Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2005 Chevrolet Avalanche, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Chevrolet Avalanche year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 3 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Risk: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Campaign 05V055000
Issue: ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Risk: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Campaign 05V163000
Issue: CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Risk: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Campaign 05V043000
NHTSA frontal crash test
Rated configuration: 2005 Chevrolet Avalanche w/SAB; w/updated ESC
The parts named most often across 206 owner complaints filed with NHTSA for this make, model and year.
2 fires
1 crash · 2 injured
1 fire
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
Odometer Fraud. The contact purchased a 2005 Chevrolet Avalanche 1500. It was discovered that there was a mileage discrepancy. The vehicle was a private sale from a towing company. At the time of purchase, the vehicle mileage was 163,428, and at the time of registration, it was discovered that the mileage was 167,126. The contact stated that the Carfax Report indicated that the mileage was 141,207, and that the odometer had been rolled back.
Gear shift indicator does not always light. Has been an issue with other models but has never been recalled for this specific model. Don’t always know what gear you are in. Spare tire completely rusted out, unable to get down. Not sure if this is a recall issue but apparently common for this vehicle
The contact owns a 2005 Chevrolet Avalanche. The contact stated that while starting the vehicle, the passenger’s side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger’s side air bag was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 16,900.
SO THE HYDRABOOST IS FAILING AND MY TRUCK IS POURING AN INSANE AMOUNT OF POWER STEERING FLUID FROM HYDRABOOST SYSTEM. WHEN RESEARCHING THIS PROBLEM FOR MY YEAR MAKE AND MODEL THE HYDRABOOST RECALL POPS UP BUT WHEN CALLING CHEVROLET THEY WANT TO DO NOTHING. WHEN ITS APPARENT MY TRUCK IS AFFECTED BY TRASH PARTS. IT ONLY HAS 149000 MILES ON IT AND THE HYDRABOOST SYSTEM IS GONE. I'M TIRED OF ADDING 2 QUARTS OF POWER STEERING FLUID A WEEK, AND CANT EVEN DRIVE MY FAMILY AROUND BECAUSE I WAITING ON BRAKES TO SPORADICALLY FAIL DUE TO THE SYSTEM BEING COMPROMISED.
THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER DOES NOT ILLUMINATE THEREFORE, I DON'T KNOW WHAT GEAR THE VEHICLE IS IN. IT SEEMS LIKE A SAFETY ISSUE TO ME. IT OCCURS WHEN I START THE VEHICLE, AM MOVING AND WHEN THE HEADLIGHTS ARE ON.
FUEL PUMP FAILED
TL* THE CONTACT OWNS A 2005 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 35 MPH, A SCREECHING NOISE EMERGED FROM THE FRONT DRIVER'S SIDE OF THE VEHICLE. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND SHUT OFF THE VEHICLE. THE VEHICLE WAS TOWED TO WILSON COUNTY MOTORS CHEVROLET IN LEBANON, TENNESSEE (615-257-0578) WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER'S SIDE WHEEL HUB FAILED AND NEEDED REPLACEMENT ALONG WITH THE ROTORS AND BRAKE PADS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.
THE SHIFT LEVER POSITION IS NOT ILLUMINATED. THERE IS ANOTHER RECALL FOR THIS SAME ISSUE BUT THE COMPANY WILL NOT DO ANYTHING. I TURN THE VEHICLE ON AND CANNOT TELL WHAT GEAR I EVEN AM IN,
METAL BRAKE LINE CORRODED THROUGH WHILE DRIVING CAUSING ALMOST TOTAL LOSS OF BRAKES.
THE GEAR SHIFT INDICATOR DOES NOT LIGHT UP IN THE INSTRUMENT PANNEL. THEREFORE YOU DON'T KNOW VWHAT GEAR YOU ARE IN. I DO UNDERSTAND THERE WAS A RECALL NHTSA CAMPAIGN 05V055000 RECALL BAGAN ON 02/14/2005
AT 80K I PUT MY TRUCK IN REVERSE AND HEARD A CLUNK SOUND AND IMMEDIATELY IT WOULDN'T SHIFT GEARS ANYMORE. I WENT AND HAD THE TRANSMISSION REBUILT WHICH LASTED ROUGHLY 10K MORE. NOW, THE TRUCK WON'T SHIFT YET AGAIN AND THE FILTER WAS CHANGED AND THE REAR OUTPUT SEAL. CURRENTLY, WHEN I DRIVE SINCE ITS MY ONLY VEHICLE, ONE MINUTE IT WILL SHIFT FINE BUT AFTER I TURN THE ENGINE OFF AND ON AGAIN, IT WILL NOT SHIFT FROM FIRST AND THE AGAIN, CHECK ENGINE LIGHT IS ON!
WHILE FUELING THERE SEEMS TO BE A BACKLASH AIR BUBBLE THAT OCCURS AND IT TAKES APPROXIMATELY 10 MINUTES TO PUT $30 WORTH OF FUEL. WHILE PUMPING THE GAS NO MATTER HOW SLOW OR FAST AS THE SAFETY IS IN PLACE TO STOP THE FUEL FROM COMING OUT OF THE FUEL NECK WHERE IT MEETS THE FUEL GOING IN THIS IS NORMAL TO KICK OFF THE FUEL SO SPILLAGE DOES NOT BECOME A PROBLEM HOWEVER WHEN YOU STOP FUELING THERE IS A BURP BACK AS IN A AIR BUBBLE THAT SPLASHES OUTSIDE THE VEHICLE WHICH COULD POTENTIALLY SPLASH IN A FACE OR ON YOUR SKIN AND IT ALSO RUNS DOWN THE SIDE OF THE BODY OF THE VEHICLE AGAIN THAT IS WHEN FUELING HAS STOPPED IT BURPS THE FUEL OUT OF THE VEHICLE. OBVIOUSLY THE VEHICLE IS STATIONARY WHILE FUELING. THIS OCCURS NO MATTER WHAT GAS STATION IS USED OLD NEW IT DOESN'T MATTER.
Showing 12 of 206 complaints.