2003 Porsche Boxster

Vehicle has an open safety recall involving a condition that may increase the risk of a crash. During a visit to an authorized dealership for information regarding the recall, dealership personnel advised against completing the recall procedure. I was informed that due to the age of the vehicle and components, performing the recall could potentially damage the headlight seals and that I could be financially responsible for repairs if damage occurred during the recall process. This raised concerns because the recall relates to a safety issue, yet I was discouraged from having the repair performed unless I accepted potential liability for damage resulting from the recall work itself. As a result, the safety recall remains unresolved. No warning lamps or messages were present prior to this interaction. The issue described here concerns the handling of the recall and the guidance provided by the dealership regarding completion of a safety recall repair.

The contact owns a 2003 Porsche Boxster equipped with Landgolden Tires, Tire Line: L27, Tire Size: 265/35/ZR18, DOT Number: (N/A). While performing routine maintenance on the vehicle, the contact discovered that the rear passenger’s side tire had experienced extensive tread separation. The online dealer from whom the tires were purchased from was contacted, but no assistance was offered. The manufacturer was not yet contacted. The failure mileage was approximately 20,000. The VIN was not available.

The contact owns a 2003 Porsche Boxster. The contact stated that upon starting the vehicle, the indicator lights on the gear shifter for the park(P) and the four (4) position was flashing. In addition, while driving at various speeds, the transmission failed to shift into fifth gear and the vehicle would enter LIMP Mode. The contact had taken the vehicle to a dealer on two separate occasions and was informed that the gear selector switch was sticky due to the vehicle not being driven. The vehicle was repaired after the failures; however, the failure persisted. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was 12,669.

THE IMS BEARINGS IN THE 2001-2005 PORSCHE BOXSTER WOULD JUST STOP THE ENGINE IF NOT REPLACED. HELLO, I BOUGHT MY 2003 POSCHE BOXSTER BRAND NEW FROM RECTOR PORSCHE/AUDI DEALERSHIP OF BURLINGAME BACK IN 2003. I RECENTLY FOUND OUT THAT PORSCHE HAD A FAULTY PART IN THEIR ENGINE CALLED THE IMS BEARINGS. THE CARS THAT WERE INVOLVED ARE CARS FROM 2001-2005 PORSCHE BOXSTER. THERE WAS A LAWSUIT (EISEN VS. PORSCHE CARS NORTH AMERICA) THAT TOOK PLACE AND SETTLED BEFORE GOING INTO TRIAL. PEOPLE THAT OWNED THE CARS WERE NOTIFIED TO GET THEIR IMS BEARINGS FIXED THROUGH PORSCHE. I WAS NEVER NOTIFIED. I REACHED OUT TO PORSCHE CARS NORTH AMERICA AND ASKED ABOUT THE LAWSUIT. THE LAST DATE TO FILE TO GET YOUR CAR FIXED WAS OCTOBER 15, 2013. THEY TOLD ME THAT I WASN'T EVEN LISTED IN THEIR SYSTEM AS THE OWNER OF MY PORSCHE BOXSTER. SO I ASKED. HOW COULD HAVE I FILED A CLAIM IF I WAS NEVER NOTIFIED ABOUT IT. PEOPLE'S CARS WOULD SEIZED FROM WORKING WITHOUT ANY SIGNS OF ANY PROBLEMS. MY CAR ONLY HAS 32,480 MILES ON IT. THE DEALERSHIP MECHANIC SUGGEST'S THAT I GET MY IMS BEARINGS REPLACED. BUT IT WOULD COST ME $3,500. WHAT CAN I DO ABOUT THIS? THEY WON'T OWN UP TO THIS AND IT'S THEIR FAULT FOR NOT HAVING MY NAME LISTED IN THEIR SYSTEM. I SHOWED THEM MY BILL OF SALES FROM RECTOR AND EVEN SHOWED PROOF OF REGISTRATIONS DATING BACK FROM 2002 - TO PRESENT DAY.

MARCH 5, 2019. [XXX]. [XXX] 2003 PORSCHE BOXSTER 3.2 ENGINE WITH BRAND NEW MICHELIN ULTRA-HIGH-PERFORMANCE TIRES. ON DECEMBER 31, 2018 ABOUT 10:30 AM, I WAS DRIVING THE CAR GOING EAST, ABOUT 80 TO 100 MILES PER HOUR IN THE MIDDLE OF THREE LANES.WHEN I REACHED THE TOP OF THE HILL, THE FRONT END OF THE CAR WOBBLE IN THE AIR, ONE SIDE WENT UP AND THEN IT CAME DOWN: AND THEN THE OTHER SIDE WENT UP AND CAME DOWN ALTERNATING FOR FEW SECONDS; AND THEN THE WHOLE FRONT END STARTED TO GO UP LIKE IT OR TAKING OFF AS AN AIRPLANE. I APPLIED THE BRAKES LIGHTLY AND IT CAME DOWN ON THE FRONT RIGHT TIRE, THEN STARTED TO PULLING ME TO THE RIGHT IMMEDIATELY. I TURNED LEFT TO CORRECT AND THE FRONT TIRES LOST TRACTION AND SO THE REAR TIRES LOST TRACTION IMMEDIATELY. THE CAR SPUN AROUND TWICE AND SIDESWIPED AGAINST THE CURB ON THE PASSENGER SIDE AND THE FRONT ENDED UP FACING EASTWARDLY, JUST THE SAME WAY AS I WAS HEADING. I WAS THE ONLY ONE IN THE CAR. THE LEFT SIDE DOOR AIRBAG OPENED UP. MY LEFT ARM AND SIDE OF MY BODY GOT ALL BRUISED UP AND SORE FOR SEVERAL WEEKS, BECAUSE OF THE CAR AND AIRBAG IMPACT. THE REAR PASSENGER TIRE WENT OVER THE CURB AND DID NOT HAVE ANY DAMAGE. THE FRONT PASSENGER TIRE WENT BARELY OVER THE CURB AND THE LOWER ARM BROKE. THE DRIVER FRONT WHEEL DID NOT GO OVER THE CURB AND UPON THE IMPACT BROKE MY STEERING ARM AND THE RIM OUTER SIDE ON AROUND THE RIM BROKE AT DIFFERENT PLACES. THE DRIVER REAR TIRE NEVER MADE IT OVER THE CURB. IT IMPACTED THE CURB SO HARD THE WHOLE WHEEL CAME OFF AND LAID ON THE GROUND FACING DOWN; THE RIM WAS BADLY BENT AND ONE SPOKE BROKEN. THE HALF SHAFT CAME COMPLETELY OUT AND WAS LAYING DOWN ON THE GROUND AND ALL THE OTHER MECHANICAL COMPONENTS WERE BROKEN AND ALL THE OIL LEAKED OUT. THIS IS A MIDSECTION REAR WHEEL CAR. IT MEANS THAT MOST OF THE WEIGHT IS IN THE REAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

TL* THE CONTACT OWNED A 2003 PORSCHE BOXSTER S. WHILE DRIVING UPHILL AT 100 MPH, THE VEHICLE VIBRATED VIOLENTLY WHEN THE BRAKE PEDAL WAS DEPRESSED. ALSO, THE STEERING PULLED TO THE RIGHT AND THE STEERING WHEEL DETACHED FROM THE STEERING COLUMN. THE VEHICLE STRUCK A CURB AND THE PASSENGER SIDE AIR BAGS DEPLOYED. THE REAR DRIVER'S SIDE TIRE DETACHED FROM THE VEHICLE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOTALED AND TOWED TO THE CONTACT'S HOME. THE CONTACT SUFFERED BRUISES TO THE LEFT ARM, WHICH DID NOT REQUIRE MEDICAL ATTENTION. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 130,000.

TOOK MY PORSCHE BOXSTER TO THE LOCAL PORSCHE DEALER FOR AN OIL CHANGE. THEY CALLED ME BACK AND SAID MY CAR HAD A GASOLINE FUEL LEAK AND NEEDED A REPLACEMENT FUEL LEVEL SENSOR IT WAS CRACKED AND LEAKING FUEL.. THE SERVICE ORDER AT PICKUP SAID MECHANIC NOTED FUEL DRIPPING FROM GAS TANK...NOTED LEAKING FROM CRACKS IN THE SENDING UNIT WHERE THE PRESSURIZED FUEL OUTLET IS, REPLACED SENDING UNIT AND SEAL, ALSO NOTED ELECTRICAL CONNECTOR SEAL SWOLLEN FROM FUEL CONTAMINATION. I ASKED THE SERVICE MANAGER IF THIS HAD BEEN REPORTED TO THE NHTSA AND HE SAID NO, WHY SHOULD THEY. I EXLPLAINED THIS WAS AN EXTREME SAFETY HAZARD INVOLVING A FUEL LEAK THAT COULD HAVE SERIOUS LIFE OR DEATH CONSEQUENCES. I HAVE THE REPLACED UNIT AND PICTURES AS I REQUESTED THIS UPON PICKING UP THE VEHICLE. I WAS CHARGED $628.58 FOR REPLACING FAULTY FUEL LEVEL SENSOR(SENDING UNIT). I HAVE A COPY OF THE BILL WITH MECHANIC'S COMMENTS. ALSO PICS OF THE FAULTY UNIT ON MY CELL PHONE.

REAR BRAKES (BOTH SIDES) BEGAN APPLYING THEMSELVES WITH NO DRIVER INPUT, LOCKING UP WITHIN ABOUT 5 SECONDS. *TR

TL* THE CONTACT OWNS 2003 PORSCHE BOXTER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, AN ABNORMAL NOISE WAS HEARD FROM THE VEHICLE. AFTER PARKING, THE CONTACT NOTICED OIL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE AND DIAGNOSED AS HAVING AN INTERMEDIATE SHAFT BEARING FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 11,000. THE VIN WAS NOT AVAILABLE.

A STRANGE THING HAPPENED AS MY WIFE AND I WERE DRIVING HOME AT NIGHT IN OUR '03 BOXSTER. THE SEATBACK ON THE PASSENGER SIDE MYSTERIOUSLY BEGAN ROTATING FORWARD, ALL EFFORTS TO STOP IT USING BODY FORCE FAILED. MY WIFE WAS CRUSHED INTO THE GLOVE BOX BY THE TIME I WAS ABLE TO PULL OVER AND STOP. SHE COULD NOT REACH THE DOOR HANDLE AND WAS BARELY ABLE TO EXTRICATE HERSELF AFTER I OPENED THE DOOR FROM THE OUTSIDE. THE SEAT MOTOR HAD ROTATED THE SEATBACK FORWARD TO A POSITION OF APPROXIMATELY 45 PAST VERTICAL BY THE TIME IT STOPPED. WE LATER DISCOVERED THAT THE SHEEPSKIN SEAT COVER HAD SNAGGED THE PROTRUDING SWITCH ON THE SIDE OF THE SEAT AND HELD IT, CAUSING THE SEAT BACK TO ROTATE. THE POINT I NEED TO MAKE IS THIS; WHAT IF THE SAME THING HAD HAPPENED ON THE DRIVER'S SIDE? THE DRIVER WOULD BE CRUSHED AGAINST THE STEERING WHEEL AND UNABLE TO STOP. A CRASH WOULD BE INEVITABLE, AND THE DRIVER WOULD SUSTAIN SERIOUS INJURY SINCE THE SPACE BETWEEN THE DRIVER AND WHEEL IS SO SMALL. THERE IS ABSOLUTELY NO NEED FOR THE SEAT MOTOR TO BE ABLE TO ROTATE THE SEATBACK FORWARD TO SUCH A HUGE ANGLE FROM VERTICAL, ESPECIALLY SINCE THE MECHANICAL LEVER AT THE TOP OF THE SEAT MAY BE USED IF SEAT ROTATION IS REQUIRED. I STRONGLY URGE PORSCHE TO CONSIDER INSTALLING A LIMIT SWITCH ON THE SEAT MOTOR TO PREVENT EVEN THE REMOTEST POSSIBILITY OF THIS EVENT OCCURRING. THE POSSIBILITY OF SOMEONE PLACING AN ITEM IN A POSITION TO SNAG THE PROTRUDING SWITCH AND ACTIVATE THE SEAT ROTATION IS TOO REAL TO IGNORE, AND RAISES A SIGNIFICANT SAFETY ISSUE. NOTE THAT THE SHEEPSKIN SEAT COVERS I USE ARE CUSTOM MADE FOR THE BOXSTER SEAT AND HAVE CUTOUTS AROUND THE SEAT SWITCHES; EVEN SO THIS INCIDENT HAPPENED. *TR

1. I PURCHASED THIS CAR NEW. IT IS MY DAILY DRIVER. ONLY SERVICED MY PORSCHE MECHANICS. IT HAD 32,500 MILES AT TIME OF FAILURE. AFTER LEAVING A DOCTOR'S APPOINTMENT, I NOTICED AN UNUSUAL SOUND COMING FROM THE ENGINE COMPARTMENT. NOT VERY LOAD. I THOUGHT IT HAD CAUGHT A PIECE OF DEBRIS IN THE BELT SYSTEM. DROVE IT SLOWLY HOME, AND THE SOUND GOT PROGRESSIVELY LOUDER. THE NEXT MORNING THERE WAS A PUDDLE OF OIL UNDER THE CAR. I CALLED THE PORSCHE DEALER IN MOBILE, AL FOR A TOW TRUCK. 2. I WAS TOLD BY THE PORSCHE SERVICE MANAGER THAT THE CAR HAD EXPERIENCED THE INFAMOUS INTERMEDIATE SHAFT (IMS) FAILURE, AND THAT I WOULD NEED A NEW ENGINE. I WAS TOLD THERE IS LITTLE TO NO WARNING OF THIS FAILURE, AND THEY ARE ALMOST ALWAYS CATASTROPHIC. REQUIRING COMPLETE ENGINE REPLACEMENT. 3. PORSCHE NORTH AMERICA WAS CONTACTED WITH ALL PERTINENT INFORMATION. THEY RESPONDED WITH AN OFFER TO COVER HALF THE COST OF A FACTORY REBUILT ENGINE. I WOULD PAY THE OTHER HALF, PLUS ALL LABOR AND TOWING COSTS. THIS REPLACEMENT WILL COST ME OVER $11,000.00 !!! *TR

MY ENGINE FAILED DUE TO A PART CALLED THE INTERMEDIATE SHAFT. THE CAR IS A 2003 PORSCHE, BOXSTER S WITH 47,000. THIS PROBLEM IS WELL DOCUMENTED ON LINE AND APPEARS TO BE A MANUFACTURING PROBLEM. THE DEALERSHIP I WENT TO, KNEW RIGHT AWAY ABOUT THE FAILURE AS THEY SEE AT LEAST 1 PER MONTH. WHEN THIS PART FAILS, THE REMEDY IS A NEW (OR USED ENGINE). THERE IS NO WAY TO KNOW OF THIS FAILURE UNTIL IT HAPPENS. I REPLACED MY ENGINE AND IT COST $12,000. THIS WEBSITE PROVIDES A LOT OF INFORMATION ABOUT THIS PORSCHE PROBLEM AND IT SHOWS SOME OF THE RESEARCH CONDUCTED BY THEIR ENGINEER, HTTP://WWW.LNENGINEERING.COM/IMS.HTML. THEIR RESEARCH INDICATES THAT PORSCHE KNOWS OF THE PROBLEM AND THINKS IT HAS TO DO WITH PARTICULAR VIN NUMBER CARS (ONE OF WHICH IS MINE) AND FIXES IT WHEN IT HAPPENS DURING WARRANTY. I ASKED THEM TO HELP COVER THE COST AND THEY SAID NO, AS MY CAR WAS OUT OF WARRANTY. IT IS MY OPINION THAT A CAR (PORSCHE OR NOT) SHOULD NOT FAIL LIKE THIS ESPECIALLY WITH NO WARNING. AS AN FYI, IT APPEARS PORSCHE FINALLY REDESIGNED THIS PART IN 2006. I HOPE YOU CAN HELP ME CAPTURE SOME OF MY OUT OF POCKET EXPENSE AS WELL AS MAKE OTHER USERS AWARE WITH A POSSIBLE RECALL. *TR