2017 Ford Fusion

I lost power while on the Freeway any indicators flashed: "see manual", "pre-collision assist not available", "service advance track", "downhill assist not available", the check engine light was on. It seems that when to limp mode. I took it to the Ford fusion dealer so they could check the car. They run into test and found that the transmission or motor has failed. I check and found that on that year make and model some cars were affected and it was a recall for that. This is the recall If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.

2017 Ford Fusion. Transmission replaced February 2026 at 98,175 miles by independent repair facility. Check engine light illuminated immediately following replacement and has remained on continuously since. Autozone scan showed emissions-related code only. On August 28, 2026 at approximately 120,064 miles, orange wrench light and "See Manual" message appeared moments after hot restart. Acceleration became heavy and hesitant. Drove approximately 70 miles home via I-15; heavy traffic required engine shutdown at multiple stops. Following morning, wrench light was no longer illuminated but hesitation persisted. Using manual paddle shift to select 5th gear improved drivability. Replacement transmission accumulated approximately 22,000 miles over 6 months. Ford Motor Company has issued multiple recalls for 2013-2016 model year Fusions involving identical transmission, shifter cable bushing, and torque converter defects, but 2017 model year vehicles with identical 6F35 transmissions and failure symptoms have been excluded from all campaigns. No crash, fire, or injury occurred.

Flexplate cracked 5 months ago, and now it has cracked again. This is due to troqeu converting failure and faulty transmission mounts.

If i do not run my car for atleast 10 minutes before driving, my gas tank will start making a loud horn sound, and when this happens and i go to slow down, the car will shut off. Mechanics say there’s an issue with the purge valve and the charcoal filter. I’ve already had this issue fixed three times and it comes back less than a week prior to service

I am reporting a serious recurring safety concern involving a 2017 Ford Fusion SE with a 1.5L EcoBoost engine. The vehicle was purchased used in August 2022 with approximately 50,000 miles. Within months, significant coolant and engine problems began. In February 2023, at approximately 55,940 miles, the vehicle developed a coolant leak. A pressure test confirmed the water pump was leaking and it was replaced. At approximately 84,189 miles, the vehicle experienced white/gray exhaust smoke, coolant loss, very low oil, and rough-running symptoms. The servicing Ford dealership referenced Ford Technical Service Bulletin (TSB) 22-2322 in connection with the diagnosis and ultimately replaced the engine short block. Despite this major engine repair, the problems continued. The vehicle subsequently experienced additional smoking, hesitation and loss of power and required replacement of the turbocharger. The vehicle was returned again because it continued to smoke and required additional repairs. I am concerned this is a recurring engine defect rather than normal wear and tear. The repeated engine/coolant failures, smoking, hesitation and loss of power create a serious safety concern because the vehicle may unexpectedly lose power or experience engine failure while being driven. Ford has been notified of the repeated failures but declined further relief based primarily on the vehicle's current age, mileage and expired warranty. This ignores that the problems began years earlier at substantially lower mileage and that major repairs failed to permanently correct the condition. I request that NHTSA investigate whether the 1.5L EcoBoost engine in this and similarly equipped Ford vehicles has a safety-related defect involving coolant intrusion, engine failure and loss of power. The vehicle is currently at approximately 101,000 miles, but the documented problems began at 55,940 miles and continued despite major repairs.

See attached document for complaint.

I was coming home from work and when I tried to shift the gear from drive to park it was stuck on drive and Neutral I contacted the car dealer and they said ford has had this issue that it was a recall on it so I researched and found out that Ford issued major safety recalls (Recall 22S43 and 18S20) for 2017 Ford Fusions regarding a degraded transmission shifter cable bushing. This defect can cause the shifter cable to detach. Consequently, the car may roll away unexpectedly because the transmission isn't actually in Park, even though the shifter says it is.Recall DetailsThe Problem: The underhood shift cable bushing can degrade and fail over time.The Remedy: Ford dealers will replace the transmission shifter cable bushing and add a protective cap over it free of charge (parts and labor). It my VIN# was not coming up as a recall and this is an ongoing issue for this car and I would like to get this resolved as soon as possible with ford recall please thank you

I experienced an issue identical to safety recall 22S02. Rear brake light remains on due to a broken Brakelight stop bumper. Dealership did not offer to fix at no charge.

The vehicle in question has the coolant intrusion into cylinders 2 and 3 with rough idle on startup, P0300, P0302, P0303, and white smoke on startup. The vehicle now has 111339 miles on it and the out of pocket cost is more than what the vehicle blue books for in excellent condition. TSB 22-2134 speaks to all the issue and what the repair is. If this is a known issue then I feel this should be a vehicle recall by Ford due to the costly repair.

What component or system failed or malfunctioned, and is it available for inspection upon request? Driver's side selt belt does not latch all the time. Yes can be inspected. How was your safety or the safety of others put at risk? If the seat fails, injury can occur in a crash Has the problem been reproduced or confirmed by a dealer or independent service center? Appointment is July 18 Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? no Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? no

Good Aftrrnoon and I hope all is well. My cars check engine light is on and the dealer states it’s the cannister purge valve. I showed them that there is a recall (PART 573 safety recall - NHTSA Recall #26V369) but they will not accept it because it’s not showing my car needing it to be changed on the NHTSA website. They are saying it will cost $1995.00 to fix the issue. This is stopping me from obtaining an inspection sticker and I’ve received tickets. Can you confirm that my vehicle is part of this recall.

ENGINE HAS COOLANT INTRUSIONAND IS MISFIRING. Engine light came on. The coolant system found pressure to be dropping significantly. Removed spark plugs and inspected cylinder bores using borescope. Verified coolant is leaking into cylinder 2 and needed to replace the engine at Ourisman Ford in Manassas VA. on July 11, 2026.