2018 Ford F-350 Supercab

The contact owns a 2018 Ford F-350 SD. The contact stated that after parking the vehicle in the driveway of their residence, the DPF regeneration process activated and completed, and the vehicle was turned off. The contact exited the vehicle. Approximately 15 minutes later, the contact discovered flames coming from under the hood. The fire department responded and extinguished the fire. The cause of the fire was not determined. The dealer and the manufacturer were not notified of the failure. The failure mileage was 150,000.

Ford Motor Company deployed an over-the-air software update to my 2018 Ford F350 that corrupted the Body Control Module. The software error permanently locked the vehicle into a speed-restricted 'MyKey' safety mode, leaving me with an altered vehicle and no admin access to bypass it. Ford Corporate is refusing to fix the corrupted software deployment. I do not and never have had a second key and they are now saying I must purchase this and pay for my truck to be reset.

Our 2018 Ford F-350 Super Duty diesel with the 6.7L Power Stroke engine has a well-known, massive fuel system concern involving the Bosch CP4 high-pressure fuel pump. This pump failed and it sheds metal shavings throughout the entire fuel system. Repair cost $13k. Per other consumer and google results: The CP4 Fuel Pump Issue. The Defect: The Bosch CP4 pump is designed for European diesel fuel, which has more lubrication than American diesel. When it lacks sufficient lubrication, it can score itself and self-destruct. The Damage: Metal debris floods the fuel rails, lines, and injectors, requiring a complete replacement of the fuel system components.

My wife reported a strong smell fuel in the passenger compartment of my 2018 F350 6.7L Diesel vehicle while returning home from work. Upon inspection under the hood when power was turned on I discovered a strong stream of fuel from the filter cap.

My truck's tailgate has started opening on its own while driving, again. Previous recalls on this issue were performed when parts were available. This is a safety hazard to anyone behind me if anything falls out of the truck bed while driving. Today, 2/3/2026, it opened again. A bucket fell out of the truck bed. Fortunately no one was behind me. My truck is available for inspection. I have not contacted the dealer yet for their inspection/diagnosis. There are no warnings when this happens. It has forced me to strap the tailgate so it can't open unexpectedly.

Steering Effort Control Module failed. This is a known concern with these vehicles. Many Super Duty's have this happen. It is a very expensive repair. The steering effort changes, the vehicle becomes out of alignment and other things like cruise control, wipers, etc may fail as part of this issue.

The contact owns a 2018 Ford F-350. The contact stated while driving 55 MPH and hauling a boat, the vehicle made abnormal banging sounds and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road. The vehicle was restarted but was undrivable. The vehicle was towed to a dealer, but the diesel mechanic was unavailable to service the vehicle. The vehicle was then towed to a certified mechanic and was diagnosed with a blown engine. The contact was informed that the engine needed to be replaced. The vehicle was being repaired. The contact stated that the failure had occurred in Vancouver Island, Canada, where the vehicle remained for the repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 72,000.

The car had not been driven and was only in use for about 20 minutes. Then, the check engine light came on. I was planning to take the next exit to investigate. About a minute after the check engine light came on, several other lights came on. They stopped about 20 seconds later. The car began to smoke and as I was pulling over, smoke began to enter the cab. When I pulled over, the car began was on fire. Highway patrol and Cal Fire arrived. Cal Fire put the fire out. It was a total loss. Highway 101 was shut down for a bit while the truck was on fire.

Truck went into limp mode wile driving on highway had to have trailer towed 980 miles egr cooler rubbing on wire harness on firewall staffing wires ro short out fuel injection this is a manufacturer defect.why would egr cooler and electrical wire harness be placed so close is a big safety and fire hazard ....cost of repairs at ford dealer in Columbia Tennessee $800 for repairs

The panoramic vista sunroof began allowing air while driving. Then the mechanism began not working properly. This all resulted in the track breaking and caused the entire system to stop working. While driving on highway or freeways, the glass would open and could not be secured properly. Could have caused the glass to become a projectile object. Upon researching this issue, I found several complaints for the panoramic vista sunroof for Ford/Lincoln's from 2017 to 2019. TSB # 18-2374. We have a 2018. To be clear; this was a progressive issue that started in 2021 and simply thought it to be the windy conditions outside the vehicle. Then the issue became worse even after being regularly serviced and repaired. By 2024, the track broke completely. Resulting in a complete replacement.

The contact owns a 2018 Ford F-350. The contact stated while driving 50 MPH and coming to a stop, the vehicle stalled in the middle to the road. There was no warning light illuminated. The vehicle failed to restart and was pushed to side of the road. The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump had exploded, causing metal shavings intrusion in the fuel system. The dealer determined that the entire fuel system needed to be replaced. The vehicle was in the process of being repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.

The contact owns a 2018 Ford F-350. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shifted hard into gear, and the vehicle was shaking erratically. Additionally, the engine overheated. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.