Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2016 Porsche Cayenne GTS — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Porsche Cayenne GTS year.
Rated configuration: 2016 Porsche Cayenne GTS SUV AWD
NHTSA lists 1 recall for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that cover the low-beam headlight horizontal adjustment screws are missing, which can allow the headlights to be improperly adjusted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Improperly adjusted headlights may not illuminate the road properly, or cause a glare to oncoming drivers, which can increase the risk of a crash.
Remedy: Dealers will inspect the headlights for sealing caps and install missing caps as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB4.
Campaign 22V656000
The parts named most often across 33 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
Porsche dashboard leather shrunk and staples pulled out. I was told that if the vehicle was in an accident the airbag might not deploy correctly. The Porsche dealer looked at it and recommended replacing it. This is a very common issue.
Engine oil leak detected in 2021 @33,195 miles caused by broken aluminum bolts in upper part of timing cover. Repaired by dealer on a “good will” basis for what I was told would have cost me approximately $9-10,000. Oil leak reappeared in 2023 @44,657 miles (less than 12,000 since first leak) caused again by broken aluminum bolts in the lower, upper oil pan, and timing cover. Repair done this time by independent shop at a cost of $6,865.70.
Porsche cayenne leather dashboard shrunk and peeling out. I was told that if the car was in an accident, the airbag might not deploy correctly. This is a common issue.
The dashboard leather has shrunk and the staples are beginning to pull out. I have read that this may keep the dashboard airbag from property deploying in the case of an accident. This is a common issue and the dealers are recommending replacement.
Porsche leather dashboard shrunk and staples pulled out. I was told by a Porsche service technician that if the vehicle was in an accident, the air bag might not deploy correctly. The Porsche dealer diagnosed it and recommended replacing it. This is a very common issue.
**Subject**: Urgent Safety Concern: Headlight Condensation and Water Damage in 2015-2018 Porsche Cayenne 958.2 Dear NHTSA, I am writing to report a serious safety issue with the LED matrix headlights on my 2016 Porsche Cayenne GTS (958.2). The problem involves severe condensation buildup within the headlight assembly, leading to water damage and electrical failures. This defect has caused my headlights to fail, particularly during nighttime driving in heavy rain, which significantly reduced visibility. This failure could have resulted in a major accident, putting my life and the lives of others at risk. The vehicle is available for inspection upon request. The issue first became noticeable after a rainstorm, where condensation started to build up inside the headlights. Despite multiple visits to my local Porsche dealership, where they confirmed the problem and attempted repairs, the issue continues to persist. I also notified Porsche corporate directly, but neither the dealership nor Porsche offered any assistance or permanent resolution. Both have failed to take responsibility for what I believe is a widespread defect, as I have found numerous similar reports from other owners. No warning lights or messages were displayed prior to the headlight failure, which made the issue even more dangerous. Without any prior indication, I was left driving without functioning headlights at night, in poor weather conditions. Given the potential for catastrophic consequences, I strongly urge NHTSA to investigate this issue. A recall or other corrective action is necessary to prevent further risks to drivers. Thank you for your attention to this matter.
Backup Camera Intermittent, Yes, available for inspection. Unexpected blackout of the screen. Cannot see pedestrians behind when backing out and expecting to see from the camera instead of rear view mirror. Yes, reproduced by the Dealer. Yes, by the Dealer representing the manufacturer. No warning of any kind. First appeared 9/19/23 Unknown.
Dear NHTSA, I am writing to express a serious safety concern regarding the dashboard of my 2016 Porsche Cayenne S. The leather on the dash has begun to shrink and is no longer fitted properly. This misalignment is causing me significant worry about the potential impact on airbag deployment in the event of an accident. Given the crucial role that the dashboard and its covering play in the proper functioning of the airbag system, this issue could compromise the airbags' deployment or effectiveness. This is not only a major safety concern but also poses a risk of the airbags failing to protect occupants as intended, potentially leading to severe consequences during a collision. I am aware that this problem is not unique to my vehicle, as several other owners of the same model have reported similar issues. The potential impact on safety is alarming, and I believe this requires immediate attention. I kindly request that you investigate this issue urgently and advise on the appropriate resolution to ensure the safety of the vehicle’s airbag system. Prompt action is essential to address this potential risk.
Porsche dashboard leather shrunk and staples pulled out. I was told that if the vehicle was in an accident the airbag might not deploy correctly. The Porsche dealer looked at it and recommended replacing it. This is a very common issue
The contact owns a 2016 Porsche Cayenne. The contact stated that water had leaked inside the front driver's side and passenger's side headlamps. The contact stated that the failure caused the headlights to become foggy and significantly dim, reducing the visibility of the roadway. The contact stated that he had received notification of NHTSA Campaign Number: 22V656000 (Exterior Lighting) and the vehicle was taken to the dealer, where the recall repair was performed. The contact stated that the dealer sealed the headlamps while there was water inside. The dealer declined to perform additional repairs. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 86,000.
While driving vehicle, noticed some slippage/clunking when turning. Took vehicle to Porsche dealer, they said transfer case needed to be replaced. Car has 12,600 original miles on it. Dealer said there was an extended warranty on the transfer case that had expired. In researching, it became obvious that there is a Porsche design problem that affected several model years for the Cayenne. As a mechanical engineer I am concerned that a transfer case failure at freeway speeds could be dangerous. Separately an auto mechanic shop opined that driving without replacing could be a safety concern. In my opinion there should have been a recall rather than a extended warranty.
car had a smell of gas diesel fumes inside cabin from air conditioning system. number of oil leaks over the years as well. now car at dealer for repair over 10 month. not fixed yet. number of problem with same diesel engine on line, even article i found . car was sold as CPO , it was new unregister, but they guaranteed us there will be no emission problems or leaking with this car. now warranty almost over Nov 2023 , and I will get a defective car back maybe... after warranty will expire! more importantly a car that leaks oil or diesel and smells inside the cabin from that.
Showing 12 of 33 complaints.
Over 5 years this costs $10,000 more in fuel than an average new vehicle.