WHEELS07/01/2026
The factory upgrade 21 inch spoke wheels with Pirelli P-Zero low profile tires are averaging a blow out every 800 miles. 5 flats and 2 sidewall blisters in the last 10,000 miles. Pirelli P-Zero 255/35/R21 Front and 285/30/R21 Rear are all four available for inspection if you tell me to save them before I replace them. There have been thousands of complaints and law suits re this issue just in the last 5 years on mercedes cars with low profile tires; to Mercedes, Pirelli, through legal discovery, to enthusiasts forums, and to NHTSA My first blowout was at 30 mph hitting a 1 1/2" deep pothole full of rain water. That one blew out the front right and blistered the sideall of the right rear at once. Then one of the new replacements blew on hitting a storm drain set 1" into the pavement on the way home from the dealership. I've been driving 60 years, and never had a single pothole blowout before now. Sidewall tears release all or most of the air at once creating an extremely dangerous situation. Somebody will lose control and hurt or kill someone, or behurt while stopped in an unsafe spot. Since the car can't be towed and has no spare, it is exteremely costly and inconvenient to replace a tire. It has cost me thousands so far, and left my disabled wife and me stranded beside the highway. Car is on a flat and one and a blister on a second tire right now in driveway. Best fix is to go to a square wheel/tire fitment using 19" x 8.5" wheels with 35 offset 66.6 mm bore on all four, all season radials. To keep outside diamter the same for the computer, 255/45/R19 /AS/ XL W and with acoustic tuning or dampening to match the quiet factory tires on these cars. 20" wheels is no good, because to maintain diameter would require the same too short 35 sidewall profile on two of the tires. Staggered 19 inch wheels will work, but the square fitment allows for tire rotaion and for the carrying of a spare. Maybe make that optional for replacement recall.
POWER TRAIN,SERVICE BRAKES,ENGINE04/19/2026
Vehicle: 2022 Mercedes-Benz S580 The vehicle is experiencing a severe and violent drivetrain "jolt" or "push" during gear transitions, specifically when shifting from 5th to 6th gear at cruising speeds. On multiple occasions, the jolt was so forceful that passengers believed the vehicle had been rear-ended by another car. This behavior is unpredictable and creates a significant safety hazard, as it causes a sudden change in vehicle momentum while driving in traffic. The issue has been reported to the authorized dealer (Fields Mercedes Lakeland) multiple times. The dealer kept the vehicle for over 40 cumulative days and performed motor/transmission mount replacements and "software calibrations," yet the violent shifting persists. Additionally, the engine produces an excessive vibration and loud noise during extended operation in high temperatures, which ceases only when the ECO/Auto-stop mode engages. I am concerned that the transmission or torque converter may fail abruptly while at highway speeds, potentially leading to a loss of propulsion or a rear-end collision due to the unexpected deceleration/jolt behavior. The vehicle is suffering from chronic oil consumption issues. The 'Check Engine Oil Level (Add 1 Quart)' message has appeared twice: once on 10/31/2025 and again on 04/17/2026. This is despite the vehicle being exclusively serviced by Mercedes-Benz Lakeland. This recurring engine issue, combined with the violent drivetrain jolts and shifting failures, significantly compromises the vehicle's safety and reliability."
STEERING,ELECTRICAL SYSTEM,SERVICE BRAKES02/11/2026
While driving a 2022 Mercedes-Maybach S680 at approximately 40 to 65 mph, multiple advanced driver assistance and safety systems suddenly became inoperative at the same time. The vehicle displayed warnings including Active Steering Assist Inoperative, Active Brake Assist Functions Limited, Active Distance Assist Inoperative, Blind Spot Assist Inoperative, Lane Change Assist Unavailable, and Emergency Stop Assist Unavailable. These warnings appeared while the vehicle was in motion and reduced steering support, braking assistance, and collision avoidance functionality. The failures occurred without warning and created a safety concern because critical driver assistance systems were disabled during highway driving. The problem has occurred more than once and affects multiple electronic safety systems simultaneously.
SERVICE BRAKES,FORWARD COLLISION AVOIDANCE01/22/2026
On multiple occasions, after the vehicle had been parked and not driven for approximately five days or more, the automatic parking brake locked in place and would not release. I attempted standard methods to disengage the brake, including manual release procedures and lightly rocking the vehicle, without success. The only way to release the brake was to apply significant pressure to the accelerator while in reverse, which caused the brake to suddenly unlock. The first incident occurred while the vehicle was parked in my home garage. At the time, my grandson was playing nearby. The sudden release of the brake after applying the accelerator created a dangerous situation and was extremely alarming. A second incident occurred several days later while I was on vacation. In this instance, I made sure no one was near the vehicle before attempting to release the brake. Anticipating the issue, I had my left foot ready to push on the breaks when I accelerated using my right foot which releases the parking. I brought the vehicle to a Mercedes-Benz dealership on January 5, 2026, where the car remained for nearly ten days. The dealership was able to replicate the issue exactly as described. The service advisor also had to apply significant accelerator pressure to release the locked parking brake. A certified Mercedes-Benz technician inspected the vehicle thoroughly, including scanning for fault codes and checking for rust or mechanical issues, but ultimately advised that this behavior was considered “normal operation.” I find this explanation concerning. Having to apply forceful acceleration to release a locked parking brake presents a clear safety risk, particularly in confined spaces such as garages or parking structures, and could easily result in property damage or personal injury
ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE,BACK OVER PREVENTION01/06/2026
Was driving the car at 3:00 P.M. and all of a sudden thr dash display when total black out nothing on the display screen. Speed,fuel,turnning singles nothing total black out. Took it to the dealership to fix as this can and would be a life threathing at loss of life could and can happen in a traffic sistiution
SUSPENSION,WHEELS,SERVICE BRAKES12/07/2025
Mercedes-Benz S580 equipped with 21-inch wheels has experienced numerous tire blowouts over the course of ownership — too many to count. The blowouts occurred during normal driving on typical roads. Several blowouts caused rim damage and created a dangerous situation, including moments where I nearly lost control of the vehicle. This appears to be a design defect involving the 21-inch wheel and low-profile tire configuration, which seems structurally inadequate for normal road conditions. The failures are recurring and not due to isolated hazards. Other S580 owners have reported identical issues with repeated blowouts on 21-inch wheels. This presents a serious safety hazard, and a permanent remedy is needed.
ENGINE AND ENGINE COOLING09/15/2025
The contact owns a 2022 Mercedes-Benz S 580. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and the engine stalled. The vehicle was taken to the dealer, where it was diagnosed with a failed CAM shaft solenoid. The contact was informed that the CAM shaft solenoid needed to be replaced. In addition, the contact was informed that the engine needed to be dismantled. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced an unknown recall with a similar failure description; however, the VIN was not under recall. The failure mileage was approximately 55,000.
STRUCTURE,VISIBILITY/WIPER09/10/2025
Subject: Report of Spontaneous Sunroof Explosion - Mercedes S580 2022 Model Dear National Highway Traffic Safety Administration, I am writing to report a concerning incident that occurred on [XXX] at approximately [XXX] while I was driving my 2022 Mercedes S580 to work on [XXX] N. During my drive, I experienced a sudden, loud explosion within the vehicle. Initially, I believed it was either a gunshot or that I had been rear-ended. In a state of confusion, I quickly pulled over to the shoulder to assess the situation. Upon closer inspection, I discovered that my sunroof had shattered spontaneously. I am certain that this was not caused by an external object, such as a falling stone. There were no overpasses, bridges, or surrounding traffic that could have contributed to the damage. This was an extremely frightening experience, and I believe it is important to bring this matter to your attention for safety considerations. I have also reported this incident to my local Mercedes-Benz dealership. Thank you for your attention to this serious safety concern. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE09/10/2025
Over ~3 years of ownership, the vehicle has experienced recurrent electrical and engine-management issues, resulting in 15+ service visits and ~100 cumulative days out of service at an authorized dealer. Patterns include: (1) electrical—keyless entry intermittently unresponsive, instrument cluster flickering/rebooting, multiple warning messages including a battery/electrical icon, HVAC/A/C becoming inoperative without cooling; and (2) powertrain/engine—check-engine light (MIL) illuminated, hesitation/limited power on initial acceleration, and rough operation after start. Safety risk: intermittent failure to unlock/start can leave occupants stranded; loss of power/hesitation creates risk when merging or crossing intersections; multiple warning messages/flicker are distracting; and loss of A/C in hot conditions has required operation with windows down to avoid heat stress. Reproduction/confirmation: The concerns have been observed by the dealer on multiple visits with fault codes recorded (codes UNKNOWN to me). Repairs/updates have been attempted, but symptoms recur after service. The vehicle has been inspected repeatedly by the authorized dealer and remains available for inspection upon request. Warnings/symptoms prior to failure: intermittent MIL, battery/electrical warning, cluster glitches/flicker, and A/C blowing warm air; some events followed periods where the vehicle would not unlock or start on the first attempt. Root cause: UNKNOWN.
SUSPENSION,WHEELS,SERVICE BRAKES07/27/2025
mechanical and safety-related failures observed in a Mercedes-Benz vehicle, specifically involving the suspension system, wheels, and braking components. Despite extensive repair efforts—including replacement of all four wheels and tires, complete AWD four-wheel alignment, and diagnostics performed at authorized Mercedes-Benz dealerships—the underlying issues persist. To date, the total cost incurred in attempting to remedy these defects exceeds $15,848. The vehicle and its components have been inspected by two independent Mercedes-Benz dealer service centers and a certified third-party auto inspection firm. All parties have confirmed, through drive testing and diagnostics, that the problems are reproducible and continue to impair vehicle safety and performance. The suspension and associated hardware have been identified as the root cause of instability and braking inconsistencies. These findings align with broader patterns observed in similar vehicles, suggesting a recurring defect that warrants intervention by the manufacturer. Despite clear evidence from multiple independent sources, the manufacturer has failed to initiate a recall or implement corrective measures. This failure poses an ongoing safety risk to operators and the general public. The vehicle remains available for further inspection upon request. Immediate attention to this matter is expected to prevent further liabilities and protect consumer welfare.
VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE03/31/2025
The following pictures will again show the issues that I'm having while driving my 2022 S Class Mercedes, while using the cruise control on the Belt Parkway. It shows me stuck in traffic and, although I can only go 11 miles an hour while I’m stuck in traffic, the cruise control wants to push it to 80 mph, which is indeed VERY VERY DANGEROUS!! as you can well imagine. Also, as you can see in the second picture, I have the cruise control set to 39 MPH. I have been writing for the past two months with no resolve as yet. The repair records speak for themselves and still Mercedes Benz offers no remedy. It would appear that it's going to take a severe accident or fatality to bring some type of action on your part to replace this vehicle, which is definitely a LEMON!!
VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE03/27/2025
Here we go again, while driving on a side road with a 20 mph school speed limit, the cruise control wants to SPEED UP to 60 mph!! WHAT IS IT GOING TO TAKE TO REMEDY THIS BEFORE I’M INVOLVED IN A SERIOUS ACCIDENT!!
Showing 12 of 45 complaints.