Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 Chevrolet Avalanche, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Chevrolet Avalanche year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 6 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Risk: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Campaign 06V289000
Issue: ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Risk: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Campaign 05V163000
Issue: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Campaign 06E043000
Issue: CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Risk: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Campaign 05V043000
Issue: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Risk: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Campaign 04V045000
Issue: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Risk: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Campaign 04V129000
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2004 Chevrolet Avalanche 4-DR. w/SAB
The parts named most often across 319 owner complaints filed with NHTSA for this make, model and year.
1 fire
2 crashes
2 crashes
4 crashes · 9 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
N/a
The brake pressure modulator valve leaks the transmission has problems and service airbags is on
Tire brand and size is cooper Discoverer stt 33×12.50R20LT. I was coming home on my lunch break and it blew out I didnt hit anything in the road or anything I have another tire the same brand and it started to separate on sidewall also but I felt a vibration so I took the tire off and put my other spare on and the vibration stopped.
The contact owns a 2004 Chevrolet Avalanche. The contact stated that upon starting the vehicle, the brake warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the rear brakes needed to be replaced. The contact stated that the vehicle was repaired however, the failure reoccurred while driving. The vehicle was taken to another independent mechanic who replaced the parking brakes and the brake fluid; however, the failure persisted. The contact stated that the brake pedal would hesitate to respond when depressed, causing a 100-feet in stopping distance delay. The dealer was notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 04V045000 (Service Brakes, Hydraulic) since the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 178,000.
VEHICLE LOOSES POWER AND BRAKES GO OUT THEN DIES,DOESN'T MATTER SPEED. IF SLOWING DOWN AND PRESS THE BRAKES, THE LOCKS, LIGHTS, AND SECURITY GOES CRAZY. THIS IS DANGEROUS AS IT IS IN INTERSECTIONS AND CAUTION FOR COLLISION. THE VEHICLE HAS TO BE OFF FOR A TIME FRAME AND RESTARTS FINE AND CAN GO. HAPPENED WHEN COMING FROM RAMP AND IN MIDDLE OF ROAD WITH SEMI TRUCK COMING DOWN BY US.
THIRD BRAKE LINE FAILURE DUE TO CORROSION. AREAS OF FAILURE ARE HIDDEN FROM VIEW ABOVE OTHER COMPONENTS. UPON BRAKE LINE FAILURE, BACKUP BRAKING WAS INOPERATIVE IN ALL CASES. VEHICLE WAS ON A CITY STREET IN MOTION ATTEMPTING TO STOP. BRAKES FAILED SUDDENLY IN ALL CASES. BRAKES WERE VERY NOTICIBLY INOPERATIVE BEFORE ANY INDICATION ON DASH BOARD. PUMPING THE PEDAL DID NOTHING- THE PEDAL WENT TO THE FLOOR. WAS TOLD MANUFACTURER NO LONGER SUPPLIES BRAKE LINES FOR THIS VEHICLE.
IT TAKES HALF AN HOUR TO FILL MY TANK IT KEEPS KICKING OFF LIKE IT'S FULL WHEN IT'S NOT
I HAD JUMPED MY DEAD BATTERY AND LEFT THE TRUCK RUNNING. ABOUT 10 MINUTES AFTER BEING JUMPED, THE DRIVER'S AIRBAG DEPLOYED. THE VEHICLE NEVER MOVED AND WAS SITTING IDLY IN PARK AND NOTHING TOUCHED THE VEHICLE. *TR
CLEAR COAT PEELING ON ALL HORIZONTAL SURFACES, UPPER DASH PANEL DEVELOPED MULTIPLE CRACKS CREATING A SAFETY HAZARD IF AIRBAG DEPLOYS.
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. THE CONTACT STATED THAT THE ENGINE FAILED TO START AND THE FUEL GAUGE DISPLAYED THAT THE FUEL TANK WAS EMPTY. THE CONTACT ALSO NOTICED A STRONG FUEL ODOR INSIDE THE VEHICLE. THE CONTACT WENT TO THE FUEL STATION AND THE FUEL ODOR BECAME STRONGER WHILE ADDING FUEL TO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT FUEL WAS LEAKING IN THE MIDDLE OF THE SUBFRAME UNDER THE FRONT DRIVER'S SIDE. THE CONTACT DROVE THE VEHICLE HOME. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. THE VIN WAS UNKNOWN.
NEW BATTERY NEW ALTERNATOR HOWEVER THE VEHICLE IS NOT COMMUNICATING CORRECTLY TO HAVE THE ALTERNATOR CHARGE THE BATTERY. RESULT IS "BATTERY NOT CHARGING." THIS DURING ANY OPERATION OF THE VEHICLE. BATTERY WILL DIE.
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 45 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V043000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.
Showing 12 of 319 complaints.