Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 Nissan Xterra, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Nissan Xterra year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 3 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.
Risk: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.
Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Campaign 10V554000
Issue: CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, AND 1290376035. A WIRE MAY HAVE BEEN PLACED IN AN INCORRECT POSITION IN THE ELECTRICAL CONNECTOR HOUSING. THIS RESULTS IN AN INCORRECT ROUTING OF WIRES BETWEEN THE TRAILER BRAKE CONTROLLER AND THE TOWING VEHICLE WIRING SYSTEM.
Risk: THIS HARNESS WOULD RESULT IN POWER FROM THE TRAILER BRAKE CONTROLLER GOING TO THE TOWING VEHICLE DASH LIGHT CIRCUIT RATHER THAN THE TRAILER BRAKES. THIS RESULT WOULD BE THE LACK OF TRAILER BRAKING WHEN THE TOWING VEHICLE BRAKES WERE APPLIED. IT WOULD ALSO RESULT IN THE TOWING VEHICLES DASH LIGHTS BEING ACTIVATED WHEN THE VEHICLE BRAKES WERE APPLIED. THE FAILURE OF THE APPLICATION OF THE TRAILER BRAKE COULD RESULT IN REDUCED ABILITY TO STOP AND CONTRIBUTE TO A POSSIBLE CRASH.
Remedy: HOPKINS WILL NOTIFY OWNERS AND REPLACE THE ORIGINAL HARNESS WITH A REVISED HARNESS FREE OF CHARGE. THE RECALL BEGAN AUGUST 17, 2007. OWNERS CAN CONTACT HOPKINS AT 800-835-0129.
Campaign 07E046000
Issue: ON CERTAIN SPORT UTILITY VEHICLES, THE ACCESSORY TOW HITCH ATTACHMENT BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.
Risk: THIS COULD CAUSE THE TOW HITCH TO LOOSEN OR SEPARATE FROM THE VEHICLE WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL TIGHTEN THE TOW HITCH. THE RECALL BEGAN ON JANUARY 3, 2005. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Campaign 04V581000
NHTSA frontal crash test
Rated configuration: 2004 Nissan Xterra 4-DR.
The parts named most often across 84 owner complaints filed with NHTSA for this make, model and year.
1 crash · 2 injured
2 crashes
1 fire
1 fire
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
I have been in three accidents, of decent speed, and my airbags never deployed. I was told to report that.
Water pump went out replace water pump motor blown
I took my xterra to get inspected 12/27/2024. I was informed I have a recall on this vehicle.
My vehicle has been in 3 accidents. Being rear-ended at 70MPH, again six months later at 60MPH, then the forward vehicle slammed their brakes, and I hit them at around 30MPH. In any of these accidents, NONE of my airbags deployed.
UNKNOWN. Wanting to make a recall appointment that was reported on my SMOG check.
THE STEERING WEAL IT'S BECOMING STIFF AND IS BECOMING HARD TO MANEUVER AROUND AND IT MIGHT AFFECT MY DRIVING AND I'M SCARED I MIGHT CRASH AND THIS IS THE ONLY VEHICLE I HAVE AND OWN AND HAVE NO OTHER MEANS TO PURCHASE ANOTHER CAR. I WAS HEADING TO WORK AND I TRIED TURNING ON THE CORNER AND IT JUST BECAME HARD TO STEER THE STEERING WEAL.
SPEEDS OVER 60 HITS A BUMP AND STARTS ROCKING AND BOUNCING
WHEN DRIVING MY XTERRA, IT LOSES POWER AND CUTS OUT ON ME. THIS IS VERY DANGEROUS AND CUTS COMPLETELY OFF WHEN I'M ACCELERATING. THERE IS A DECLARATION AND THEN THE VEHICLE WON'T CRANK OR START LEAVING ME STRANDED. THIS IS NOT THE FIRST TIME OVER YEARS THAT THE XTERRA HAS CUT OFF ON ME. ALL DASHBOARD SYSTEMS STOP COMPLETELY WHEN IT HAPPENS. I HAVE NO CONTROL OVER THE CAR WHEN IT HAPPENS.
COOLANT IN TRANSMISSION! BOUGHT NEW IN MARCH OF 2015. WAS DRIVING ON I-10 IN BILOXI AND IT STARTED SMELLING LIKE A BURNT RUBBER SMELL AND IT STARTED SMOKING! PULLED OVER AND GOT OUT OF IT! LEFT ME AND MY DAUGHTER STRANDED ON THE SIDE OF THE HIGHWAY! *TR
FUEL GAUGE REGISTERING IMPROPERLY. ONLY SHOWS 3/4 TANK UPON FILLING TANK FULL AND WILL NOT DROP UPON USAGE OF FUEL. GAUGE HAS ONLY DROPPED ONCE SINCE I HAVE OWNED THE VEHICLE.
WHEN VEHICLE IS STARTED, THE BRAKE LIGHTS WILL STAY LIT AS IF YOU WERE PRESSING THE BRAKE EVEN WHEN ENGINE IS OFF, CRUISE CONTROL WILL NOT SET EITHER SO YOU CAN TURN IT ON BUT WILL NOT ENGAGE. IT MAY HAVE SOMETHING TO DO WITH THE CRUISE CONTROL SWITCH LOCATED BY THE BRAKE PEDAL. I'VE FASHIONED A SPACER TO SLIDE IN BETWEEN THE BRAKE AND SWITCH SO THEY'LL GO OFF WHEN I'M NOT DRIVING. I WAS JUST CURIOUS AS IF THERE IS A RECALL TO THIS OR IF I HAVE TO ACTUALLY REPLACE THE PART MY SELF.
TL* THE CONTACT OWNS A 2004 NISSAN XTERRA. THE CONTACT STATED THAT THE VEHICLE WAS TOWED TO COURTESY NISSAN (1777 N CENTRAL EXPY, RICHARDSON, TX 75080) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 10V554000 (STEERING). AFTER RETRIEVING THE VEHICLE FROM THE DEALER, IT WAS DISCOVERED THAT THE STEERING WHEEL WAS LOOSE. THE CONTACT STATED THAT THE STEERING WHEEL WAS ABLE TO TURN THREE INCHES TO THE RIGHT OR LEFT, BUT THE WHEELS FAILED TO MOVE. THE CONTACT ALSO STATED THAT A LOUD NOISE WAS HEARD COMING FROM THE FRONT DRIVER'S SIDE TIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO ANOTHER DEALER BECAUSE COURTESY NISSAN HAD LOST THE VEHICLE FOR SEVERAL DAYS. THE APPROXIMATE FAILURE MILEAGE WAS 212,000.*PM CONSUMER STATED DEALER WANTED THE VEHICLE TO BE LEFT A THE DEALER FOR 2 WEEKS BUT CONSUMER COULD NOT, WITHOUT A LOANER, DUE TO WORK.*JB
Showing 12 of 84 complaints.