Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2019 Mini Cooper — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Mini Cooper year.
NHTSA lists 2 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.
Risk: A vehicle stall can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the crankshaft sensor, free of charge. The recall began September 6, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 18V465000
Issue: BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X1 sDrive28i, X1 xDrive28i, 2019 X2 xDrive28i, MINI Cooper S Convertible, Countryman, and John Cooper Works Countryman vehicles. The steering gear tie rod may have been assembled incorrectly, which may result in excessive wear of the tie rod end, eventually causing it to break.
Risk: A broken steering tie rod would lead to a loss of vehicle control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the vehicles and replace the tie rods and ball joints as necessary, free of charge. The recall began October 11, 2019. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.
Campaign 19V601000
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
NHTSA has no NCAP crash-test rating for this model/year (common for older, low-volume, or heavy-duty vehicles).
The parts named most often across 10 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
my vehicle only has 23000 how is it that vehicle with low miles and 5 yrs old and there telling me that engine mounts are cracked what mini cooper said was that the reason why is because there made out of plastic . how can this be legal what holds the engine in place made from plastic ? i think this need to be investigated and looked into is not safe and is not fair to the consumer to have to pay for this bad choice in design .
Car sent a message about vehicle stabilization initiation in the middle of the road. I could barely turn the steering wheel and change the lane. Authorized dealer service center tells me it’s a click and drive wiring malfunction issue. I was on the way to the airport via toll road and highway. Continue to drive with the stabilization in progress could caused me an accident for not being able to move the wheel smoothly.
*The condensate drain hose is not properly draining the condensate from the vehicle. *Breathing in mold and didn't know it *Yes the problem was confirmed by the dealer *The dealer inspected *no warnings, no recalls
I am writing regarding the failure of the steering column on my 2019 Mini Cooper Hardtop. The incident occurred on December 31, 2022. I drove my car to a residential location in Seattle, parked and locked the vehicle. When I returned to my car and started it up to move it, I realized I had no control of the car because the steering wheel was spinning uncontrollably. When the car was towed to Seattle Mini, the AAA tow truck driver and the dealership service department personnel receiving the car said they had seen nothing like this before. Seattle Mini takes the position that the steering column was forcibly broken due to an accident which is not the case. I’m very concerned about the safety of this vehicle and not comfortable with Seattle Mini’s theory as to the cause of the failure since no accident or “great force” event occurred as described in the service department video. If this had occurred while I was on-route to the location where the car was parked, the outcome could have been catastrophic. We would like to confer with you this coming week on the best course of action to address this situation. Thank You.
Foul odor coming from vents when starting up AC, and after turning off for 10 - 15 minutes.
Center console phone charger Center console is and enclosed component and when a cell phone is placed in the console and used for Bluetooth navigation and or phone calls it shuts down the system. The phone heats to such a temp that all phone operations and interaction with the vehicle system freeze or shut down and the phone continues to heat. I have spoken to the dealership and have been told it's a problem. When I communicated to MINI USA they acted as if this had never been reported. As far as warnings all car play functions slow down then freezes, and all functions stop. The phone had become so hot I was afraid it may cause a fire or explode the battery. This process usually takes an hour or so to happen.
Entire Driver Side Tail Lamp assembly stopped working (includes running light, brake light, reverse light, and blinker). Dash board did display warning (while driving) of lights malfunction, but nevertheless stopped working while driving. Upon further Inspection, found a “short” / melted pig tail (electrical connector) connecting to the rear of the lamp assembly. (Both the connector and pig tail showed signs of melted plastic/fire hazard). After further investigation, I realized this is not an isolated incident as I found multiple threads/posts on the Mini Cooper (F56) Internet forums, in which multiple owners complained of the same issue (many posting pictures as I have), which dates back many years, link to forum attached. https://www.minif56.com/threads/rear-left-lights-not-working.80537/
WHILE DRIVING ON ROAD DRIVER'S SIDE ROLL OVER BAR JUST POPPED UP. I'M CONCERNED THAT IF CAR WOULD HAVE ROLLED OVER PASSENGER WOULD HAVE BEEN CRASHED. ALREADY NOTIFIED MIN ICOOPER WAITING FOR A RESPONSE. CAR WILL BE SERVICE THIS WEEK.
THIS IS A BRAND MODEL AND BRAND NEW CAR THAT I HAD JUST PURCHASED AND WAS DRIVING HOME FROM BUYING IT- I HAD NOT EVEN OWNED FOR A COUPLE OF HOURS. WHILE ON MY WAY HOME VEHICLE MALFUNCTIONED AND HAD NEAR FATAL COLLISION. WHILE DRIVING ON HIGHWAY - AT HIGHWAY SPEED I WAS UNABLE TO CONTROL CAR AND MAINTAIN SPEED. ENGINE SEEMINGLY LOCKED UP AND AS I WAS UNABLE TO CONTROL CAR ALMOST CAUSED A NEAR FATAL COLLISION AS CAR BEHIND ME DID NOT REALIZE I WAS LOSING SPEED. TAKEN TO DEALERSHIP AND THEY NOTED THE CRANKSHAFT SPEED PULSE GENERATOR SENSOR HAD MALFUNCTIONED.
THIS IS SECOND INCIDENT THAT OCCURRED WITH BRAND NEW MINI COOPER 2019 WITH SAME EXACT ISSUE THAT AGAIN ALMOST CAUSED A NEAR FATAL ACCIDENT. WHILE DRIVING ON HIGHWAY, AT HIGHWAY SPEED THE CAR PRECIPITOUSLY MALFUNCTIONED AND CAR LOCKED UP AND WOULD ALLOW ME TO MAINTAIN SPEED- NOR ACCELERATE. I WAS UNABLE TO MAINTAIN SPEED OF THE CAR THEREFORE STARTED TO LOSE SPEED AND DECELERATE. THE VEHICLES BEHIND ME COULD NOT TELL THAT I WAS SUDDENLY LOSING SPEED AND I WAS ALMOST INVOLVING A NEAR FATAL COLLISION AGAIN. I HAD BEEN DRIVING ON THE HIGHWAY FOR ABOUT 5 -10 MINUTES PRIOR TO THIS PRECIPITOUSLY OCCURRING. THIS WAS THE SAME SITUATION I EXPERIENCED WITH A BRAND NEW MINI COOPER 2019 MODEL A WEEK EARLIER. THE CAR WAS TOWED TO THE DEALERSHIP AND THEY NOTED THAT THE CRANK SHAFT SPEED PULSE GENERATOR SENSOR WAS NO GOOD AND HAD MALFUNCTIONED. AS THIS IS A REPEAT ISSUE AND VERY SERIOUS AS IT ALMOST CAUSED 2 NEAR FATAL INCIDENTS, I AM CONCERNED THAT THE MAKER OF THE VEHICLE IS NOT DOING THEIR DUE DILIGENCE TO ENSURE THAT OTHER 2019 MODELS ARE SAFE. I HAVE BEEN TOLD OTHER MINI MODELS WERE HAS EXPERIENCED SAME MALFUNCTION. THIS INCIDENT AND THE OTHER BOTH OCCURRED AT HIGHWAY SPEED WHICH CREATES A VERY DANGEROUS SET UP AFTER THE VEHICLES HAD BEEN DRIVEN FOR A FEW MILES ON THE HIGHWAY AND IN WET CONDITIONS.