2017 Lincoln MKC

The contact owns a 2017 Lincoln MKC. The contact stated that while his wife was driving 65 MPH, the check engine warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that there was coolant inside cylinders #2 and #3. The contact was informed that the engine needed to be replaced. The engine was replaced, and the vehicle was repaired. The failure mileage was 45,000.

My 2017 Lincoln MKC equipped with the 2.0L EcoBoost has recently experienced a serious engine failure and requires engine replacement. It developed an engine problem while driving on at least two occasions and is no longer reliable or safe to operate. No prior warning messages were observed on the vehicle. Fortunately, I was able to pull over on the side of the road and I observed smoke coming from the engine. I was then concerned about the safety of an unexpected engine failure while driving, which might cause the vehicle to stop in traffic. I have now observed green/milky contamination on the engine oil dipstick. The vehicle requires further diagnostic evaluation and engine replacement by a Ford dealership. Ford issued technical service information concerning coolant intrusion into the cylinders of 2017-2019 Lincoln MKC vehicles with 2.0L EcoBoost engines. I am reporting because I believe the engine failure may be related to this condition and may represent a safety defect. I am in the process of having the Ford dealership inspect the vehicle and likely replace the engine. I can request the engine be retained for possible inspection. Ford Lincoln has been contacted regarding this problem. They denied any post-warranty financial assistance. I am concerned the failure may be related to the coolant-intrusion condition described in Ford's technical service information.

The contact's wife owns a 2017 Lincoln MKC. The contact stated that while driving at various speeds, the engine was running rough. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the #3 cylinder and spark plug had seized and there was water intrusion into the engine. Upon further investigation, the contact associated the failure with NHTSA Action Number: DP26008. The contact stated that the engine was previously replaced by an independent mechanic with parts from the local authorized dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 101,989.

I own a Lincoln Mkc 2017 - purchased on 2/19/19 with 12miles I have replaced 4 batteries over the years so far. I drive every day. I am never sure if the car will start. Multiple times i have a dead battery. Lincoln has a problem with this module and the electrical system. parasitic drainage issues on the battery. I don't feel safe, because there is an "unknown" draining the battery, therefore I am scared to drive the car and don't want to keep getting stranded. They have discontinued this make and model, but I am seeing the same complaints with the Corsair. My car only has 53k miles, it is in excellent condition. But unfortunately, i cannot rely on this car. I don't know what to do.

Check engine light on. Codes P0316, P0300, P0301, P0302. Technician confirmed via scope coolant intrusion on cylinder 1 and 2. Technician stated it is known issue with this engine and recommends a new engine for $16,169.92. This has been an ongoing issue for the past two years.

My husband and I own a 2017 Lincoln MKZ that was purchase new in 2018. It is equipped with the 2.0L EcoBoost engine, with approximately 69,000 miles. It has been meticulously cared for! Before the diagnosis, I noticed that when starting the vehicle and backing up, the engine would jerk slightly until I stepped on the accelerator to proceed. The check engine light then came on, which prompted me to take the vehicle to the Lincoln dealer for diagnosis. The servicing Ford/Lincoln dealer, Sugar Loaf Ford in [XXX], examined the vehicle and found coolant in a cylinder. We have been advised that the engine requires replacement. I am concerned because this appears consistent with reported coolant-intrusion problems involving the 2.0L EcoBoost engine used in certain Ford/Lincoln vehicles. A vehicle with only approximately 69,000 miles should not require complete engine replacement because coolant is entering a cylinder. We contacted Lincoln Customer Service and opened case #XXX requesting assistance. Lincoln declined our request and closed the case. Sugar Loaf Ford also contacted Lincoln on our behalf, but Lincoln again declined assistance. I am filing this complaint because I am concerned that this may be a recurring engine defect rather than normal wear. I request that NHTSA document this failure and consider it together with similar complaints involving 2017 Lincoln MKZ vehicles, particularly failures involving coolant intrusion into the cylinders and resulting engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Coolant intrusion into number 2 cylinder requiring full engine replacement of my 2017 my 2.0l eco boost engine

Head gasket failure where engine coolant leaked internally into the engine cylinders.

For the last 17,000 miles, the engine light has been on. We got it checked out and there is coolant and cylinder three we change the cylinder thought it was a misfire, but the problem keeps occurring and we found out information that those engines are bad.

Check Engine Light present. Took car to Ford dealership. Formal diagnosis from Ford dealership: Coolant intrusion present causing misfires, specifically in cylinder 4. P0304 and P0316 codes present. This is a known manufacturing issue; however, Lincoln customer service refuses to acknowledge the problem even exists. Upon talking to the Ford dealership service members, they stated that this is a common issue. One of the service members stated he has already dealt with multiple vehicles with this exact problem this week alone. Having an engine (misfire, steam, etc) go out due to a manufacturing/design flaw, especially while driving on the highway, is a major safety issue. Service team instructed me to no longer drive vehicle which would cause catastrophic damage.

I am filing a formal safety complaint regarding my 2017 Lincoln MKC equipped with the 2.0L EcoBoost engine (VIN: [XXX]). The vehicle has experienced a severe, progressive engine failure caused by internal coolant intrusion into Cylinder 1, directly matching the structural design defect detailed by the manufacturer in Technical Service Bulletin TSB 22-2229. This defect allows pressurized engine coolant to continuously leak directly into the combustion cylinders while driving and during engine rest. This creates an immediate safety risk of vehicle hydro-locking during ignition, sudden mid-drive engine stalls at highway speeds due to severe misfires (Fault Code P0301), and unexpected engine overheating. The manufacturer has knowingly built these open-deck engine blocks with narrow coolant grooves prone to fracturing, creating an ongoing risk of sudden thermal failure and power loss in active traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Contact owns a 2017 Lincoln MKC. The contact stated that reversing at an undisclosed speed, the rear cross traffic warning system of the vehicle was inoperable. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of failure. The failure mileage was approximately 36,000.