Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2016 Toyota Prius, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Toyota Prius year.
NHTSA lists 5 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Prius vehicles. A capacitor within the hybrid system may not have been properly bolted to the inverter housing.
Risk: If the capacitor was not properly secured, vibrations from driving the vehicle may damage the capacitor, shutting down the hybrid system, causing a loss of motive power and increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the inverter, free of charge. The recall is expected to begin by early December 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0U.
Campaign 17V658000
Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.
Risk: An electrical short can increase the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the engine wire harness assembly and replace it if damage is found. A protective sleeve or protective tape will be included to prevent any future damage. These repairs will be performed free of charge. The recall began October 30, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0T.
Campaign 18V579000
Issue: Toyota Motor Engineering and Manufacturing (Toyota) is recalling certain model year 2016 Toyota Prius vehicles manufactured November 30, 2015, to June 14, 2016. An air bag inflator manufacturing error may result in the inadvertent partial inflation of the front passenger air bag.
Risk: A front passenger air bag that unintentionally inflates can increase the risk of a crash or injury.
Remedy: Toyota will notify owners, and dealers will replace the front passenger air bag assembly, free of charge. The recall began November 10, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0W.
Campaign 16V672000
Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Toyota Prius and Lexus RX 350, RX 350 F Sport, RX 450h F Sport and RX 450h vehicles and 2015-2016 Lexus NX 200T, NX Turbo and NX 300h vehicles. The air bag pressure sensors and/or the acceleration sensors may fail causing the side/curtain shield air bags and/or the front air bags to not deploy in the event of a crash.
Risk: If the air bags fail to deploy in a crash, it can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the sensors as necessary based on their serial numbers, free of charge. The recall is expected to begin March 12, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are JLA, J0F.
Campaign 18V085000
Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016-2017 Prius vehicles manufactured August 6, 2015, to October 3, 2016. The affected vehicles are equipped with a foot-operated parking brake system that has a parking brake cable that may disengage.
Risk: If the parking brake cable disengages from the mechanism and the transmission is left in a gear other than 'Park' while the ignition is on and the driver leaves the vehicle, the vehicle may roll unexpectedly, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will install a clip at the parking brake cable end to prevent the cable from disengaging, free of charge. The recall began November 10, 2016. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is G01.
Campaign 16V741000
The parts named most often across 179 owner complaints filed with NHTSA for this make, model and year.
2 injured
5 crashes · 4 injured
4 crashes
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
The contact owns a 2016 Toyota Prius. The contact stated that while the vehicle was on and running, the ABS and traction control warning lights illuminated, and the messages "Braking Power Low - Stop in a Safe Place”, “See Owner's Manual", "Braking Power Low - Visit the Dealer", and "ABS Malfunction - See Dealer" were displayed. The contact stated that while driving approximately 35 MPH and depressing the brake pedal, the brake pedal was firm. The vehicle was taken to a dealer, and DTC: C14B6 was retrieved, indicating that the brake booster needed to be replaced. The vehicle was not repaired; however, the code was cleared. The vehicle was then taken to an independent mechanic, where the information from the dealer was relayed that the brake booster needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,028.
Second time !!!! during ownership of car that brakes fail. Same problem as before Brake Actuator/Booster Failures: Multiple reports indicate issues with the ABS actuator or brake booster pump, leading to warning lights ("Braking power low", "ABS system malfunction").
The car has a very strong gas smell, especially when full.
Found coolant leak from heat exchanger into exhaust pipe. Looks like, T-SB-0135-19.
Car was driving fine one day and then while driving down the interstate I had the Pre collision system malfunction error, Brake light came on, Cruise will not operate, ABS light is on. After much research it seems Prius V has a common issue with brake booster faulting.
The headlights are either too bright or aimed poorly that it blinds oncoming traffic, who frequently flash their high beams at me. This occurs without any load in back and without me using the high beams. Can Toyota either adjust the bulbs or place a film on the headlights to prevent blinding oncoming traffic? Thank you!
Water pump failed without warning and caused irreparable damage to the engine ("blown" engine requiring replacement). Vehicle began to stall and not respond to attempted acceleration while traveling on 4 lane divided highway, 55 mph speed limit. One "Maintenance Required" message was received the previous week, but disappeared. This is the same message that appears for routine oil changes. No other warning messages were noted at the time of the incident, no unusual noises, and no smoke or other sign of overheating. Driver was able to steer vehicle to safety, but this failure could result in stranding on a busy, dangerous interstate highway. For such a critical piece of the vehicle (i.e., the water pump), there should be obvious warning message(s) and dedicated monitoring of the equipment.
Refer to TSB 0135-19 dealer denied repairing under the California emissions defect and performance warranty.
My car suddenly stopped in the middle of the road with message "Hybrid system stopped steering power low". Safety concern to this happen on the middle of road during rain or cold.
Driving on the freeway the car stalled and was unable to accelerate. The issue seems identical to the 2020 recall. 2020-06-23 Recall no. 20V369000 Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven. I was told by the service center that my car is not on the recall list so they are unable to work it as a recall.
See attached document for complaint
Prinx HiCITY HH2 175/65R15 84H Bought this tire in November 2022. About 15000 miles into it, on Aug 6, 2024, the passenger front tire just busted. After swapping with the spare tire, and upon inspection, there was no nail nor it hit the curb, but the side wall is busted. This is a manufacturing quality issue.
Showing 12 of 179 complaints.
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2016 Toyota Prius 5 HB FWD
60.1 mpg average · 51–86 range · EPA says 52
Over 5 years this costs $5,250 less in fuel than an average new vehicle.