ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM07/17/2026
I am reporting a severe safety recall compliance failure and fraudulent reporting by an authorized dealership regarding a 2023 Audi electric vehicle. On May 30, 2024, under Repair Order 227719, the dealership officially certified to the NHTSA and Audi that Safety Recall 93U6 (Compact/Portable Charging System Cable) was fully completed. The dealership never actually removed or replaced the hazardous, fire-prone charging hardware. The original recalled cable (Part Number: 8V4.971.675.BB) remains in my home and is available for inspection. The dealer falsely reported a federal safety remedy as remedied while leaving a fire-hazardous component in a consumer's possession. The vehicle suffers from chronic, sporadic overnight charging failures where the vehicle indicates it is charging via a green indicator light but fails to draw power overnight. The vehicle was returned to the same dealer in July 2026 for this defect, at which point the false historical recall reporting was discovered on the printed history report
SUSPENSION02/09/2026
Front suspension ball joint failure occurred while driving approximately 70 mph on an interstate highway, resulting in sudden loss of vehicle control and requiring immediate emergency response. The vehicle is a 2023 Audi e-tron A5. Two weeks prior to the sudden failure, an Audi dealership inspected the same front corner of the vehicle following earlier damage and stated that the front suspension and wheel components were safe and the vehicle was fit to drive, replaced the rear right tire and recommended replacing the rear wheel housing after not being able to get the full car alignment to spec. I told them I wanted to defer that service until later in February unless it was catastrophic when we discussed the findings. They told me that the car was safe to drive and proceeded with the wheel alignment and replacement on the rear. The ball joint failure was catastrophic and presents a serious safety concern, particularly given the recent dealer inspection and the short time between inspection and failure. Warranty coverage was later denied by the dealership, despite having just inspected the car for damage and claimed that the failure of the front ball joint was caused by deferring the rear wheel housing service. I am submitting this complaint due to the safety implications of a suspension component failure at highway speed and concern that the defect may have existed and should have been detected during the prior inspection.
AIR BAGS,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCEcrash01/22/2026
As I began to move the car, the vehicle suddenly accelerated on its own. I attempted to brake before reaching the stop sign, but the car continued to gain speed. I estimate the vehicle reached approximately 60 mph. Within seconds, I collided with two vehicles and then a palm tree, sustaining a frontal impact. The entire incident occurred within approximately two to three seconds, during which the vehicle accelerated rapidly. Despite the collision, the airbags did not deploy, the seat belt did not lock, and neither the brake system warning nor the automatic braking system activated.
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCEcrash12/11/2025
I purchased the Audi Q4 Etron new. The issue that I'm bring up is 'self-acceleration' I had the intial incident 10/2025 where the car self accelerated (Audi Case open) but can't reproduce which almost pin a kid between my vehicle and another vehicle. I was able to react quickly to prevent a death. Second time 'self-acceleration" was on 3/27/25. My son pulling into garage with my sitting next to him, the car self accelerated after coming to complete stop, jumped a pakring block and crashed into my garage wall. Dealer had the car for 2-3 weeks and still couldn't replicate. Third incident was 10/30/25 while at a complete stop in traffic leaving a parking lot, the car was at complete stop and 'self-acclerated' into the vehicle in front. This incident caused my vehcile to be total-loss by insurance. Audi case was also open and they said no fault and told me it's an insurrance matter. I believe there are many cases like mine and they are aware. There are lots of discussion on the defective 'self-accelreation' on Audi Q4 Etron. take a look at this link "https://www.reddit.com/r/etron/comments/16ta6qe/beware_of_the_q4_etron_sudden_acceleration/"
ELECTRICAL SYSTEM,UNKNOWN OR OTHER11/05/2025
Primary issue is electric shock hazard and limb dismemberment. It was confirmed by an Audi service tech that all Audi Q4s have dangerous gaps in every door. My child 8 years old got her finger caught between the panel and door frame. She could have cut or worse lost her finger should the door rapidly open or close. Wires are exposed leaving the easy situation of access to wires with sharp metal objects that a kid could do. Open door panels have sharp edges leading g to easy cuts. As the wires are colorful and visually appealing a kid would be enticed to try to acquire. The techs will not close the panel to frame since this is Audi’s deliberate design. Tech claims to have fixed but clearly was not touched. Audi should be required to redesign door paneling and reinstall proper paneling. All door paneling to the door frames should be closed and secured with zero gaps. Video claiming this normal is found here [XXX] §ion=RECOMMENDATIONS&shouldOpenInspectionsReport=true INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,AIR BAGS09/24/2025
See attached document for complaint.
ELECTRICAL SYSTEM,ENGINE04/04/2025
Car alarmed that my EV had a major electrical issue and made sirens outside as to warn others to not come close and keep distance as if the car will catch fire or explode. I replicated this warning again sitting in the car. Fearing the car will catch fire I had it moved out of my garage. My Audi Service Center was not able to replicate the issue and I provided video and photo evidence of the danger. They claim that car works normal. In the photo is the battery light and sos light on. In addition, all safety features failed to work. Audi Q4 Etron regularly crashes and driver lose federally required safety features. For example additional photos show the loss of speedometer reading stuck on 8 mph and other safety features. These crashes happen at least once a week.
ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER03/12/2025
In several occasions I have noticed my Audi Q4 windows and tailgate are open the next day in the morning in my garage, after I made sure all windows and doors are properly closed and locked, thank God hasn’t happened when parking in open public parking lots and or in raining days. Also many times after locking doors and applying brake properly (after double checking before getting out of my car) I receive on myAudi App the notification that “is not locked “, and after checking my car it’s “unlocked “. Sorry I don’t have pictures for this issue.
STEERING,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE03/12/2025
I have noticed on my Audi Q4 in about 4 different occasions that when I applied the brakes in situations like when traffic suddenly stops, the car and wheels shakes in an uneven, irregular way. Like I never expected before in my more than 45 years driving BMW, Mitsubishi, Mazda. Besides that also always noticed that my car reduces the speed almost to stop suddenly when there is a car already moved into the right or left lane (lanes next to mine) such sudden slow down from 50 mph to 0mph causes the cars behind me to stop suddenly and in several occasions almost ending in a rear ended crash against my car. I guess the radar identifies the traffic ahead next to my lane as a traffic “in front” of my car. Also, even when I am holding the steering wheel with one or 2 hands, frequently I received a message on the dashboard asking me to “Please take over steering” in yellow color, and if I don’t move the steering wheel side to side the yellow warning turns into a Red warning on the dashboard saying “Please take over steering” and if I don’t steer side to side, I get several hard pulls on my seat belt and a load alarm. The only way to avoid such progress of “warnings” is by steering my steering wheel side to side (zigzagging) on my lane. Who ever see me doing that would think I’m drunk or distracted regaining control of my car.
ELECTRICAL SYSTEM03/12/2025
On 7/17/2024 at 11:39am at Bakersfield, CA.when weather temperature was in the 100s , when turn ignition on, lights on temperature control module (A/C, Heating) and emergency light switch started flashing unstoppable. I sent the video tu Audi of America and Audi of Bakersfield, CA. I got an email from Audi of America acknowledging the email was received. I’m afraid this is a dangerous electric issue that can start a fire. I have videos about this issue. Since I informed about this issue I still don’t get a solution from Audi.
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKEScrash11/14/2024
I was driving on the highway at a very slow speed (<5mph) due to heavy traffic. All of a sudden my car accelerated and hit the car in front of me twice because brakes would not apply. I found similar user reports online (links below). These cases suggest that my experience is not an isolated incident, which raises serious safety concerns. Links to other users who have reported similar issues: https://www.e-tronforum.com/threads/unintended-sudden-acceleration.7662/ https://www.e-tronforum.com/threads/sudden-acceleration-issue.2124/ https://www.cars.com › ... › 20232023 Audi Q4 e-tron Consumer Reviews
ELECTRICAL SYSTEM10/08/2024
My first two years of ownership of the Juicebox 40 were pretty uneventful. However, over the last few months my Juicebox 40 became very unpredictable. Sometimes it would charge outside of the Time of Use (TOU) settings I had defined in the Enel X way app. Sometimes it wouldn't charge during the times it was supposed to be charging. There were a lot of random error messages. My hypothesis was that the Juicebox was receiving contradictory commands from multiple sources at Enel X. The support staff at Enel X could not figure it out. Then, on 9/12/24, I walked into my garage and smelled smoke. I had a sense it was coming from where the Juicebox connects to the 14-50 wall plug so I cut the breaker. When I went back to investigate more closely, I saw that the Juicebox had completely melted the 14-50 wall outlet. The smell I was smelling was the 14-50 outlet completely melting down.
Showing 12 of 16 complaints.
