UNKNOWN OR OTHER07/22/2026
Vehicle safety SOS button is not functioning properly. When the SOS button is depressed in case of emergency, the vehicle notifies user at the emergency system is un operational. Toyota includes this for 10 years from the date purchase and my vehicle is a 2021 making this feature active till 2031. By having the SOS button nonfunctional occupants of the vehicle, which may rely on this feature may sustain injury or death by this feature not operating correctly in the event of an accident.
SERVICE BRAKES07/13/2026
FAILURE: Brake control system. Vehicle intermittently surges forward while braking at low speed, most often through a curve — the brakes momentarily release and the vehicle lurches before braking resumes. Appears to occur during the transition between regenerative and friction braking. Vehicle available for inspection. SAFETY RISK: Unpredictable momentary loss of braking at low speed, in parking lots, residential streets and curves where pedestrians and other vehicles are close. Driver cannot anticipate it. WARNING LAMPS: None. No lamp, no message, no stored trouble code. Present since early in ownership; purchased new September 2021. CONFIRMED BY DEALER: No. Reported to a Toyota dealer in 2022 under warranty. Dealer test drove, could not reproduce the intermittent condition, took no action. Also reported in writing to Toyota in August 2022; no substantive response. MANUFACTURER REMEDY: In May 2024 Toyota issued TSB T-SB-0047-24, a brake control module software update for this exact low-speed braking condition on 2021-2022 Sienna Hybrids. Warranty had lapsed, so it was applied at owner expense in late June 2026 at ~156,000 miles. The defect persists after Toyota's own remedy. The surge still occurs, including within the past week at ~157,000 miles. REQUEST: A TSB is not a recall — owners are not notified, and the software remedy did not eliminate the defect on this vehicle. Request that ODI evaluate whether this condition warrants a defect investigation and recall.
ELECTRICAL SYSTEM,LANE DEPARTURE,BACK OVER PREVENTION07/13/2026
FAILURE: Blind spot monitor module failed due to a corroded internal electrical connector. The failure disabled both the Blind Spot Monitor (BSM) and Rear Cross-Traffic Alert (RCTA). Both remain inoperative. The failed component has not been replaced and is available for inspection. SAFETY RISK: Two active safety systems are disabled. The vehicle no longer warns of vehicles in the blind spot during lane changes, and no longer warns of cross traffic when backing out of parking spaces or driveways. WARNING LAMPS: Yes. Multiple warning lamps illuminated simultaneously in February 2026, including BSM and RCTA malfunction messages. No prior symptoms or gradual degradation. CONFIRMED BY DEALER: Yes. A Toyota dealer diagnosed the corroded connector as the cause. Repair quoted at approximately $2,500-$3,000. Repair not performed. INSPECTED BY MANUFACTURER: Diagnosed by a Toyota dealer. Goodwill assistance was requested from Toyota and declined, on the stated grounds that the vehicle had not been regularly serviced at a Toyota dealer. NOT A WEAR ITEM: A sealed electrical connector that corrodes to failure is a component defect. No step in the manufacturer's published maintenance schedule inspects, services, or protects this connector — no owner action could have prevented it, and service history has no bearing on a connector that no service procedure touches. Vehicle purchased new September 2021; failure occurred at approximately [XXX] of age. REQUEST: Request that ODI evaluate whether the BSM sensor and connector design used on this vehicle is inadequately sealed against moisture intrusion, resulting in premature failure of two active safety systems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
SERVICE BRAKES07/01/2026
Car surged as brakes were applied when stopping. Very dangerous. Could have easily rear-ended another vehicle. Surge was immediate and occurred when brake was being applied. Not confirmed yet, but another driver of vehicle told me of having similar problems when braking this car. Very scary. No warnings or messsages.
POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM06/27/2026
Unexpected failure of the acceleration pedal to accelerate from a complete stop to a go at an intersection. The electric vehicle (EV) motor began accelerating up to about 3 mph than instantly had a failure to accelerate, even with the gas pedal continuously pushed to the floor. After about 4 to 5 seconds the engine kicked on and began accelerating. The failure seemed to occur during the EV motor swapping over to the gas powered engine. This has been the fourth occurrence and can be extremely dangerous at intersections with oncoming traffic. No fault codes or check engine lights came on.
UNKNOWN OR OTHER06/19/2026
1. The rear underbody air conditioning (AC) lines and their supporting structural mounting brackets have failed due to severe corrosion. Specifically, a heavy steel mounting bracket has rusted excessively, causing localized galvanic corrosion at the point of contact with the adjacent aluminum AC lines. This structural and material failure caused the aluminum line to erode, crack, and leak high-pressure chemical refrigerant into the environment. The vehicle, failed components, and detailed photographic evidence of the galvanic corrosion and rusted bracket are fully available for inspection upon request. 2. The failure presents multiple safety and health hazards: •Environmental and Inhalation Hazard: The high-pressure leak of mobile air conditioning refrigerant (R-1234yf or R-134a) releases a hazardous chemical compound directly beneath the cabin. •Defrost and Visibility Failure: The rapid loss of system pressure completely disables the vehicle’s climate control and window defrosting/demisting capabilities, severely compromising driver visibility during inclement or humid weather. •Structural Degradation: The severe rust and erosion of the underbody mounting bracket mean structural components are failing prematurely on a 2021 model, creating a risk of loose or dragging underbody debris at highway speeds. 3. The physical failure (loss of refrigerant and severe physical corrosion) has been visually confirmed. However, the Toyota dealership service center actively refused to document the cause. However, photographic evidence clearly reveals the distinct, localized galvanic corrosion occurring exactly where the rusted steel bracket contacts the aluminum line. Further, Toyota’s highlander model had this same problem which was addressed through T-SB-0021-26. 4. The vehicle was inspected by an authorized Toyota dealership which acknowledged the leak but refused to provide a written technical breakdown. 5. Rust, corrosion, and loss of cooling ability.
SERVICE BRAKES06/03/2026
My 2021 Toyota Sienna Hybrid has an intermittent and dangerous brake failure where the brakes suddenly release pressure during normal braking. When slowing down—especially at lower speeds or approaching a stop—the brake pedal briefly loses resistance and the vehicle surges forward as if the brakes let go. I must immediately re‑apply hard pedal pressure to avoid rolling into traffic or another vehicle. The vehicle as a result can stop up to six feet past the intended stopping point in some instances. This issue is unpredictable and has occurred multiple times. It creates a serious safety risk. Toyota performed T‑SB‑0047‑24 (Brake ECU Reprogramming) on my vehicle, whereafter the brakes seemed to function normally for several months, but the problem resurfaced and occurred threee time in one week in May of 2026, which prompted me to bring it backk to Toyota for another look. The dealer has been unable to reproduce the issue and therefore has not repaired it. The veicle has been returned to me, and continues to have the problem intermittently at a random frequency. Toyota corporate Brand Engagement Center has been notified, and a case was opened (Ref # 260528002416). This case was closed however after telling me that the dealership connot reproduce the problem, therefore they cannot repair it. This appears to be a brake control defect involving the hybrid brake‑by‑wire system. Because the failure is intermittent and leaves no diagnostic codes, it is extremely difficult for the dealer to diagnose, but the safety risk is severe. I'd like to advise that I have owned and driven earlier hybrid models (2012-14) that never exhibited this type of brake failure. I'd also like to point out... an internet search of this problem reveals that this problem seems to be prevelant in newer Toyota hybrid models. This was confirmed by the service manager at my local dealership. I have not been informed of any continuing engineering efforts given the failure of the TSB.
AIR BAGS05/30/2026
SRS light has been showing up on the dashboard, off and on for 3 weeks. Diagnostic reader completed by the dealership states it is an airbag module malfunction of the 2nd row left passenger seat. The seat has never been removed, there have been zero accidents and no damage to the seat or wiring.
SUSPENSION05/20/2026
Both front struts of the vehicle have failed and are leaking. There is only 36,000 miles on this vehicle when they should last 200,000 miles per Toyota's service department. Toyota refuses to acknowledge this is their problem and that it's a "wear and tear' part. However clearly these parts should not fail after so little usage.
AIR BAGS05/13/2026
Unknown, I got the SRS Airbag system malfunction in my vehicle, I got the same error in my vehicle dashboard a few times in the past but it would go away and since yesterday I have the message in my dashboard
SUSPENSION,UNKNOWN OR OTHER,ENGINE04/11/2026
We were stopped at a stoplight. As soon as we stepped on the gas pedal, there was a loud clunk sound and plastic parts started flying out from under the car. We immediately pulled over. Oil was spilling out everywhere. The transmission oil pump was laying on the inside of the engine compartment. We had towed to Toyota. They diagnosed a bent piston went through engine which also caused a hole in the transmission. I had it towed for a 2nd opinion. Neither toyota or the 2nd opinion had ever seen anything like it. My mechanic also said there are a bunch of other suspension parts that were damaged due to the violent stop of the engine. There are a few of the same incidents online in chat rooms. The car is totalled and we are out of a car now.
ENGINEfire04/03/2026
The contact owned a 2021 Toyota Sienna Hybrid. The vehicle was parked in the driveway when an explosion occurred; the vehicle burned down. The contact was inside the residence when a loud noise was heard, and the house "rocked." The contact ran to the front of the house to investigate and noticed that the vehicle was engulfed in flames. The fire damaged the driveway, melted the garage door, and melted a landscaping retaining wall. The fire damaged the post on the front porch. The contact and her family were unable to exit through the front door due to the fire and used the sliding kitchen door to exit the residence. The fire department was called to the scene. Per the contact, three fire trucks were at the scene. The fire department informed the contact that the fire went up to 3,000 degrees. The fire department concluded that the fire started from underneath the driver's back panel. The contact stated that the gas tank was underneath that area and believed the gas tank may have contributed to the fire. The towing company towed the vehicle to a towing yard, and it was later picked up and towed to an unknown location. The insurance company was notified and declared the vehicle a total loss. The manufacturer was made aware of the failure and advised the contact that an inspection was needed on the vehicle and asked for the location of the vehicle. However, the contact was awaiting the results. The failure mileage was approximately 80,000.
Showing 12 of 37 complaints.
