Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2001 Lincoln Navigator, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Lincoln Navigator year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 6 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000
Issue: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000
Issue: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000
Issue: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Risk: A FIRE AT THE SWITCH COULD OCCUR.
Remedy: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000
Issue: VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001
Issue: VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Risk: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000
4 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2001 Lincoln Navigator 4 DR. w/SAB
The parts named most often across 92 owner complaints filed with NHTSA for this make, model and year.
3 fires
1 crash · 5 fires · 1 injured
5 crashes · 11 injured
1 injured
1 fire
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
I had been driving for about 15 minutes and then I noticed a burning plastic smell. It was dark so my headlights were on. I felt heat coming from under the dash by the pedals. I started to watch my dash to see if the truck was over heating or the check engine light would come on but neither of those happened. The next light I stopped at I could see smoke coming from the driver side air vents. I pulled over and opened the hood and nothing. Well after some extensive searching I located the issue. The headlight switch to control my headlights was completely melted. Had I not pulled over and popped the hood, Im sure the truck would have continued to catch fire. I replaced the fuses and switch and have not had any problems there but I do now have problems with my odometer lights. I cannot seem to keep that fuse from popping. Everyone I replace just pops again. So I have an electrical issue somewhere I guess I'll just have to start chasing wires!
BOUGHT CAR IN OCTOBER 2017 HAVE HADE TO PURCHES HAD PROBLEMS WITH TIRES FOUR TIME NOW TODAY MAKES FIVE TIMES HAVE TO GO PURCHASE ANOTHER TIRE HAVE TO HAVE IT TOWED IN THE MORNING
THE VEHICLE'S CRUISE CONTROL JUST WILL NOT ENGAGE ANY LONGER. HAS WORKED FINE UP UNTIL ABOUT 2 MONTHS AGO.
TL* THE CONTACT OWNS A 2001 LINCOLN NAVIGATOR. THE CONTACT STATED THAT AFTER RAINY WEATHER, THERE WAS A BURNING ODOR AND AN ABNORMAL SOUND COMING FROM THE VEHICLE AS IF IT WAS ATTEMPTING TO START INDEPENDENTLY. IN ADDITION, THE CONTACT STATED THE WINDSHIELD WIPERS FAILED TO OPERATE INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.
IT MAKES A LOUD NOISE AND NO 1 KNOW WHAT IT IS
TL* THE CONTACT OWNS A 2001 LINCOLN NAVIGATOR. WHILE THE CONTACT WAS SEATED AND THE ENGINE HAD NOT BEEN STARTED, THE DRIVER SEAT AIR BAG DEPLOYED. THE CONTACT HEARD AN EXPLOSIVE NOISE AND JUMPED OUT OF THE VEHICLE. THE CONTACT STATED THAT THE AIR BAG EXPLODED AND SMOKE AND OBJECTS WERE EJECTED. THE CONTACT WAS TAKEN TO THE HOSPITAL AND DIAGNOSED WITH FIRST DEGREE BURNS ON HIS BACK SIDE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000.
TL* THE CONTACT OWNS A 2001 LINCOLN NAVIGATOR. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE OVERHEATED AND EXHIBITED NUMEROUS OTHER MECHANICAL ISSUES. THE CONTACT STATED THAT THE TIRES WERE BALD, THE AIR BAG LIGHT ILLUMINATED, AND THE BRAKES FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKES, TIRES, AND PARTS OF THE ENGINE NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
WHILE DRIVING ON I-95 NORTHBOUND AROUND WOOLBRIGHT ROAD, I RAN OVER TIRE DEBRIS AND CAUSED PART OF MY TIRE TO COME OFF. THE TIRE DID NOT GO FLAT AMAZINGLY, BUT I WILL DEFINITELY NEED A NEW TIRE. I HAVE A NAVIGATOR, SO LUCKILY IT DIDN'T CAUSE ANY MORE DAMAGE LIKE AN ACCIDENT. *TR
SECOND TIME THE SPARK PLUG BLEW OUT OF THE TRITON 54 HEAD.. TRAINED TEC PERFORMED IT THE FIRST TIME SERT INSTALL AND WORKED FINE. HE DIDN'T TOUCH THE FACTORY PLUGS ON THE OTHER CYLINDERS. BUT THOSE BLEW OUT THIS IS A FORD DESIGN ERROR AND FLAW BUT THEY REFUSE TO ACKNOWLEDGE IT. INSTEAD THEY RATHER BLAME THE TECHS AND THE CUSTOMER. *TR
TL* THE CONTACT OWNS A 2001 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DECELERATING TO A STOP, THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE WAS RECURRING. ADDITIONALLY, THERE WAS A BURNING ODOR PRESENT INSIDE THE VEHICLE AND THE SOUND OF BURNING MATERIAL WAS COMING FROM THE FRONT DRIVER SIDE AREA NEAR THE FUSE BOX. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 80,000.
TL* THE CONTACT OWNS A 2001 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE PARKED AND UNOCCUPIED, THE VEHICLE SPONTANEOUSLY COMBUSTED. THE FIRE DEPARTMENT WAS SUMMONED TO EXTINGUISH THE FLAMES. A POLICE REPORT WAS ALSO FILED. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 129,000. *TT
CONSUMER STATES AFTER PUTTING DRIVER SIDE WINDOW DOWN THE RADIO WILL CUT OFF. HAD VEHICLE SERVICED.THIS IS A RESULT OF AN ELECTRICAL SHORTAGE. DEALERSHIP CANNOT FIX PROBLEM,CONSUMER AFRAID THIS SHORTAGE WILL CAUSE A FIRE. *TR
Showing 12 of 92 complaints.