2 complaint-reported fatalities on this model.
ENGINE07/15/2026
Engine experienced mass, sudden oil consumption with no warning of any sort, resulting in significant engine damage. Oil had been changed apx 800 miles prior to incident, and vehicle showed no signs of leaks or oil consumption following the oil change. No oil leaks or wetness were found around oil filter or drain plug. Vehicle drove perfectly fine one day, and when started to leave a store it began horrendously knocking, despite operating as normal on the drive to the store. Dipstick was completely dry. No engine warning light was triggered, no low oil warning, etc. I contacted Kia America directly, as I had found examples of this same issue reported online and hoped for some cooperation, and was given a generic response to haul it to the nearest Kia dealership for diagnosis and repair, out of my own pocket.
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES07/10/2026
The contact owns a 2016 Kia Sedona. The contact stated that the climate control panel became inoperable, failing to distribute heat and air conditioning. While the middle and third-row climate systems functioned, an abnormal burning odor was detected. The fan speed adjustment button experienced an electrical short, and upon removing the climate control panel, the wiring harness was found burnt. The contact stated that the climate control panel was previously replaced. Additionally, the power sliding door was inoperable. No warning lights illuminated. The contact related the failure to NHTSA Campaign Number: 19V109000 (Electrical System); however, the VIN was not included in the recall. The vehicle was taken to a local dealer but was not diagnosed or repaired. The vehicle was then taken to an independent mechanic, who determined that the failure was caused by the climate control panel. The manufacturer was not notified of the failure. The failure mileage was approximately 159,259.
Insert, Padding,Other/I am not sure07/07/2026
The Styrofoam is cracked in half on two sides and it's losing pieces when I contacted the manufacturer. They said they were sending me tape and I don't feel that's very safe. That is the only solution they are offering me. This has had a recall previously. They said this is what you've approved as a fix to the recall. I just wanted to check on this because I don't feel it's very safe for me to tape my child car seat back together especially since there's pieces missing chunks and the Styrofoam is completely cracked in half. I could separate the two pieces and they're telling me to tape it back together.
ENGINE06/25/2026
Engine failure due to loud knocking as a result if high oil consumption. No warning lights ever. Needs replacement. Regular maintenance records available. Original owner with only 63900 miles in less than 10 years. Vehicle supposed to be under powertrain warranty (10 years/ 100000 miles). Kia and dealership keep denying warranty claim despite providing all records to prove regular maintenance.
FUEL/PROPULSION SYSTEMfire05/02/2026
While driving car gas tank blew a hole and started on fire. Car then lost power while on fire while I was in traffic, luckily I was able to cut into a parking lot and people that were in traffic with me call 911. Fire department confirmed there was a hole in gas tank which sits right underneath driver side. Fire was only contained to where the gas tank and lines are. I have pictures.
ENGINE04/26/2026
Oil was changed and within a month was completely dried with no visible leak and without any warning or lights the engine shut off while driving and seized Turner Kia performed a thorough diagnostic and determined that will cost $13,508.90 to replace the engine.
AIR BAGS,UNKNOWN OR OTHER04/21/2026
This concerns an unresolved airbag safety issue that went undetected due to a negligent recall inspection at a Kia dealership. On March 16, 2026, I brought my vehicle to Ed Voyles Kia of Chamblee, GA for a recall inspection to determine whether damaged wiring under the passenger seat was causing my airbag warning light to remain on. I dealt with the service advisor throughout the process. After the appointment, I was told the inspection was complete and no wiring damage was found. Upon leaving the dealership, I immediately noticed that my exterior and interior lights, radio, seatbelt indicators, and numerous other systems had stopped working, none of which were issues before my appointment. I contacted the dealership the same day and returned on March 17, 2026. The service advisor relayed the technician's position that these failures were pre-existing and unrelated to the service. After I pushed back, the manager became involved and pointed to a separate BCM recall to explain the replacement, rather than acknowledging that the BCM had failed immediately after their service. My BCM had been functioning normally before the appointment. The service advisor and manager continued to deny any wiring damage. On April 20, 2026, I personally inspected the area under the passenger seat while cleaning my vehicle I immediately found visibly damaged wires, the exact area the technician had examined during the recall. I found this damage within minutes. The damaged wiring under the passenger seat is the very issue this recall was designed to identify. The technician failed to find it, leaving a known safety hazard unresolved. My airbag warning light has been on since before the appointment and remains on today. I have been driving my family in this vehicle with a compromised airbag system. I have photo evidence of the damaged wires and request that NHTSA log this as a formal safety complaint and investigate if this reflects a broader pattern of incomplete recall inspections
ENGINE04/20/2026
Engine has multiple engine miss fires. Loss of coolant into exhaust. Engine knocking.
ENGINE04/13/2026
Since the day a bought the car I have had to constantly deal with oil leaks and burning up oil. We had to check the vehicle every Sunday for oil replacement. The vehicle on one day just stopped in the middle of the street. It had a complete engine failure. I had to pay thousands of dollars. I contacted Kia with out help. They claim my vehicle was not part of their class action settlement of engine failure. And I can’t sell the car because all mechanics know the engine is trash and the vehicle is worth nothing. And Kia won’t help at all.
ENGINE04/03/2026
I am the original owner of a 2016 Kia Sedona, purchased new from the DeMontrond Kia dealership in Houston, Texas, in August 2016. The vehicle currently has 63,400 miles and has been maintained according to standard schedules. Two weeks ago, I noticed a slight knocking sound and took the car to the dealership for an inspection. I was informed that there is sludge buildup in the engine and was told the repair would not be covered under warranty due to alleged owner neglect. The dealership quoted $10,000 for an engine replacement. Prior to this, there were no warning lights or indicators of any issues, and there have been no oil leaks. I have retained most of the records and receipts for the oil changes performed on the vehicle.
ENGINE03/25/2026
Engine started knocking loosing power just like our 4cylinder GDI engine. These engines are also not safe to be operating
ENGINE03/24/2026
Engine Failure due to rod and bearing failure
Showing 12 of 289 complaints.
