 12V battery reset button inside vehicle restores power No error codes or permanent fixes from dealerships Issue occurs sporadically, making it difficult to replicate or diagnose Some dealers have replaced the 12V battery or DC-DC converter, but results are mixed No formal recall exists yet, despite growing reports INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ELECTRICAL SYSTEM06/30/2025
Every day the car is dead, have to take the manual key out pop door cover off unlock car manually push the 12v reset button and hold fob to start/stop button for car to work again. Happens daily.
ELECTRICAL SYSTEM05/27/2025
12v battery dying randomly
ENGINE04/25/2025
Air flow check engine light alerted and source was faulty fuel injector which required replacement of 4 fuel injectors.
ENGINE03/09/2025
Overheated engine alarm came on while I was on the freeway on a rainy day. Vehicle was towed to Hyundai dealership in which service technician found that the part preventing water from leaking into the muffler was broken. Hyundai dealership has ordered replacement part but it is on backorder. The broken part that needed replacement has been on backorder for close to a month and there is not an ETA of when the part will be received. Prior to the overheated engine alarm going off, cold air was blowing out of the vents even when the heat option was selected.
ENGINE03/05/2025
Coolant system leaks in to the engine or exhaust system, which is evident in white smoke exhaust and coolant level dropping. In my situation, I required an entire container of coolant to perform a daily commute, and the reservoir was empty by the time I made it to the dealership. Car is rendered undrivable due lack of coolant and engine overheating. My car was in the dealership repair facility for 6 weeks awaiting parts on back order due to nationwide shortage. A technical service bulletin has been issued for this manufacturer defect (23-EM-009H). Cost of repairs was roughly $2,300.
UNKNOWN OR OTHER,ENGINE01/19/2025
My 2021 Hyundai Sonata Hybrid seems to be leaking coolant into the exhaust system. Various reports online indicate that this is a consistent issue with 2020-2022 Hyundai Sonata Hybrid models. A lot of the reports indicate that owners have tried getting theirs cars repaired for the same issue I have a various dealerships all across the US, but either haven't had any luck or have had a temporary fix for the issue, which proceeded to occur again every couple of months. I personally have had my car inspected by my personal dealership and they have confirmed the issue and have mentioned that other owners have brought theirs in to be checked out, but haven't really had luck. I believe that Hyundai should take responsibility for this and issue a recall on the affected models. I bought the car in good faith hoping for reliability but haven't had it for even 6 months now and this problem is here. For safety or myself and others on the road, this models of the Sonatas need to be recalled and repaired IMMEDIATELY. For reference, here is a reference for the complaints people have made online regarding the vehicle: 1. [XXX] 2. [XXX] . (THE RESPONSES HERE ARE VERY DETAILED) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Showing 12 of 52 complaints.
