2017 Lincoln MKZ HEV

I am paying on a 2017 Lincoln MKZ with total engine failure due to coolant leaking into it. I am aware that NHTSA in early October 2023 there was an investigation into more than 700000 late model Ford due to catastrophic engine failure. Why was people not informed on this matter, or a recall established.

The contact owns a 2017 Lincoln MKZ. The contact stated that upon starting the vehicle, the check engine warning light remained illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the engine had failed due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.

Vehicle began to feel as if it was losing the ability to get any power to the engine. I would push the pedal to accelerate but even fully compressed the vehicle would not go above 30mph. I attempted to drive the vehicle in to be inspected at a dealership and while on the way the steering wheel completely locked and an Emergency Light appeared on the dashboard stating "Safely Park Vehicle". It was a Horrifying Experience to be driving In traffic and lose control of the vehicle but luckily I was able to coast the vehicle to the side of the road to safety without crashing! Although the vehicle was fully powered, it would not move and I had to call AAA in order to get the vehicle towed to the closest AAA Approved facility which was AutoWorks Diagnostics & Repair in Kittery, ME. They observed fluids had leaked out but were unable to locate where the leak was coming from and very Loud Noises that appeared to be coming from in between the Engine and Transmission . After researching online they found that there were Two Recalls involving the welds on the Torque Converter detaching from the engine. They also found a recall on the front brake hoses rupturing & leaking brake fluid as well as a Recall with the steering wheel retaining bolt loosening & detaching while driving which could also have contributed to the issues experienced with the vehicle and the safety concerns associated as I was driving in traffic and lost Total Control of the vehicle which could very likely have caused a Major Accident! Unfortunately None of these recalls have been associated with the VIN connected to this vehicle and the manufacturer; Lincoln, to this point has refused to discuss any of the issues having to do with the four recalls being associated to my specific 2017 Lincoln Hybrid Premier 2.0L gas engine with 6 speed transmission although this specific year, make & model has each of these reported recalls.

When I stop at a stop sign & then turn right, my steering wheel locks up. It does clear up after trying to turn it but I’m stuck in traffic & cannot move because the steering is locked. This happened twice in 4 days. Brought car to dealership & they never heard of this.

Transmission slipping, side airbags deployed, seatbelt cut, TPMS light on, unsafe to drive.

I purchased my 2017 Lincoln MKZ Select on November 11, 2024. The vehicle was determined to need a new engine, per Murgado Lincoln of Chicago. They had my car for over 48 days while putting in a new engine. After this was completed the car had to be sent back due to a mistake the mechanics made by not attaching a gasket properly. After this, I began experiencing odd noises underneath the hood and throughout the vehicle; delayed timing belt in both acceleration and deceleration, and so forth. I was then involved in a hit-and-run car accident (not my fault). All side airbags deployed and my passenger side rear wheel is destroyed. I had this car assessed just a few days ago by a certified Auto Care Company who said I needed a completely new transmission and that this car is not street legal at the moment... insurance is not helping me at all.

At any given time without warning the car will down shift into 4, 3, 2, or 1. It is intermittent but in the last 3 weeks has become very frequent. I have taken it to the dealership. They state that it is the internal clock spring in the the steering column. They have told me that my power train warranty and/or technology extended warranty will honor the replacement, so I looked up possible recalls on this model vehicle and found there is in fact a recall on the steering column internal clock spring but the concern was on the airbag. The issue I am having with the downshifting is going to cause someone to rear end me. There is no pre-warning. I have driven on service roads, the interstate, my neighborhood streets, and on highway. It seems to happen more as I am following the curve of the road, or when I am turning or changing lanes/merging onto interstate. If I am at a complete stop and turn either left or right it will downshift to 1. I am also concerned to the extent of damage this may be doing to my transmission and engine, as it happens during speeds of 45 to 75 mph on the highways and interstate. I do have video on my phone of this behavior and I can send it to you if I have an email address you have access to. I have placed the most current date of this behavior in the incident box, however this has happened numerous times over the past few months, It just wouldn't give a code to any dealerships for diagnosis.

I am submitting this complaint to formally report that my 2017 Lincoln MKZ experienced engine block damage due to a failed torque converter weld, a known safety defect covered under NHTSA Recall 17V-427 / 18V-390 (Ford campaign 17S16). This recall specifically affects vehicles like mine equipped with a 2.0L gas engine and 6-speed automatic transmission, due to improperly welded torque converter studs. This failure causes loss of power and potential transmission or engine damage—precisely what occurred with my vehicle. When I brought my vehicle to an authorized Lincoln dealership in Alexandria, Virginia, the service department refused to cover the cost of repair, despite the vehicle falling within the recall parameters. Their refusal directly contradicts federal recall law (49 U.S. Code § 30120), which mandates that manufacturers and authorized dealers must remedy safety defects at no cost to the vehicle owner, regardless of ownership history or age. As a result of their denial, I am left with significant out-of-pocket costs for damage that should be addressed under a federally mandated safety recall. This poses both a financial burden and a public safety risk if other owners are similarly turned away. I am requesting that NHTSA: Investigate this dealership’s noncompliance with federal recall obligations. Ensure that Ford Motor Company and its authorized dealers are held accountable for safety-related repairs. Assist in compelling the dealer to honor the recall and reimburse or cover the cost of required repairs.

The contact owns a 2017 Lincoln MKZ. The contact stated while driving at an undisclosed speed, the engine seized, with the check engine warning light illuminated. The vehicle was taken to the dealer and the contact was informed that a tune-up was needed. The vehicle was not repaired. The vehicle was taken to an independent mechanic who performed the tune-up. The vehicle was repaired; however, the failure reoccurred. The vehicle was towed to the dealer and was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 107,500.

Ford have a Huge problem with the 2.0 ecoboost. Where coolant pass through the cylinder and make engine mix oil and coolant. Ford have a thousand of claim about this and still doesn’t have any solution and they make customer pay everything

While driving the car in commuter traffic on Route 22 Highway the car transmission stopped working and car bucked and then stopped. Upon getting out of the lane of traffic there was a large amount of transmission fluid on the ground. Car had to be towed as it would not move. Danger was the car stopping on the highway in busy traffic. Upon inspection by car dealer they found it had a broken transmission cooler line . The Lincoln dealer put in a Tube Assembly repair kit and replaced all trans cooler lines at a cost of $ 1,029.72 to me. No Warning lamps or messages came on before the lines broke.

The contact owns a 2017 Lincoln MKZ Hybrid. The contact stated that while driving 35 MPH, there was an abnormal sound coming from the engine. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,800.