Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 BMW X5, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every BMW X5 year.
NHTSA lists 4 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.
Risk: WITH PROLONGED DRIVING, THESE BOLTS COULD BECOME LOOSE, CAUSE DAMAGE TO THE ENGINE AND TRANSMISSION HOUSINGS. THE RIGHT OUTPUT SHAFT COULD BECOME DISCONNECTED, AFFECTING THE ABILITY TO CONTROL THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Campaign 03V475000
Issue: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Risk: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Campaign 04V344000
Issue: ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.
Risk: THE VEHICLE COULD ACCELERATE UNEXPECTEDLY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Campaign 04V409000
Issue: ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.
Risk: ENGINE STALLING COULD OCCUR, EVEN THOUGH THE VEHICLE'S FUEL GAUGE INDICATES THAT FUEL IS PRESENT IN THE TANK. DEPENDING UPON TRAFFIC AND ROAD CONDITIONS, THIS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Campaign 04V402000
17.8 mpg average · 15–24 range · EPA says 16
Over 5 years this costs $12,750 more in fuel than an average new vehicle.
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2004 BMW X5 4-DR. w/SAB
The parts named most often across 127 owner complaints filed with NHTSA for this make, model and year.
4 crashes · 4 injured
1 fire
10 fires · 2 injured
3 fires
1 fire
1 crash · 2 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
No start no crank sos light battery drain
Vehicle rpm’s rev wildly in park and neutral. When driving vehicle speeds up on its own and rpm’s climbs out of control. When stopped at a light or in traffic, car leaps forward against the break .
MY STEERING IS WAY TO TIGHT. AND ITS HARD TO MOVE THEVCAR.
FRONT PASSENGER SEAT BELT DOESN'T WORK PROPERLY. *TR
TL* THE CONTACT OWNS A 2004 BMW X5. WHILE DRIVING 55 MPH ON THE FREEWAY, THE VEHICLE JERKED SEVERELY. SUDDENLY, THE ENGINE POWERED DOWN IN THE MIDDLE OF TRAFFIC. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER SAFELY ONTO THE SHOULDER. A MESSAGE INDICATING "FAIL SAFE" APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS LATER TAKEN TO RAY CATENA BMW (543 TARRYTOWN RD, WHITE PLAINS, NY 10607, (914) 761-5555) WHERE IT WAS DIAGNOSED THAT A NEW ENGINE AND VALVE PUMP NEEDED TO BE INSTALLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 120,000.
PASSENGER SIDE SEAT BELT AND AIRBAG LIGHT STAYS ON.
PASSENGER SEAT/AIRBAG WARNING MALFUNCTION. THIS WARNING HAS BEEN ON SINCE I PURCHASED VEHICLE. IT IS OBVIOUSLY THE COMMON SEAT MAT SENSOR FAILURE. AND IT WOULD APPEAR THAT EITHER MY VIN ISN'T ON THE PREVIOUS RECALL OR IT HAS EXPIRED FOR MY YEAR AND MODEL. BUT MY WIFE SITS IN THAT SEAT AND IF WE HAVE AN ACCIDENT AND HER AIRBAGS DO NOT DEPLOY WHOSE FAULT WILL THAT BE?
VEHICLE STARTED SMOKING FROM UNDER THE CAR AND AIR VENTS WHILE CAR WAS IN MOTION AIR CONDITIONING WAS RUNNING AND THE OWNER PULLED OVER AND THE FIRE DEPARTMENT PUT OUT THE FIRE AND BROKE 3 WINDOWS UNNECESSARILY IN THE PROCESS. CAR ENDED UP BEING TOTALED AND RESIDES AT OWNERS PROPERTY. COULD BE BASED ON OTHER REPORTS AND A POSSIBLE RECALL ON BLOWER MOTOR ON 2001-2003 RECALLS WERE CHECKED AND ARE CURRENT ON THIS VEHICLE CHECKED BY DEALER AND NHTSA WEBSITE
TL* THE CONTACT OWNED A 2004 BMW X5. WHILE DRIVING 15 MPH, THE CONTACT'S VEHICLE WAS STRUCK BY ANOTHER VEHICLE ON THE DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE RIGHT SHOULDER, BACK, AND NECK, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE CRASH. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000. THE VIN WAS NOT AVAILABLE.
I BOUGHT 4 RUN-FLAT BRIDGESTONE TIRES FROM A BMW DEALERSHIP: DUELER H/L 400 [36110427162] ON JUNE 21, 2017 WITH MY SUV MILEAGE OF 169,318. YESTERDAY, 1/15/2018, I FOUND OUT MY TWO REAR TIRES WERE ALMOST BALD AFTER DRIVEN 10,384 MILES DUE TO SUMMER ROAD TRIP. SEVERAL TIMES THESE PAST FEW DAYS I FELT THE SUV WAS SLIPPING AND SLIDING EVEN THOUGHT NO ICE AROUND. THE TWO REAR TIRES HAVE MARKINGS OF DOT H491 DJE0716 AND DOT H491 DJE0216]. THE FRONT TWO TIRES [DOT H491 DJE4015 AND DOT H491 DJE3160] LOOK NEW COMPARED TO REAR - PLEASE SEE IMAGES.
ABOUT 3 WEEKS AGO WE NOTICED IN THE FRONT PASSENGER SEAT "A MARK" THAT LOOKS LIKE A BURNT - WE THOUGHT THAT IT WAS JUST A MARK OR SOMEBODY PUT A HOT BOTTLE O CUP ON THE SEAT - BUT THIS MORNING WE TURN THE HEATING IN BOTH SEAT TO WARM UP A LITTLE BIT THEN SMELL AND SMOKE START TO COME OUT THE BURNT MARK. WE TURNED IT OFF BOTH SIDES AND OPEN THE WINDOW - NOW OUR CONCLUSION IS THE HEATING ELEMENT CAUSED THAT BURN IN THE SEAT.
HAVE ACCIDENT.BECAUSE MY BMW X5 2004 WHEN START THE ENGINE..THE CAR JUMP. AND PROBLEMS WITH TRASMISSION NOT WORK GOOD WHEN L STAR DRIVING THE CAR JUMP THE SPEEDS NOT WORK GOOD THE GEARS 2 MONTHS AGO L HIT .THE FRONT CAR .BECAUSE MY CAR JUMP .IN HAVE TO PAY .THE OWNER THE OTHER CARS .HAVE TO MANY ACCIDENTS WITH BMW X5 2004..PLEASE YOU CAN HELP ME ..THANK YOU VERY MUCH.
Showing 12 of 127 complaints.