Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2017 Volvo XC60, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Volvo XC60 year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 4 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Risk: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Campaign 18V800000
Issue: Volvo Car USA LLC (Volvo) is recalling certain model year 2017 S60 and S60 Cross Country, V60 and V60 Cross Country, and XC60 vehicles manufactured August 16, 2016, through October 21, 2016. The affected vehicles have driver and front passenger seat side mounted side air bags (SAB) with inflator initiators that may fail to ignite during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection" and number 214, "Side Impact Protection."
Risk: If the air bag inflator initiator fails to ignite, the air bag will not deploy, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect and, if necessary, replace the front seat side air bags, free of charge. The recall is expected to begin on February 13, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89712.
Campaign 16V918000
Issue: Volvo Car USA LLC (Volvo) is recalling certain 2017 S60, S60CC, V60, V60 Cross Country, and XC60 vehicles. The affected vehicles have driver and front passenger seat side mounted side air bags (SAB) with inflator initiators that may fail to ignite during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection" and number 214, "Side Impact Protection."
Risk: If the air bag inflator initiator fails to ignite, the air bag will not deploy, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect and, if necessary, replace the front seat side air bags, free of charge. The recall began March 31, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89712. Note: This recall is an expansion of recall 16V-918.
Campaign 17V127000
Issue: Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Risk: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
Campaign 16V798000
NHTSA frontal crash test
Rated configuration: 2017 Volvo XC60 SUV FWD
The parts named most often across 16 owner complaints filed with NHTSA for this make, model and year.
1 fire
1 crash · 1 injured
1 crash · 1 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
235/55R19. Tire blowed up while driving on the interstate highway I-57. Tire pressure was checked at 35 psi before the ride.
Pulling into a gas station, a turtle warning light (limp mode) came on in the dash, and the car started moving very slowly. Moments later the engine was on fire. Basically the entire front end of the car melted away before the fire department in New Buffalo, Mich., could put it out.
The support battery for start/stop started to show on the dash and tells me that service is required about 2 weeks ago. "THE LOCATION OF THE BATTERY IS MY CONCERN". A month ago, the air coming out from the vent of the ac/heater started to smell like a rotten egg, a very strong smell that gives me a headache and makes me dizzy. This smell comes and go.I had to open the windows and switch to recycled air, this helps a little bit. I brought my Volvo to 2 shops about 3 weeks ago before I went to the dealer on Feb 16, 2024. The first shop smelled it and said they checked the catalytic converter and run a diagnostics and emission and they said emission is very good and there is no problem with the catalytic converter and suggested to bring it to the dealer. They said it could be coming from the battery and I told them that the battery is new and main battery has a box casing so the strong smell is definitely not coming from the main battery. I didn't know that there was another battery. I brought it to an exhaust shop and said the same thing, no leaks in the pipe and catalytic converter and smoke coming from the exhaust looks normal and smells normal. Next I brought it to the dealer and they did nothing and simply stated they could not duplicate the problem. I had no choice but to do an extensive research to find out where the location of the support battery so I can change it myself. I always wondered why the smell is so strong in the passenger side intake screen cover of the cowling. I couldn't believe where Volvo had placed the second battery/support battery. It was on the passenger side, right next to the air intake for the AC/heat of the car and is covered by the cowling between the windshield and the engine. Harmful gases that can potentially come out from the battery is directly suck in to the intake of the car's air conditioner.
SRS Airbag light came on three times in a month but did not stay on. Took it to Volvo dealership to see what the issue was. According to dealership- there was loose pin tension in the left front door harness. They checked for codes and received SRS B11A081 left side pressure sensor message failures. Followed VIDa fault tracing and found the loose tension in SRS pins in the driver door harness. They had to replace the SRS terminal pins and splice wiring. The dealership did mention that this has happened with 3 or 4 different Volvo models already this year. It sounds like it's a defect in the manufacturing of the SRS system within the doors. However, Volvo warranty will not cover this repair. My primary concern was that the airbag was deactivated this entire time, even when the light was off. Again, the warning only came on for three trips in an entire month. I had assumed it was a software glitch, since when my software needs updating electrical things start to happen (i.e. spacial sensors going off when nothing is around me and I'm parked).
I pulled my car out of the garage, I saw I had not taken the trash out and had my foot on brake. the car has an automatic shut off at stops to save gas. It shut off, I jumped out thinking it was "off" as there was no engine sound. The car started back up and started going forward. I attempted to jump in to hit the brakes ... it kept going and hit side mirror, door, me and then kept going! it never stopped! crushed me half in half out of door. my friend jumped in stopped it from passenger side and then started it up to back it up and remove me. I was taken to trauma with fractured pelvis, broken lumbar, cracked ribs and a concussion and stitches! this is supposed to be one of thee safest cars. my family owns 3! the sensors did not stop the car! period! called volvo and they blew me off after several drawn out forms. Said the car will not stop in reverse. I was going forward! I paid for the black box to be downloaded and it shows NO collision recorded but I need two new doors its so bad! it has been since first week of feb that I have been rehabilitating and several of my doctors have asked why this was not a case with a lawyer? so far most do not want to fight volvo I guess. I need help with this. I have proof it did not stop or even show collision from sensors. Thank you Kimberly Bradshaw
Got into my car, pulled out of a parking spot and approached a stop sign. The brakes suddenly became extremely mushy and the brake peddle went all the way to the floor. I didn't notice an issue when I pulled out of the parking spot. I was unable to continue driving as the brakes were not usable. I had the car towed to the dealer and they indicated the brake booster and vacuum pump failed due to "normal wear and tear". The vehicle was purchased at, and always maintained at our local Volvo dealer. Luckily no accident occurred.
I will followup once I have a report from a mechanic. My car stalled while driving in heavy traffic; a pedestrian ran in front of me and I braked. I didn't hit anything or anyone, not even a pothole. My car stalled and all the dashlights went off. I put the car in park and tried to restart, but it would not start. My emergency lights wouldn't work and because I was on a busy thoroughfare in DC, my daughter and I were nearly rear ended by a bus. Even after we got out of the car, we watched other cars nearly hit it because it couldn't be pulled over and the emergency flashers wouldn't turn on. The mechanic said that the battery was fine. I had a regularly serviced oil change 2k miles ago, and everything was fine. The mechanic will replace the starter since the car will no longer start, but said that a bad starter would not cause the car to just die in heavy traffic. I called Volvo to report the issue, but they said they wouldn't take safety reports unless it was towed to a Volvo dealer. Of course, my car stalled out far away from a Volvo dealer, and roadside assistance only tows to the nearest mechanic.
The fuel pump regulator failed causing the fuel pump to fail way to early (car has less than 60K miles). In addition, the floats in the fuel tank itself stick making the fuel gauge unreliable. We have had to replace the fuel pump regulator, fuel pump and also have an unreliable gas gauge now unfortunately. The car failed while we were driving through the canyon in southern CA which was terrifying and very dangerous. We are fortunate we were able to steer off the road and get out of the way.
2017 VOLVO XC60. CONSUMER STATED THAT VOLVO VEHICLES ARE UNSAFE DUE TO NO LONGER HAVING SPARE TIRES IN VEHICLES. *LD *JS
TL* THE CONTACT OWN A 2017 VOLVO XC60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE SWERVED TO THE LEFT AND THE RIGHT. THE CONTACT RELEASED THE ACCELERATOR PEDAL AND THE VEHICLE OPERATED AS DESIGNED. THE VEHICLE WAS NOT TAKEN TO A DEALER NOR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE, HOWEVER NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.
TL* THE CONTACT OWNS A 2017 VOLVO XC60. THE CONTACT STATED THAT THE STEERING WHEEL FAILED TO TURN. THE VEHICLE WAS TAKEN TO SMOLISH VOLVO (20360 GRANDVIEW DRIVE BEND, OREGON 97701, (541)-639-3005) TO BE DIAGNOSED. THE DEALER REPLACED THE STEERING WHEEL COMPUTER SENSOR, THE STEERING WHEEL RACK, AND THE STEERING WHEEL FLUID RESERVOIR; HOWEVER, THE REPAIRS DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 191112-000964. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.
I WAS T-BONED BY ANOTHER SUV IN THE DRIVER'S DOOR, DAMAGING FRONT & REAR DOORS, FRONT PANEL AND BACK PANEL. MY CAR WAS STOPPED GETTING READY TO MAKE A LEFT TURN AND THE OTHER VEHICLE STOMPED THE GAS TO MAKE A LEFT TURN AND HIT ME DIRECTLY. DOOR WOULD NOT CLOSE AFTER IMPACT AND ALL OF THESE PARTS REPLACED. AIR BAGS NEVER DEPLOYED AND INSURANCE ADJUSTER INDICATED THAT THIS MODEL VOLVO DOES NOT HAVE SIDE AIRBAGS. PLEASE ADVISE..
Showing 12 of 16 complaints.