STRUCTURE,UNKNOWN OR OTHERcrash07/18/2025
Standing at a red light and someone rear ended
FUEL/PROPULSION SYSTEM07/18/2025
During hot temperatures and after coming to a full stop, the car stalls/hesitates significantly (5-6seconds) when pushing the gas pedal. The car eventually proceeds but the issue reoccurs. It can only be intermittently reproduced and no codes are shown on the car dashboard. Mechanics are unable to identify the source of the issue so it cannot be resolved.
ENGINE AND ENGINE COOLING02/27/2025
The contact owns a 2017 Toyota Prius. The contact stated that while driving approximately 25-30 MPH, the vents were blowing out cold air. The check engine warning light was illuminated. The contact was adding coolant to the coolant reservoir every three to four days. The vehicle was taken to the local dealer, where it was diagnosed and determined that the coolant was leaking into the exhaust pipe. The dealer recommended that the exhaust system front pipe be replaced. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 81,700.
POWER TRAIN11/27/2024
The contact owns a 2017 Toyota Prius. The contact stated while the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed. The accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the vehicle stalled and jerked. The vehicle was driven to the residence. The contact stated that the battery indicator did not look as if the battery was charging. The contact stated that the vehicle was taken to two independent mechanics; however, the failure was not duplicated. In addition, the vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the failure had become persistent. The contact stated that during one failure his wife was driving, and the vehicle lost motive power and stalled. The vehicle failed to restart. The vehicle was towed to an independent mechanic however, the failure was not duplicated. In addition, the contact stated that during one failure, the excessive acceleration warning light illuminated. The contact had not depressed the accelerator pedal during the failure. The manufacturer was made aware of the failure and a case was filed. The contact was informed that no assistance was available. The failure mileage was approximately 68,000.
ENGINE,FUEL/PROPULSION SYSTEM11/21/2024
Dear NHTSA, I am seeking assistance and compensation for ongoing warranty and repair issues with my Toyota Prius. Key Incident Timeline: •March 21, 2024: Dashboard message “Grille Shutter Inoperable” •March 25, 2024: Toyota of Glendale visit •Charged $220 for diagnostics •Refused to honor service bulletin •Vehicle mileage: 149,217 Customer Service Interactions: •April 9, 2024: •Contacted Toyota customer service •Confirmed CA emissions coverage to 150,000 miles •Discovered extended warranty unexpectedly canceled Brand Engagement Claim: •April 9, 2024: Filed claim with Toyota’s Brand Engagement line •June 26, 2024: Claim denied, dealership’s decision upheld Repair Challenges: •July 5, 2024: Wondries Toyota diagnostic visit •Charged $200 for diagnostics •Confirmed active service bulletins would have covered repairs Repair Management: •Northeast Mechanic has handled all subsequent repairs due to Toyota’s failures Financial Losses Breakdown: •Initial diagnostic fee (Toyota of Glendale): $220.00 •Diagnostic fee (Wondries Toyota): $200.00 •Car rental (July 6, 2024 - Hertz): $1,356.17 •Car parts: $1,706.55 •Labor on vehicle: $754.22 •Water pump: $167.78 •Head Gasket, Spark Plugs, Engine Water Pump: $2,161.00 •Total financial loss: $6,565.72 I request a comprehensive investigation into these warranty and repair issues, seeking full compensation for the financial burden caused by Toyota’s repeated failures. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
TIRES10/20/2024
While driving I heard noises, like “flap,flap,flap”. Pulled over to look at the tire and saw that the tire was peeling. Changed to the donut spare tire and went to “Firestone” 5 days later to have a new tire put on because the original service shop, “Mr King auto services center”, would not take any responsibility for a the tire that was purchased and installed by them 6 months prior. I went to Mr Tire 2 days after this happened and was basically told there was nothing they could do and said it was the alignment. Firestone said my alignment was fine and gave me paperwork to show what was checked. Cooper P215/50R17 (90W)
UNKNOWN OR OTHER07/30/2024
While driving the speed limit of 70mph on a major highway, the sunroof on my 2017 Toyota Prius exploded. There was no warning of any kind: no other traffic nearby so no rock or debris from another vehicle; no overpass or bridge so nothing from above; it was a mild sunny day of 76 degrees so not a weather factor; and by the angle of the glass that remains being in an outward position rather than inward, reveals to me that it was from inside out, not from outside in as if it were a rock hitting. It just exploded. I was the only person in the car. Thankfully, the visor was shut on it or the shattered glass would have caused injury and of greater serious concern is just the sudden sound of what sounded like a bomb going off over my head was enough to cause a reaction which easily would result in an accident. It was a terrifying experience! I was lucky no other vehicles were nearby and could react and safely get off the road. I called 911 immediately and reported it. I have read many such claims from other Toyota owners online (see ToyotaNation.com and search by "exploding Sunroof") and even from a technician at my nearby Toyota Collision Center that it just happened to a friend of theirs also. This is not a one time issue. When I took the car to the Collision Center for an estimate and inquired about the damage, they could find no recall on it by Toyota. This is certainly a dangerous and hazardous issue that needs to be addressed asap before someone is seriously hurt or there is a fatality.
ENGINE07/22/2024
Coolant leaking into exhaust And engine also vehicle suddenly stops for no reason now engine is completely broken due to the coolant going into the motor oil
STRUCTURE07/15/2024
The contact owns a 2017 Toyota Prius V. The contact stated that while her husband was driving approximately 70 MPH, there was a loud explosion coming from the rear of the vehicle. The contact stated that after stopping to inspect the vehicle, it was discovered that the passenger’s side rear hatch strut had exploded into pieces. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 180,000.
ENGINE,FUEL/PROPULSION SYSTEM07/03/2024
Dashboard pop up came up saying that the grille shutter is inoperable to visit a dealer. Went online and noticed there were recalls for my Prius year and because emissions is affected I contacted Toyota financial customer service who said to go to a dealer and that they would fix no charge. Went three times to the dealer and they did not want to honor the recall. Charged me $200 to run diagnostics on the vehicle and confirmed that the code that was being recalled matched. They made excuses and in the end did not fix. The pop up appeared March 2024 and since then I now have another pop up appear about the hybrid system overheating due to them not fixing. I went to a local mechanic who said it was the dealers responsibility since there are service bulletins but they do not want to help. The car has stalled out on the freeway almost leaving me to get hit and my fuel has gotten worse.
VEHICLE SPEED CONTROL10/17/2023
On 10/16/23 I was turning slowly into a parking spot and my car suddenly accelerated without my pressing the accelerator. I slammed on the break and the car stopped. It was frightening because I could have hit someone or something but luckily the car stopped before that happened. I believe that this was a malfunction of the accelerator. This has not been checked or reported to anyone yet but I will be calling Toyota to have it checked. There have been no warning messages.
ENGINE10/03/2023
The contact owns a 2017 Toyota Prius. The contact stated while driving 10 MPH and pulling out of a parking lot, the vehicle lost motive power and made abnormal sounds. Several unknown warning lights were illuminated. The vehicle failed to restart, and was towed to the dealer, where it was diagnosed that the head gasket was blown, causing damage to the engine. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where the same assessment was made. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because the vehicle was out of warranty. The failure mileage was approximately 80,000.
Showing 12 of 101 complaints.