STRUCTURE07/06/2026
Toyota has a paint problem on the tacomas. The paint is the bright white, .040 . They have painted all 4 doors,both front fenders and the pillars on each side of the windshield. I’m having the same problem on my hood,top of windshield and bed . Toyota refuses to take responsibility for these areas. They call this a customer satisfaction program instead of a recall so they don’t have to paint the whole truck. I have a 25 year old truck that has better paint than it. I just wanted to let you know about this situation. Thanks [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
POWER TRAIN05/19/2026
The contact owns a 2024 Ford Edge. The contact stated that the vehicle was shaking while driving. The contact noticed there was fluid emerging from the rear of the vehicle near the tire. There were no warning lights illuminated. The vehicle was taken to the local dealer, who confirmed there was no recall or leak. The vehicle was not repaired. The manufacturer was contacted, who referred to the local dealer. The failure mileage was approximately 100,000.
FUEL/PROPULSION SYSTEM05/08/2026
The original low pressure fuel pump failed at 114,700 miles. The symptoms of the failure were loss of power on the freeway, quickly followed by the engine stumbling, then shutting off completely forcing me to change lanes without power. The vehicles has had to be towed on 2 occasions because of this. The pump was replaced at 114,700 miles by a Toyota dealer at my own cost (no warranty, no recall). Now only 20k miles later the fuel pump has failed again. This issue has put my family at serious risk of accident to complete engine shut off at highway speeds. Now that I am on my third low pressure fuel pump, I have little confidence that this is being addressed by the pump manuf. and Toyota.
SEAT BELTS,SEATS,UNKNOWN OR OTHER04/11/2026
Dear Toyota Japan Customer Experience Team, I am the owner of a 2016 Toyota Tacoma currently registered in Guam, U.S.A. I am writing to request your assistance regarding a water leak issue from the rear brake light area, which has caused the carpets and seats to become wet and develop mold. I originally purchased this vehicle in Saipan and recently relocated to Guam. When I visited the Guam Toyota Service Center, they kindly inspected my vehicle and informed me that this issue is related to the 3rd brake light gasket recall; however, the recall period has already expired. Unfortunately, I was never notified of this recall while the vehicle was in Saipan. Continuous exposure to mold has seriously affected both my health and my daughter’s health. Because of this, I had the vehicle professionally cleaned and sanitized by a specialist company. The Tacoma has always been our family’s favorite car, but now I drive it only because I have no choice. Every time I get in, I feel anxious and uneasy. The water leak itself is concerning, but the mold issue worries me even more. I truly hope this water leak and the mold problem can both be resolved so that I can once again enjoy driving my Tacoma with peace of mind. The blue circles in the attached photos indicate areas suspected of mold. These photos were taken right before I sent the car for cleaning. According to the cleaning company, when they removed the seats, they found water underneath the seats and carpets. Whenever I drive the vehicle, I experience persistent coughing and headaches due to mold exposure. This has become a serious health and safety concern. Since this issue is directly related to a previously recalled safety defect, I kindly request Toyota Japan to consider a Goodwill Repair or Safety Exception to address the water leak and the resulting interior damage.
STRUCTURE03/17/2026
Severe clear coat and paint fading on hood, roof and sides of truck.
POWER TRAIN03/07/2026
2016 Toyota Tacoma is known to have an issue with the timing cover leaking oil. This is a Fire Hazard: Oil leaking onto hot engine components can vaporize and ignite, posing a fire risk to the vehicle and surrounding areas and can cause environmental pollution.
LATCHES/LOCKS/LINKAGES01/13/2026
The rear passenger door lock actuator on my 2016 Toyota Tacoma failed prematurely, causing the door to no longer lock or unlock properly. The failure required replacement of the entire actuator assembly at a Toyota dealership at a cost of $727.19. This failure occurred without abuse or unusual use and is not consistent with normal wear and tear. I am aware of numerous similar complaints and pending class action lawsuits involving door lock actuator failures across multiple Toyota models, indicating this is a known and recurring defect. A door that cannot reliably lock or unlock presents a safety and security concern, particularly for passengers and children, and increases the risk of unauthorized entry or inability to exit the vehicle in an emergency.
STRUCTURE12/03/2025
2016 Toyota Tacoma – severe clear coat and paint failure on the hood and roof. The clear coat began peeling in 2022 and has progressively worsened. Large sections of the hood and roof show complete delamination, oxidation, and exposed basecoat. This is a widely reported defect for 2015–2017 Tacomas across multiple paint colors. Toyota Customer Care confirmed today that my VIN is not included in Customer Support Program 23TE08 and that no goodwill repair would be authorized, even though the defect is identical to the vehicles Toyota acknowledges as affected. This appears to be a manufacturing defect that compromises durability and corrosion resistance. Photos and documentation are available upon request.
STRUCTURE11/27/2025
Paint on hood and roof is fading significantly.
UNKNOWN OR OTHERfire11/13/2025
The seat heater pins have melted, leaving black residue. thus showing possibilities of a fire
STRUCTURE10/31/2025
The contact owns a 2016 Toyota Tacoma. The contact stated that while driving, there was a musty odor coming from the interior of the vehicle. The contact was unable to locate the source of the odor. The contact stated that on a separate occasion, while vacuuming the vehicle, the contact noticed that the carpet and floor mats from the rear passenger’s side were wet. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear quarter duct vents had fractured, and water was entering the interior of the vehicle. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 80,000.
ENGINE10/14/2025
Bought 2016 Tacoma in 2022 w/ 53k miles. Hit 58,850 (ish) and had an noticable oil leak… apparently this was a “Well Known” issue, as the mechanic @ Surprise, AZ Dealership (Toyota of Surprise, 13543 N. Auto Show Ave., Surprise, AZ 85388) told my wife and I…. it’s from this same thing that google showed me also: “Engine oil leaks: Reports on Consumer Reports and other forums detail expensive repairs to fix oil leaks from the front seal or timing cover, which can cost $5,000 or more because the engine often needs to be removed for the repair.” And this was 100% my case- and confirmed by the Toyota Dealers Mechanic verbally. Leaks were without engine light indicators “at all”. The dealership added a dye, told me to drive 100-500 miles and return to have a re-inspection done after their initial one came with no results. Initially I spotted this while I was conducting a regular 3,000 mile oil change. (2nd oil change since owning the truck. So my out of pocket was around $5,700+, for an apparent (see attached) “well-known” Dealer issue. @ 60k, a major repair cost for this should NOT but coming from the consumer, and needs to be listed as a “recall”. Had I not noticed the missing oil, this could have left me stranded, my family stranded, or caused many other traveling issues throughout my driving experiences. I repaired this around two years ago, but have been terrified to drive my truck! I’ve driven about 1,000 miles or less since the repair (in 2 years time). I’m selling first chance I can, BUT, I WANT MY MONEY BACK! I have the receipt in a safe for when this becomes a recall - to prove i paid it, and to get a FULL REFUND!!! That is not how good business is done by Toyota. I owned a 2004 and 2005 Camrys prior, as well as a 2014 Lexus GS 350 F Sport (all in my name), this truck was a dream, now a nightmare. Please, for everyone complaining online and those that have had to also pay for these repairs @ low mileage, MAKE THIS INTO A RECALL FOR 2016 TACOMAs.
Showing 12 of 323 complaints.