Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2020 GMC Sierra 3500, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every GMC Sierra 3500 year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 8 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.
Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192284960.
Campaign 20V142000
Issue: General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Risk: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Campaign 20V792000
Issue: General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.
Risk: If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is N202305380.
Campaign 20V446000
Issue: General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.
Risk: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.
Campaign 19V814000
Issue: General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair). The hood-latch striker wires on replacement hoods installed for Safety Recall 20V-142 may not have been heat-treated properly, possibly causing them to fracture.
Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202306490.
Campaign 20V324000
Issue: General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.
Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
Remedy: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.
Campaign 24V060000
Issue: General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Risk: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Campaign 24V797000
Issue: General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Risk: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Campaign 26V083000
NHTSA has no NCAP crash-test rating for this model year, which is common for older, low-volume and heavy-duty vehicles.
The parts named most often across 45 owner complaints filed with NHTSA for this make, model and year.
2 crashes
4 injured
1 fire
1 crash
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
The contact owns a 2020 GMC Sierra 3500. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently went into LIMP Mode. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the transmission valve body sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 130,000.
The contact owns a 2020 GMC Sierra 3500. The contact stated that while driving at 60 MPH, the rear differential seized, in addition, the contact was hauling a median size tracker on top of a flat bed. The flat bed jackknifed and hit the left side of the contact's vehicle. The vehicle was able to come to a stop. The air bags did not deploy. There was no warning light illuminated. A police report was filed. There were no injuries sustained. The vehicle was towed to a towing yard. The trailer was towed to the residence. The tractor was damaged in the accident. The vehicle was diagnosed by an independent mechanic. The contact was informed that the transmission had failed. The vehicle was not repaired. The insurance company was contacted. A claim was filed with the insurance company, and it was canceled a few days later by the insurance company. The manufacturer was not notified of the failure. The failure mileage was approximately 108,000.
The contact owns a 2020 GMC Sierra 3500. The contact stated that while driving 45 MPH with passengers seated in the rear seats, the passengers became aware that water was entering the vehicle between the window and frame. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact of Technical Service Bulletin: 18-NA-383. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that there was no special coverage or warranty coverage on the vehicle. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.
Engine started skipping, then service parking brake light came on, then service engine light came on and speed dropped to 44 mph.
My IntelliBeam function stops working sometimes, I can still use the lights as normal but the IntelliBeam function stops every so often and starts working after about 2 to 10 mins. Lane departure warning stops every so often and will start working after 1 to 10 mins, I have noticed that when it stops working at night time then the IntelliBeam function stops working also. When I press the on/off button for lane departure then it will say that lane departure is unavailable right now. I have been getting a p20ee code showing something is wrong with SCR nox sensor 2. Scan tool reveals that the sensor works normal and then stops. Once I clear the code then it works good for a few days.
Valve body failed while pulling my camper down the interstate. Transmission began to have issues and locked up on us while driving. Luckily i was able to avoid any accidents. Had truck towed to a private Transmission shop to have the transmission repaired. Shop advised the failure was due to the faulty valve body.
Greetings. In December 2024, I brought my vehicle in for the rear end lock up recall. The recall reprogrammed the transmission control module. As admitted, by yourself and GM this doesn't fix the problem. In addition, if the lockup occurs and a new valve body is required, GM is on back order with no date for delivery. Also, it is replacing it with the same valve body, i.e. you will have the same problem in the future. Nextgen Drivetrain has a valve body for around $1000 that fixes the problem. [XXX] . Please read the attached blog from Nextgen, they explain in detail, the problems and the fixes. I am scared to death to pull my travel trailer out of state with this looming problem. Please give us a better solution. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Def heater connection on the tank will arc and melt down causing engine derate and costly repairs. Gm know and has released a service bulletins in 2022. Bulletins N212342980. But even with bulletins done still fails. And talking todealer ships it a very common problem and there is a shortage in parts.
The contact owns a 2020 GMC Sierra 3500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The contact was concerned about the remedy repair not being adequate to repair the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
I was towing my 44'camper entering the highway and during excellration there was a loud bang and the truck shuddered no lights on the dash. Pulled over and did a visual check of the vehicle and did not see anything out of ordinary. Continued on our journey and during the the week noticed clunking noise when shifting into park and into drive with no camper. We shortened our trip and returned home with no futher incidents. Received recall letter from GM in December, called the dealer and was told Gm has not released my VIN number yet. Called twice in January 2025 and the software was done on February 20, 2025. Truck seems to run as it should. I use the truck for business and to tow my camper. The software is only a patch. My fear is I'm out traveling with my 44' camper and the truck goes into limp mode limiting to fifth gear. Then I have to get the truck towed home and the camper. I travel with 3 dogs too. GM has known about this issue and has failed to fix the problem leaving me and my family at risk of a serious accident. I can not work without my truck and GM does not care about me or my family. I have several camping trips scheduled for this year and I'm considering canceling them because I don't feel comfortable with the software update.
Engine Coolant Low error constantly appears. GM Service provider states that engine coolant level is fine, but sensor may be defective.
Contacted General Motors to have the Recall software patch installed, appoint was set, vehicle was dropped off and now they are telling me there is nothing they can do, that the recall is not available. The software update is available, and is being installed on other vehicles. This is a life safety issue as the rear wheels can lock up at any time which could cause a vehicle accident involving the vehicle under recall as well any vehicles on the road around this vehicle when it happens. General Motors should be taking care of this asap instead of waiting. I do not feel safe driving the vehicle until they feel like they installing it.
Showing 12 of 45 complaints.