Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2005 Mazda RX-8, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Mazda RX-8 year.
Over 5 years this costs $10,500 more in fuel than an average new vehicle.
NHTSA has issued a do-not-drive warning covering 3 recalls on this make, model and year. Repairs are free at any franchised dealer.
Recalls are issued per model. Confirm whether this specific car has already been repaired using its VIN, free, at any franchised dealer or on nhtsa.gov/recalls.
NHTSA lists 6 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 16V354.
Campaign 18V402000
Issue: Mazda North America Operations (Mazda) is recalling certain 2005-2006 Mazda MPV vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. On July 9, 2019 this recall was expanded to include certain 2005-2009 RX-8 vehicles that were previously recalled under 17V-011 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Risk: An inflator explosion may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018 for MPV vehicles. The recall began July 9, 2019 for RX-8 vehicles. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 17V-011.
Campaign 18V404000
Issue: Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. The recall began on September 12, 2017. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 1417G. Note: This recall supersedes recall 15V-382.
Campaign 17V474000
Issue: Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles. Heat from the engine and the exhaust may cause the main fuel pump pipe to crack.
Risk: If the fuel pump pipe cracks, fuel may leak, increasing the risk of a fire.
Remedy: Mazda will notify owners, and dealers will replace the fuel pump filter kit, free of charge. The recall began on July 31, 2017. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 1017E.
Campaign 17V354000
Issue: Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles manufactured April 10, 2003, to February 18, 2008. The affected vehicles have fuel pump sealing rings that may deteriorate due to exposure to heat from the engine or exhaust pipe.
Risk: The deteriorated seals may leak fuel, which, in the presence of an ignition source, can increase the risk of a fire.
Remedy: Mazda will notify owners, and dealers will replace the fuel pump sealing ring set and add a thermal insulation pad to the fuel tank, free of charge. The recall began July 31, 2017. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 0516J.
Campaign 16V793000
Issue: IF CERTAIN PASSENGER VEHICLES ARE PARKED AND THE ENGINE IS OPERATED AT HIGH RPM'S FOR AN EXCESSIVE LENGTH OF TIME, SOME OF THE PARTS AROUND THE EXHAUST SYSTEM CAN MELT AND PRODUCE A VARIETY OF MALFUNCTIONS. PROBLEMS CAUSED BY THE EXCESSIVE HEAT BUILD-UP CAN RANGE FROM INOPERATIVE OXYGEN SENSOR, NEUTRAL SWITCH AND BACK UP LIGHTS, PROBLEMS WITH THE PARKING BRAKES, MALFUNCTIONS OF THE GAS GAUGE AND/OR POSSIBLE FUEL LEAKS RESULTING FROM HEAT DAMAGE TO THE FUEL TANK.
Risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE PARTS. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.
Campaign 05V317000
NHTSA frontal crash test
4 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2005 Mazda RX-8 4-DR. w/SAB
The parts named most often across 168 owner complaints filed with NHTSA for this make, model and year.
1 injured
4 crashes · 3 injured
1 fire
1 crash
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
See attached document for complaint
Part associated with recall 1017E has failed due to improper installation.
My cars steering will loosen up and stiffen up randomly also the traction control will randomly engage and the tire pressure lights and another light
The steering wheel sometimes its hard to control sometimes its normal and when going fast the steering is so loose like there's a gaps that you need your two hands on the steering all time and the weels Weigel at high speed 60mph. its hard drive the car on the freeway And everyday use i already spend $2800 at the dealership get fix but never get fix The car no accident to be like that. Car has 80k mileage
FUEL LEAK AT GAS TANK AREA CAUSED MASSIVE FIRE.
THE CLUTCH PEDAL ASSEMBLY BRACKET BREAKS AT THE SPOTWELDS WHICH ALSO BREAKS THE CLUTCH MASTER CYLINDER AND LUKILY THIS BROKE WHILE STARTING THE CAR
OIL COOLER HOSES RUST OUT AT FITTINGS AND LEAK OIL UNCONTROLLABLY. ONE SEARCH OF ANY RX8 FORUM AND YOU WILL FIND ALL YEARS ARE EFFECTED.
TL* THE CONTACT OWNED A 2005 MAZDA RX-8. WHILE DRIVING 55 MPH, THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE JUNK YARD. A POLICE REPORT WAS FILED. THE CONTACT RECEIVED MEDICAL ATTENTION AND SUFFERED INJURIES TO THE HEAD, PELVIC, AND RIBS. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS TOTALED AND WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 150,000.
MY STEERING WHEEL TURNS ON ITS OWN WHILE IN MOTION ON THE BELTWAY AND SOMETIMES IT DIFFICULT TO STEER AT ALL WHILE IN MOTION IN TRAFFIC. I PURCHASED NEW TIRES THINKING THAT WOULD SOLVE THE PROBLEM BUT IT DIDN'T.
TAKATA RECALL MAKING A COMPLAINT ABOUT NOT DOING RECALL IN A TIMELY MANOR
CLUTCH PEDAL BRACKET BROKEN UNDER NORMAL CONDITIONS. I WENT TO PUSH THE CLUTCH IN TO DOWNSHIFT AT HIGHWAY SPEEDS TO OVER TAKE A SLOWER VEHICLE AND IT SNAPPED WITH AN AUDIBLE "POP" AND I COULDNT SHIFT INTO THE LOWER GEAR AND MY RPMS, WENT TO IDLE AT HIGHWAY SPEED. HAD IT BROKEN AT A DIFFERENT TIME, I COULD HAVE BEEN LOCKED INTO A CERTAIN GEAR AND HA TO BREAK FAST OR CRASH RISKING THE LIVES OF MY OCCUPANTS AND THE OCCUPANTS OF ANOTHER VEHICLE
I HAD MANY RECALLS DONE LAST YEAR. NOW, TODAY, OLIVER AT MAZDA CORPORATE SAID THAT JOE MACHENS DEALERSHIPS AREN'T EQUIPPED TO HAVE DONE THE WORK PROPERLY. RECALLS: 16V793, 17V-354 & 355, FRONT END STEARING FROM INAPPROPRIATE CAULKING OF BALL JOINT , ENGINE REPLACED TWICE, OIL MIXING WITH COOLANT, AGAIN, AND NOW MY ALARM GOES OFF AS SOON AS I START IT. JOE MACHENS TOLD ME TO REMOVE THE BATTERY. A NEW LITHIUM BATTERY IS BEING DEVELOPED BY MAZDA BECAUSE ROTARY ENGINES CAN'T USE A REGULAR BATTERY. THEY HAD MY CAR FOR SIX WEEKS LAST YEAR, AUGUST, AND KEPT YELLING THAT THEY DIDN'T HAVE THE NEW, CORRECT PARTS. MY STEARING IS DIFFICULT AT TIMES AND THEY NEVER TOLD ME ABOUT THE RECALL CONCERNING THIS. THE SEALS DETERIORATED MAKING ISSUES. NOW THEY ARE MAKING NEW GASKETS, RINGS, ETC. TO BE HEAT RESISTANT. THEY ARE FIGHTING ME, AGAIN, WHILE THEY HAVE ADMITTED MY CAR NEEDS PROPER FIXING WITH PROPER PARTS FROM INAPPROPRIATE WORK DONE LAST YEAR. ONE CORPORATE WORKER SAID MAYBE A NEW ENGINE SHOULD HAVE BEEN DONE WITH PROPER PARTS. YET NOT AT A DEALERSHIP, AT A MECHANICAL SHOP THAT KNOWS HOW TO WORK ON ROTORY ENGINES. MY CAR WAS PARKED IN MY LOT. I HAD MY OIL CHECKED TO HAVE FLUIDS CHANGED WITH VALVOLINE BECAUSE OF THEIR OFFER FOR 150,000 MILES ON ENGINE IF USING THEIR OIL. I COULDN'T GO FORWARD WITH THIS BECAUSE OF THE SAME ISSUES . OIL FOAMY, ALARM GOES OFF, FAULTY LIGHT THEY KNEW ABOUT ALSO. IT WORKED BEFORE THEY DID RECALL WORK ON IT. IT IS NOT SAFE FOR FIRE HAZARD, STEARING DIFFICULTY, GOES THROUGH A LOT OF OIL SINCE THEY WORKED ON IT. IGNITION SWITCH RECALL THEY NEVER DID. WERE SUPPOSED TO CONTACT ME WHEN PARTS ARRIVED. I WILL NEED TO FAX YOU PAPERWORK. MANY PAGES. ALSO SHOWS HOW THEY X'D OUT ONE RECALL CONCERNING GASKETS. I COULDN'T CHECK THE BOXES AS I WISHED TO REPORT.
Showing 12 of 168 complaints.