2021 Acura TLX

VEHICLE LOSING TRACTION WHILE DRIVING. CONFIRMED BY [XXX]'S ACURA IN [XXX]. CONFIRMED: TRANSFER CASE WITH BAD TRANSMISSION. VEHICLE NOW INOPERABLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am submitting this complaint regarding a major drivetrain failure in my 2021 Acura TLX Type S SH-AWD with approximately 86,643 miles. My vehicle experienced a complete loss of AWD. The front two wheels are receiving power, but the rear wheels are no longer receiving power. An independent mechanic initially diagnosed a transfer-case/drivetrain failure and advised that the transmission may also be involved. I then took the vehicle to OH Acura of Temecula, where the Acura dealership independently diagnosed the vehicle with transmission and transfer-case failure. The service manager confirmed that my independent mechanic’s diagnosis was accurate. The dealership provided a repair estimate of approximately $16,000. I am concerned because NHTSA previously opened investigation DP26-001 regarding reported failures involving the transmission and transfer case in 2021–2023 Acura TLX SH-AWD vehicles. My vehicle is now experiencing a complete loss of AWD consistent with the issue described in that investigation. I also experienced an unusual grinding noise on September 21, 2026, which lasted approximately five minutes before stopping. I was subsequently told the noise was caused by worn spindles. The noise has not returned, and I am not claiming that issue was related to the drivetrain failure. Acura declined goodwill assistance, citing lack of documentation for transmission maintenance. The vehicle is outside its original warranty. I am submitting this complaint so NHTSA has a record of my vehicle’s actual failure and complete loss of AWD and can consider it alongside other reports involving this vehicle and drivetrain configuration. I can provide the VIN, dealership diagnosis, repair estimate, and supporting documentation if requested.

My 2021 Acura TLX has a fuel leak. This is a known issue and manufacture design flaw. The Acura dealership has quoted my $4200 - $4500 to replace the fuel tank. I've contacted Honda and they've only offer $300 "goodwill" credit towards the repair. This is a know issue, a fire hazard, and other 2021 TLX has been recalled for this fuel tank/fuel leak issue via recall.

I drive a 2021 Acura TLX TYPE S around 85K miles. I heard a loud clank when I was driving one day, and I loss traction. When I was accelerating I was losing traction and it seem like I lost power while I was moving as well. It seems like I'm driving front wheel drive. I let me foot of the gas and it seems like it's back to normal SH-AWD. I hope this gets looked into and fixed soon.

The transfer case and transmission splines have been stripped causing the car to be FWD only. The issue was confirmed by the dealer, and both the transfer case and transmission were replaced under warranty. The car shuddered, followed by a drivetrain noise for a few seconds. No warning lights or messages appeared when the incident occurred. The issue occurred at approximately 26,574 miles on the odometer.

transfer case leaking fluids at 73,000 miles

Transmission and transfer case failure. Noticed a very small amount of fluid leaking and took to dealership. Dealer informed me that I was "lucky" to have noticed and that the transfer case spline failure had occurred. Notified that the problem could lead to sudden loss of all wheel drive and loss of vehicle control, vehicle slipping, and oversteer. DP26001 had indicated that these issues are a safety concern and could lead to an accident. I had noticed instability in certain issues where the rear of the car did not feel firmly planted when cornering (oversteer). Dealer indicated that both the transmission and transfer case need to be replaced. I was ~8000 miles within powertrain warranty. Parts are on a national backorder which indicates a widespread issue. No warning lamps or indication of seal failure that leads to stripped splines off the shaft due to the fluid leak. NHTSA does not understand how the Acura SH-AWD system interacts with vehicle dynamics and handling, and loss of the rear wheel drive and its impact on oversteer would be absolutely NO DIFFERENT than a rear sway bar breaking under load while cornering. I experienced this exact symptom on [XXX] where the road goes from 3 lanes to 2 lanes on a sweeping right hand curve. This is where I had felt like I may lose control of the vehicle, the rear of the car started to come around and I had to steer into the slide to regain control of the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I'm losing power than normal all of a sudden. When I step on the gas after light hits green in sport and sport plus mode my car losses traction even when traction control is on, and I hear a loud clunck sound. After the the loud clunck sound the car losses RPM while driving I step off the gas and step back on it and the RPM goes back to normal again.

I took this vehicle to get serviced in the summer of 2025. I recently joined an Acura Type S (2021+) group on Facebook and learned that the issue is quite prevalent. I had to have the transmission and transfer case replaced due to transmission issues and traction issues

On July 7th 2026 I was driving home, came to a stop light at normal speed, when the light turned green I took off at normal speed and I heard a huge cluck / bang from underneath the car and it bogged and didn’t want to move. I then stepped on the gas because of the Car behind me getting to close and my traction control light started to flash and the car started to shake and feel very uncomfortable to drive . After that I realize only the two front wheels of the car were working and even at low cruising speeds the car feels very unsafe and shakes and hear noises I never heard before the part that is causing this is the transfer case and transmission thus there are many other people who have had this same issues ranging from 21 to 23 tlx type s with 15k miles to 100k miles

Transmission splines went out and transfer case has also failed which is only sending power to front wheels

On 07/01/2026, at approximately 8:00 AM, during steady acceleration, flashing of MIL with loss of power presented northbound after merging from 235 west bound to I-135 north bound near Park City, KS. Particularly dangerous resulting in near rear end collision. Upon taking nearest exit ramp, attached BlueDriver .OBD II reader, and fault code P0303 - Cylinder 3 Misfire and U0401-68 PGM-Fi/ECM/PCM system event code was logged, with multiple warning indicators that safety system, AWD, brake, and other systems were disabled. Note, vehicle has had TSB 20-053 update w/ flash of PGM-Fi which did not resolve the fault, fault associated with hot and humid climates or period of rain fall, apparent water vapor, condensate build up in intercooler. For Honda Accord and Acura RDX w/ 4 cylinder 2.0 TDGI engine TSB includes redesigned intercooler replacement, that is not available for TLX 21-25 which is currently out of production. This has occurred previously during humid and hot weather, but no intermittent flashing MIL does not store code. Thankful in this instance P0303 and U0401-68 code is stored, and scheduling service at dealership to diagnose misfire.