2016 Fiat 500X

The contact owns a 2016 Fiat 500X. The contact stated that while driving approximately 30 MPH through a green light, another vehicle driving through a red light and attempting to make a turn, the front bumper of the contact’s vehicle crashed into the front passenger’s side door. No warning lights were illuminated. The contact exited the vehicle safely and had a passenger in the front passenger-side seat and another in the rear middle row seat. The contact was adamant that the air bags should have deployed. The contact sought medical attention for whiplash, chest pain, bruises, a sore stomach, swollen right leg, and left leg. The contact's front seat passenger sought medical attention due to additional damage caused to a previous medical procedure on the right calf. The child passenger sitting in the rear middle row seat sought medical attention for back pain. The contact stated that the local Fire Department arrived on scene to extinguish a fire under the hood. The source of the fire was unknown. A police report was filed. The vehicle was towed to a local tow yard; however, it was unknown whether it had been declared a total loss. The local dealer where the vehicle had been purchased was contacted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 96,000.

3 times my car had died going under 30 mph, it must turns off or goes into this neutral position and won’t let me change gears, when i restart it, the engine makes an awful squealing sound. all these “drive mode unavailable “ “check esc system” “service electronic brake” it seems it is related to the S55 / 16V529000 safety defect …. “intermittent switch to neutral while driving”

The contact owns a 2016 Fiat 500X. The contact stated that while attempting to start the vehicle using the Push-to-Start button, the engine failed to crank or start. The vehicle was started after the fifteenth attempt. Additionally, the contact stated that the brake pedal was extremely firm and difficult to depress while attempting to start the vehicle. The vehicle was taken to a dealer, but the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.

I was driving vehicle and it all of a sudden get stuck in gear in either park gear or some other gear that wont allow me to turn engine off. Sometimes it just slow down to a stop and will not go into gear again for a while or appears the gears are not engaging putting me at risk for accident on highway. Once it slowed down in traffic and I nearly got hit trying to drive it off the highway. The gears were not engaging putting me at risk of many vehicles hitting me. I was praying someone noticed I had car trouble to slow down as I was no longer in full control of vehicle. After some

I received a letter stating that there was a recall emissions/catalyst efficiency,I have called a fiat dealership several times to get this fixed and it never did, now I am seeing that there is no recall now. So I'm confused on what's going on. U90 is the emissions recall number.and letter said there are others w80

I am submitting this complaint to report a failure related to an emissions recall repair. The vehicle identified by VIN [XXX] was fully operable, properly maintained, and in excellent condition prior to an emissions recall repair performed by an authorized dealership. Immediately after the recall “fix” was completed, the vehicle began experiencing serious operational problems and became undrivable. The servicing dealership towed the vehicle and attempted an additional repair. After the vehicle was returned, it failed again on its first use and is now completely inoperable. Despite the fact that this failure occurred only after the recall repair, the dealership and manufacturer are refusing to assume responsibility for towing and correction unless the owner pays to have the vehicle towed more than 75 miles to another location. We do not believe it is appropriate for the owner to bear the cost of correcting a defect that arose directly from recall work. Another authorized dealership has advised that responsibility remains with the dealer that performed the recall repair. The original servicing dealer has now stated they are “not responsible,” despite having performed the recall work. This situation has left the vehicle undrivable and created a significant hardship, and we believe it represents a recall remedy failure. I spoke with the service manager at the dealership and he said it is up to me to prove that they did the damage to the car. The vehicle was operable before the recall repair The vehicle became inoperable immediately after the recall repair The recall is still showing as open The dealer already acknowledged a problem by towing it once and attempting a second repair That establishes prima facie responsibility. In plain English: Cause-and-effect is already evident. We are requesting that NHTSA document this issue and review the manufacturer’s handling of this recall repair. Thank you for your attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Fiat 500X. The contact stated that while driving at an undisclosed speed, the transmission unintendedly shifted from drive(D) to neutral(N). The RPM became elevated; however, the vehicle failed to accelerate as intended. While driving approximately 15 - 20 MPH, the vehicle went into LIMP Mode. While in LIMP Mode, the contact coasted to the side of the road and waited for several minutes before continuing to drive. The failure had occurred twice. Additionally, the check engine warning light illuminated intermittently. The vehicle had been taken to a certified mechanic, who determined that the transmission had failed and needed to be rebuilt. The dealer also diagnosed that there was a failure with the instrument cluster. The instrument cluster lights were cleared; however, the transmission was not repaired. The check engine warning light remained illuminated. The contact was made aware of NHTSA Campaign Number: 16V529000 (Power Train), for the transmission for the same year, make, and model. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall and opened a case. The failure mileage was approximately 144,000.

Car suddenly slowed down while driving on Christmas Day. This was a very unsafe situation because I was on the highway in traffic traveling at 70 miles per hour and the car suddenly slowed down which could have resulted in an accident leading to harm. A warning light then came on to service transmission right as the car slowed down. I Tried to step on the gas pedal and it would not accelerate. There was no warning light prior to this incident. The car was towed to the dealership the next day. On the following Monday we were told the transmission needs to be completely replaced after they completed a diagnosis test. Enclosed is a pic of the invoice.

While driving, the vehicle suddenly shut off completely in the middle of the road, forcing me to come to a full stop and make several attempts before it restarted. During the incident, all electrical power was lost—I was unable to use hazard lights or blinkers, and I’m unsure if the brake lights worked when pressing the pedal. This created an extreme safety risk to both myself and other drivers. About a month earlier, the same issue occurred and the dealership diagnosed it as a “battery, fuse, array” problem, replacing the battery. The same issue has now returned, and the dealership has identified it as a MultiAir actuator failure. The vehicle is a Fiat 500X equipped with the 2.4L Tigershark engine, which has known problems with the MultiAir system. The car has only around 60,000 miles and is currently at an authorized Chrysler/Fiat dealership, available for inspection upon request. The problem has been confirmed by the dealer, no warning lights appeared before the failure, and a technical case has been opened with Fiat/Stellantis corporate.

The contact owns a 2016 Fiat 500X. The contact stated that while driving at various speeds, the vehicle stalled. The contact stated that the fuel gauge indicator failed to function as intended. The check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with DTC: P0456 and P0452. The evaporative emission system pressure sensor/switch had failed. Additionally, a leak was detected in the evaporative emission control system (EVAP). The dealer replaced unknown parts on the vehicle. The contact stated that the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that the fuel filler neck was fractured. The vehicle was repaired three more times after the first failure. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle jerked while driving in second gear and occasionally in third gear. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was 145,297.

I am writing to you in regard to my 2016 FIAT 500X about multiple concerns. 1. There has been an open recall on the Emissions system since 2022. I immediately followed up and was put on a waitlist as I was told that the parts were on back order. I was told I was 27 on the waitlist. I followed up every 3-6 months for an update on getting the recall repaired but was told they have no update on the parts. It is now 2025 and my registration and inspection are expired. I was informed by FIAT service mechanic that the open recall should not impact my inspection. Upon bringing it in for inspection, I needed to get the thermostat replaced, which was one of the first recalls that was rectified upon purchasing the car in 2017. My car failed inspection. I followed up with FIAT corporate and was assigned a case manager who followed up as well unable to rectify the situation. Now my car is unsafe to drive, I have gotten a ticket for expired inspection . I told the officer that there is an open recall and that I am at the mercy of FIAT. Secondly since I purchased the car I have brought it back multiple times, expressing concern that the car lags when you press the gas. If I am merging on the the highway and I am going 30mph the RPM will struggle to go over 3 in order for the car to accelerate and then it falls to 1-2 RPM. Attached are numerous photos of my constant communication of presenting issues. The entire electrical system will turn on and off on its own. Error I have gotten speeding tickets always when trying to switch lanes or am preparing for the exist because I have to compensate for the lag otherwise I will get smashed by another car. When driving 25-40 mph the engine will make a humming sound as if it is stuck in a gear. So my options are 50+ or 25 or less. Living in NY this is very difficult. I have even advocated that I believe my car is apart of the 2016 transmission recall on my particular make and model. My car is unsafe to drive and I need some guidance

Oil level dropped way below minimum. The current consumption is 1000miles every quarter