Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2005 Ford Expedition, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford Expedition year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2005 Ford Expedition 4-DR.
NHTSA lists 5 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000
Issue: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000
Issue: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000
Issue: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000
Issue: CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000
The parts named most often across 315 owner complaints filed with NHTSA for this make, model and year.
1 crash
1 crash · 3 fires
1 fire
2 crashes · 1 injured
3 crashes
1 fire
7 crashes · 18 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
Engine Missing
The contact owns a 2005 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. The vehicle was taken to an independent mechanic, where the contact was notified of an engine misfire. The spark plugs were replaced. Additionally, the contact stated while driving 55 MPH, the brake pedal became stiff, and the vehicle failed to immediately stop. Additionally, the vehicle made an abnormal sound and stalled. The vehicle was taken to an independent mechanic, who informed the contact that the spark plugs, and the engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 89,000.
COOPER TIRES 265/70/17 DISCOVERER M+S. BELT SEPARATION AND TIRE DEFORMITY ON 3 OF 4 TIRES IN THE LAST 1000 MILES. 2 FAILED WITHIN THE LAST 200 MILES. IN MOTION, HIGHWAY. . SEVERE VIBRATION OCCURRED. (THINK PAINT MIXER) LOW USE 80% TREAD REMAINS. MAX USE OF 3K MILES PER YEAR BUT NOT ALL YEARS. PURCHASED IN 2013. DOT RM1Y C6J 2412 COOPER CUSTOMER SERVICE CLAIMS I DIDN'T USE THEM ENOUGH. *TR
MY TRUCK LOST ALL FORWARD GEARS EXCEPT FOR REVERSE OUT OF THE BLUE THE OTHER MORNING WHEN ATTEMPTING TO LEAVE HOME. VALVE BODY, SERVOS, SOLENOIDS, HAVE BEEN REPLACED AND STILL HAS NOT CORRECTED THE ISSUE. THE VEHICAL HAS LESS THEN 155000 MILES
ENGINE MAKES RATTLING NOISE AND MISSING BADLY
MY CAR AT TIMES WILL GIVE A HARD START. TURNING, BUT NOT FULLY TURNING OVER OR GIVES OFF A SOUND THAT I CAN ONLY DESCRIBE AS AN ELEPHANT TRUMPETING. WHEN IT DOES START AT TIMES IT WILL SHUT COMPLETELY OFF JUST AS FAST. IT HESITATES TO PICK UP ADEQUATE SPEED AND WILL STUMBLE OR JERK, AND WHEN PUT IN REVERSE IT WILL COMPLETELY STALL OUT. I'VE HAD A NEW BATTERY INSTALLED, AND THE SPARK PLUGS AND BOOTS HAVE BEEN CHANGED, BUT TO NO AVAIL.
THE CAR TURNS OFF. I NEED TO PUT THE CAR IN PARK WAIT A FEW MINUTES THEN TURN THE CAR BACK ON AND IT WORKS. THE BAD THING IS IT CAN HAPPEN AT ANY TIME.
I WAS DRIVING AND ALL OF A SUDDEN STEERING WHEEL LOCKED AND MY CAR LITERALLY SHUT OFF WHILE I WAS DRIVING.. I COASTED TO THE SIDE AND I TURNED OFF CAR.. TRIED TO TURN IT BACK ON AND IT KEPT CRANKING AND I KEPT DOING IT LIKE 5 TIMES UNTIL IT STARTED BACK UP. SURE IT IS A 2005, BUT IT HAS BEEN GIVING ME PROBLEMS SINCE I GOT IT, NOW IT IS WORSE. I DON'T BELIEVE IT IS WEAR AND TEAR I ACTUALLY REPLACED THE WHOLE ENGINE 4 YEARS AFTER I BOUGHT MY CAR WHICH IS RIDICULOUS TO BEGIN WITH. IF MY CAR BURNS UP WHILE I AM DRIVING I WILL REALLY MAKE A STINK..
CRANK NO START, AFTER REPLACED NEW FUEL PUMP, FILTER AND OTHER PARTS WOULD NOT START AND NOT GETTING FUEL. WAS IN MOTION AND DIED AFTER MAKING A RIGHT TURN AFTER FILLING FUEL TANK.
MY GEAR SHIFT BROKE WHICH BROKE THE STEERING COLUMN AND I FEEL LIKE THIS IS DEFAULTED SYSTEM SO DO FORD BECAUSE DID CONTINUE THIS STEERING COLUMN SO I HAD TO REPLACE IT WITH ONE FROM JUNK YARD SO HOW IS THAT SAFE FOR ME AS A CONSUMER WELL I FILING THIS JUST IN CASE IT BREAK AGAIN AND MY LIFE IS IN DANGER MY CAR CAME OUTTA OF PARK LIKE TO TANNED ME OVER SO I'M SPEAKING UP BECAUSE THIS PUT MY LIFE IN DANGER
ALUMINUM BODY PANELS ARE CORRODING UNDERNEATH THE PAINT, CAUSING BUBBLING, FLAKING, AND CHIPPING OF THE PAINT. THIS IS NOT CAUSED NATURALLY, THIS IS A FAILURE ON THE PART OF FORD AND THEIR QUALITY CONTROL. THE ALUMINUM UNDERNEATH WAS CONTAMINATED FROM THE FACTORY WITH IRON CAUSING CORROSION. WHILE KNOWING ABOUT THIS PROBLEM, THEY FAILED TO ISSUE A RECALL.
TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE FUEL CAP AND THE TIRE SENSOR WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (CAPITAL FORD OF CHARLOTTE LOCATED AT 5411 N TRYON ST, CHARLOTTE, NC 28213) WHERE IT WAS DIAGNOSED THAT THE TIRE SENSOR, THE FUEL CAP AND THE WINDSHIELD WIPER BLADE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE FUEL CAP WARNING LIGHT, FAILURE OCCURRED EVEN AFTER REPLACING THE PART. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,368.
Showing 12 of 315 complaints.