STEERING,SERVICE BRAKES,ENGINE08/18/2022
It just died and I lost brakes, power steering, and only know what else stopped working. Come to find out the splines wear off of the oil pump shift after the counter balance and chain goes out. This is so common a problem that when you Google what happened there are numerous videos and complaints about this issue, with ways to stop it from happening. Korea has already recalled them and Europe has recalled them, why are we so far behind on this. Not only is it expensive, but also a major safety issue because this stops the brakes from working and the car does not have stopping power with the motor dead. NOT EVERYONE KNOWS TO REPORT TO NHTSA!
ELECTRICAL SYSTEM,STRUCTURE08/18/2022
Electronic control module, electronic body module starts going out, it will not let you open the doors from the outside without rolling the windows down and sometimes won't even let you open them with the inside door handles. This is a major safety issue in a wreck or fire especially if you cannot get out of the car. Sometimes they work and sometimes they don't. For a vehicle that everyone complains about with this, and as expensive as it is to fix, are you going to wait until someone dies to make them fix it? When people complain if someone would just Google these issues you would find out just because not everyone knows about NHTSA, that these are extremely common issues that need to be fixed by Volkswagon!
FUEL/PROPULSION SYSTEM11/17/2021
Approximately back in June 2021, I noticed the smell of diesel fuel coming from the rear of the vehicle, noticed hours and days after the vehicle was parked. The smell is partially present from the interior in the trunk area, but mostly evident when standing near the vicinity of the fuel tank when outside of the vehicle. After driving the vehicle, I occasionally notice small puddles of diesel fuel (as evidenced by the oily texture and smell) coming from below the fuel tank. On occasion, I can also spot actual drops of diesel fuel on the lower car frame from underneath the vicinity of the fuel pump. These puddles usually evaporate or dissipate within an hour or two after appearing. Given that these puddles only appear after driving, and not after extended periods of the vehicle sitting in my driveway, I suspect that there is a leak in the fuel pump. A more recent VCDS scan of the ECU on 29 October 2021 results in a Gateway and Dashboard fault code in the fuel pump, which may or may not be related to the fuel pump leak. The fault code is 00476, relating to the fuel pump control module, indicating "no communication"; the code is marked as "static". This fault code may not be related to the underlying fuel leak, but since it relates to the fuel pump, I thought it would be worth mentioning. Last but not least, a recall notice was issued on the diesel fuel pump assembly that impacted the make and model of my vehicle, issued in December 2004, just a couple months before the manufacture date of my vehicle (February 2005). As a result of this cut-off date, my vehicle's VIN number was not included in the official recall notice (NHTSA # 04V586000); see: https://www.vindecoderz.com/EN/Volkswagen/PASSAT/2005/fuel%20system,%20diesel/recall/04V586000. Due to the commonality of my vehicle's components with the 2004 Volkswagen Passat TDI and close temporal proximity to the recall notice, I highly suspect that my vehicle's fuel pump is impacted by this latent recall.
FUEL/PROPULSION SYSTEM09/27/2019
2005 VW PASSAT WAGON, 4 MOTION, 128,000 MILES, W/ INTENSE ODOR OF GAS IN THE CABIN OF THE CAR; AFTER DRIVING 15 MILES TO WORK, I DEVELOPED A HEADACHE AND ILLNESS SYMPTOMS WHICH LASTED FOR 2 -3 DAYS. CAR WAS TOWED TO LOCAL VW DEALER. I CONTACTED VW OF AMERICA, WHO AGREED TO DIAGNOSTICS. LARGE FUEL TANK FRACTURE CONFIRMED. AFTER MANY DISCUSSIONS WITH CUSTOMER SERVICE AT VW OF AMERICA, THEY REFUSED TO COVER REPAIRS, THOUGH THEY DID CONFIRM THAT THIS FAILURE WAS THE SAME FAILURE WHICH HAD LED TO A PREVIOUS RECALL CAMPAIGN OF THE FUEL TANK/SYSTEM, BUT SINCE MY CAR HAD ALREADY BEEN REPAIRED (2015) W/ A SUPERSEDED PART AND IT WAS PAST THE 12 MONTH WARRANTY PERIOD, I DID NOT QUALIFY, NOR WOULD THEY OFFER GOODWILL SERVICE. THEY DID ACKNOWLEDGE, HOWEVER, THAT IT WAS A SERIOUS SAFETY ISSUE AND THE CAR SHOULD NOT BE DRIVEN. I VERBALIZED IN MANY CONVERSATIONS THE SAFETY CONCERN THIS POSED NOT ONLY FOR MYSELF AND MY FAMILY BUT FOR OTHERS WHO HAD THE POTENTIAL TO FACE THE SAME SITUATION. I ASKED WHAT PROCESS VW HAD FOR DOCUMENTING AND REPORTING THESE CONSUMER SAFETY CONCERNS OF SUCH A SERIOUS NATURE AND WAS TOLD THAT IT IS REPORTED INTERNALLY BUT THERE WAS NO ONE I COULD SPEAK WITH TO DISCUSS FURTHER ANY ASPECT OF THE CASE, NOR WOULD VW REPORT THIS TO NHTSA, AS IT HAD BEEN REPORTED UNDER THE PREVIOUS CAMPAIGN. I FEEL VERY STRONGLY THAT THIS REPEATED FAILURE SHOULD BE REPORTED AND THEREFORE AM DOCUMENTING HERE. THE CAR HAS NOW BEEN TOWED TO MY HOME WHERE IT SITS IN MY DRIVEWAY D/T THE FUMES BEING AT A TOXIC LEVEL WHEN THE CAR IS IN THE CLOSED GARAGE. THE CABIN OF THE CAR ALSO REMAINS WITH A HIGH LEVEL OF GAS FUMES. I HAVE ASKED FOR WRITTEN DOCUMENTATION FROM VW OF AMERICA RELATED TO MY CASE, BUT AS OF YET HAVE NOT BEEN PROVIDED WITH SUCH.
FUEL/PROPULSION SYSTEM07/14/2019
MY 2005 PASSAT HAS DEVELOPED A FUEL LEAK UNDER THE TANK. MY VEHICLE LOOKS LIKE NEW AND ONLY HAS 72000 MILES ON IT. THIS LEAK/SMELL OCCURS AFTER WHEN THE CAR IS MOVING AS WELL AS WHEN THE CAR IS SITTING IN THE DRIVEWAY. SEEMS VERY DANGEROUS TO ME AND I'VE READ MANY COMPLAINTS DESCRIBING THIS EXACT SCENARIO. WHY IS VW NOT FORCED TO RECALL AND INSPECT FOR THIS SITUATION.
FUEL/PROPULSION SYSTEM04/26/2019
I COMPLETELY FILLED THE FUEL TANK OF MY CAR IN THE MORNING ON 4/22/2019. I THEN DROVE HOME AND PARKED THE CAR IN MY DRIVEWAY (SO IT WAS STATIONARY AT THIS TIME). THAT AFTERNOON I SMELLED A STRONG ODOR OF GASOLINE AND SAW A PUDDLE ON THE GROUND UNDERNEATH THE CAR BY THE DRIVER'S SIDE REAR WHEEL. I THOUGHT THAT MAYBE I OVERFILLED THE FUEL TANK SO I WAITED TO SEE IF THE ISSUE WOULD GO AWAY AFTER I DROVE A BIT. ON 4/23/2019 I STILL SMELLED GASOLINE AND SAW A PUDDLE UNDER THE CAR AFTER PARKING. I DETERMINED THE FUEL WAS ONLY LEAKING WHILE THE CAR WAS IN MOTION AND IT BECAME APPARENT THERE WAS A LARGER ISSUE. ON 4/24/2019 I TOOK THE CAR TO A MECHANIC TO DIAGNOSIS WHERE THE LEAK WAS COMING FROM. THE MECHANIC COULD SMELL GAS AND FOUND FUEL RESIDUE, BUT NOTHING FRESH. IT WAS RECOMMENDED THAT I FILL THE FUEL TANK AND RETURN TO SEE IF A LEAK COULD BE FOUND. SO ON 4/26/2019 I COMPLETELY FILLED THE FUEL TANK AND RETURNED TO THE MECHANIC. AND THEY FOUND THAT FUEL IS LEAKING FROM THE SEAM OF THE FUEL TANK.
ENGINE02/14/2019
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. WHILE DRIVING 25 MPH, THE ENGINE BEGAN TO OVERHEAT AND DRAIN THE COOLANT. THE FAILURE OCCURRED MULTIPLE TIMES AND THE CONTACT HAD TO CONTINUOUSLY REPLACE THE COOLANT OVER A COUPLE OF WEEKS. THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE THERMOSTAT AND HOUSING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.
SEAT BELTS01/15/2019
INERTIA REEL WILL NOT PAYOUT WEBBING. CAR WAS IN A SCHOOL PARKING LOT, CAR WAS LEVEL
ELECTRICAL SYSTEM,ENGINE05/04/2018
OVER HEATED AND TIMING BELT
FUEL/PROPULSION SYSTEM04/16/2018
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. UPON STARTING THE VEHICLE OR DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED A FUEL ODOR INSIDE THE VEHICLE. IN ADDITION, THE CHECK ENGINE AND ANTI-SLIP REGULATOR WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED MOMENTUM VOLKSWAGEN OF CLEAR LAKE AT (844) 894-5461 (15100 GULF FWY, HOUSTON, TX 77034) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM, GASOLINE). THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 91,628.
POWER TRAIN,VEHICLE SPEED CONTROL05/27/2016
I DECIDED TO CHANGE THE OIL MYSELF IN MY CAR, SINCE I WANTED TO SAVE MONEY AND I KNEW WHAT I WAS DOING. INSTEAD OF DRAINING THE OIL, I ACCIDENTALLY DRAINED THE TRANSMISSION FLUID. I DIDN'T FIGURE OUT THAT IT WAS TRANSMISSION FLUID BECAUSE IT LOOKED LIKE OIL! SO, THIS IS WHAT HAPPENED AFTER; I DROVE HOME (NOT KNOWING THERE WAS NO TRANNY FLUID IN IT) AND I NOTICED THAT THE CAR WANTED TO TAKE OFF BY ITSELF. IT KEPT DOING TIS TWO OR THREE MORE TIMES WHEN IT BECAME STUCK IN 4TH GEAR. I MANAGED TO SAFELY GET HOME, AND FIGURED OUT WHAT HAPPENED. I AM REPORTING THIS BECAUSE THIS IS A DESIGN FLAW!!! THE TRANSMISSION FLUID DRAIN HOLE IS WHERE THE ENGINE OIL DRAIN HOLE SHOULD BE! LUCKILY, AFTER I PUT FRESH TRANNY FLUID IN IT, THE CAR WAS FINE. I WONDER HOW MANY OTHER PEOPLE THIS HAPPENED TO.
UNKNOWN OR OTHER04/29/2016
CAR HAD INTERMITTENT STARTING ISSUES FOR ABOUT 6 MONTHS. ENGINE CRANKS BUT DOES NOT TURN OVER. WILL EVENTUALLY RESTART ANYWHERE FROM 15MIN - 5 HRS LATER. LENGTH SEEMS TO BE DEPENDENT ON HOW LONG WAS DRIVEN BEFORE TURNING OFF. CODE SAID THE CPS WAS FAULTY. REPLACED IT. BUT STILL HAVING RANDOM PROBLEMS AND CODE STILL SAYS CPS IS FAULTY. CANNOT GET IT FIXED BECAUSE CAN'T RECREATE PROBLEM AT MECHANICS. CAR DOES NOT DIE WHEN DRIVING. THERE DOES SEEM TO BE FLUCTUATIONS IN SPEED WHILE DRIVING. AND DOES SEEM TO BE WORSE IN RAINY WEATHER. CAR DOESN'T RUN HOT. ANYBODY ELSE HAVE THE SAME PROBS? HOW DID YOU FIX?
Showing 12 of 148 complaints.
