STEERING06/16/2025
The power steering system lost it's fluid and pump is cavitating. It's available for inspection. The vehicles can be steered at the moment, but if it were to fail completely, it could cause loss of control at highway speeds. The problem is ongoing but hasn't been presented to a dealer or independent service center. No, the this hasn't been inspected. There were no warning lamps or messages or symptoms prior to failure. NOTE: there is an existing recall for 2015-2020 Sprinter vans for this issue, however upon contacting the dealership, the 2016 model doesn't currently fall under this recall.
EXTERIOR LIGHTING,STRUCTURE07/29/2024
The primary issue is the seal on the air conditioning unit, which is on top of the Sprinter van. Prior to purchasing it, we read multiple reviews that the seal breaks frequently and water pours into the cabin. It is a known defect and quite prevalent. Whenever we drive through rain and the seal is intact, we get drips of rain. When the seal needs to be replaced, gallons of water pour into the cabin. Replacing the seal costs thousands of dollars and we've replaced it a few times. We travel with buckets and a dozen bath towels in case we drive through rain. Seals for the air conditioning unit only last about a year before a new one is needed. Our local dealership is aware that this a widespread problem on Sprinters but Mercedes is refusing to to fix the issue. Secondly, the interior lights do not work. We've had them replaced and they quickly stop working. I'm not certain how prevalent this issue is in other Sprinters, but it is an issue that does not appear to have a long-time fix on our model.
WHEELS01/23/2024
Had 2 rims develop cracks causing loss of air pressure in tires. 1st occurred at approx. 45000 miles (2019), 2nd occurred at 110000 (2023). Both failures occurred to area of rim where welds to lock in center (with lug holes) on outer rim (where tire sits) are situated. Both failures manifested as small air leak then suddenly crack increases in size dramatically to where tire can only hold air for a few hours before deflating fully
ENGINE07/17/2023
The check engine light came on in the Sprinter van. There is a Hissing noise coming from the engine when accelerating. The Sprinter van loses speed when on the highway. The vehicle could not keep up with traffic on the road. The Mercedes Benz dealer, Ft. Mitchell, Kentucky has inspected the vehicle and stated that it has a defective intake manifold. This vehicle has 140,000 miles at this time. At this time the van has not been repaired, the cost is $3132.77
STEERING,AIR BAGS06/12/2023
The contact owns a 2016 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags), 19V004000 (Air Bags), and 20V663000 (Steering) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
VEHICLE SPEED CONTROL,SERVICE BRAKES11/15/2021
There is a known issue and recall for wheel speed sensors on Mercedes Sprinter 3500 models. However, this same issue applied to 2500 models also. Along with other RV owners, I have just experienced this problem. I was in city traffic when all the sudden multiple warning lights came on: "ESP, visit workshop", "Brake force distribution, visit workshop", ABS warning light, ESP, warning light, collision prevention malfunction warning light, check engine light with fault code U0416. The presence of all these errors, beeping, red messages sounds extremely scary to any driver. The fact that it says brake force distribution isn't working properly suggests a hazardous condition that could lead to a crash if brakes are not working properly. Since this is being caused by a failing wheel speed sensor, these should all be replaced and the recall expanded to include other models like mine.
ENGINE11/15/2021
My 2016 Sprinter is suffering from a failing EGR valve that's causing intermittent power loss. The issue started after only 25000mi on the odometer. No errors are shown, nothing indicates malfunction. The problem is quite severe and presenting itself through random power loss. When accelerating the car will jerk and lose acceleration force suddenly. Driving uphill is the worst and producing constant jerking. Once moving at a good speed it's less notable but still present. The main safety concern is that the behavior is unpredictable and in situations where it's necessary to accelerate into a road with traffic, this can lead to a hazardous when the car doesn't accelerate as intended. In multiple occasions I was unable to properly speed up and get moving and thus blocking traffic behind me and forcing them to slow down or change lanes. The Mercedes dealer diagnosed a malfunctioning EGR valve on the edge of failing completely which would put the Sprinter in "limp home mode" which has limited power output to prevent further damage. Since this is a known issue and the EGR valves have been failing frequently with various Sprinter models, these should be recalled and replaced! Currently, it's not even possible to get this issue addressed. The EGR valves are back-ordered and not available for 6 MONTHS! That's 6 months of limping through traffic with the potential of the valve failing completely. Unacceptable!
SERVICE BRAKES, AIR,VEHICLE SPEED CONTROL07/15/2021
The contact owns a 2016 Mercedes-Benz 2500. The contact stated while driving 21 mph, the vehicle independently accelerated when the brake pedal was depressed. The contact was not able to control the vehicle however, the contact was able to shift the vehicle into neutral to stop the vehicle. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The contact was relating the failure to faulty wheel speed sensors. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50,600.
STEERING,ELECTRICAL SYSTEM,STRUCTURE04/10/2021
MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.
UNKNOWN OR OTHER03/18/2021
I'VE OWNED THIS CAR 2 YEARS. IN THE SUMMER TIME WHEN WE TURN ON THE A/C THERE IS A BAD ODOR COMING OUT OF THE VENTS. ONLY IN THE SUMMER IT'S NOT A PLEASANT SMELL. DURING THE WINTER TIME LAST YEAR WAS A GASOLINE SMELL BUT THAT GOT FIXED. I WOULD LIKE FOR YOU TO LOOK INTO IT PLEASE IT'S A MOLDY SMELL.
VEHICLE SPEED CONTROL,WHEELS,SERVICE BRAKES11/22/2020
THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.
ELECTRICAL SYSTEMfire09/24/2020
RV TRANSFER SWITCH CAUGHT FIRE WHILE SLEEPING. 5100 SERIES TRANSFER SWITCH.*DT CONSUMER STATED DIDN'T KNOW WHY IT HAPPENED BUT COULD OF BEEN THE VIBRATION WHICH MAY HAVE LOOSEN THE SCREWS.*JB
Showing 12 of 27 complaints.