Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2017 Ford Explorer, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford Explorer year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA frontal crash test
2 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2017 Ford Explorer 4 DR SUV AWD
NHTSA lists 14 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer vehicles equipped with power front seats. The seat frames may have sharp edges.
Risk: Occupants my contact the sharp edges when reaching between the power front seat and center console, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will install protective tape on the exposed inside edge and tab of the power seat frames, free of charge. The recall began November 8, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S29.
Campaign 19V651000
Issue: Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Risk: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000
Issue: Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
Risk: A loss of the wheel or wheel end can increase the risk of a crash.
Remedy: Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000
Issue: Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
Risk: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.
Campaign 17V530000
Issue: Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Risk: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Campaign 17V332000
Issue: Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.
Risk: An oil leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.
Campaign 16V925000
Issue: Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Risk: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Campaign 21V316000
Issue: Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Risk: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Campaign 21V537000
Issue: Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Risk: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Campaign 20V675000
Issue: Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Risk: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000
Issue: Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Risk: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Campaign 25V347000
Issue: Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Risk: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000
Issue: Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Risk: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Campaign 26V101000
Issue: Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Risk: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Campaign 26V448000
The parts named most often across 1,691 owner complaints filed with NHTSA for this make, model and year.
1 fire
1 crash · 2 fires · 9 injured
2 fires · 5 injured
1 injured
1 crash
1 crash
4 crashes · 4 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
Head on collision occurred XXX. A man was traveling east on XXX and ran the light at the intersection of [XXX]. I was heading south on [XXX] and hit his white truck. My air bags did not deploy. Also, within the last year a seatbelt was not latching properly and I had to get it replaced. In addition to repairing the roof rack cover which flew off as I was driving one day. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2017 Ford Explorer. The contact stated that there was a crack in the front windshield and water was leaking into the vehicle. The contact was concerned about the electrical system failing from becoming wet. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure) and 26V448000 (Structure). The local was contacted in person, and the contact was advised that the parts were on back order. The vehicle was inspected, and the contact was informed that the vehicle was qualified for the repair. The manufacturer was contacted by phone and informed the contact that parts were not available.
The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 26V448000 (Structure); however, the parts to do the recall repairs were unavailable. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue but offered no assistance. The contact stated that while driving at various speeds, the driver’s side A-pillar trim was loosened and rattled excessively. The vehicle was not repaired. The failure mileage was unknown.
Benoit Nissan in DeRidder, LA, was contracted to perform a critical safety repair/recall on my vehicle's airbag system. The dealership charged for the completed repair, but explicitly aborted the physical installation, leaving the vehicle's Supplemental Restraint System (SRS) incomplete, non-functional, and hazardous. They attempted to return the vehicle to me with the air bag safety system compromised, creating an immediate, severe physical risk to occupants in the event of a crash. This involves deliberate service manipulation of a federally mandated safety device. They have a proven record of deceitful operations of criminal negligence and felony theft
The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver’s side door B-pillar trim detached and was hanging by the wires, which became frayed. The message "Liftgate Ajar" was displayed while the liftgate was closed. The contact associated the failure with NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 71,789.
I know there is a current recall, but I have NO idea why FORD is taking almost 2 years now for a remedy. Now the trim piece under this recall is starting to separate from the driver side. This also has electrical functions (keyless entry), and is making driving the vehicle a challenge as who knows when the piece will fully separate from the vehicle. HELP PLEASE, there has to be a faster way to get this recall work done.
The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the passenger’s side A-pillar trim detached from the vehicle. The contact associated the failure with NHTSA Campaign Number: 24V031000 (Structure). The dealer was contacted, and the driver’s side A-pillar trim was taped down to avoid becoming detached. However, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 81,000.
The steering wheel sticks when going into a turn then pulls back . It’s been on going . I know they had issues and recalls with steering .
The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the passenger's side B-pillar trim detached and flew off the vehicle. The contact stated that the B-pillar trim struck another vehicle. In addition, the driver's side B-pillar trim was fractured. The contact stated that the driver's side B-pillar trim was reattached but was still loosened. The dealer was made aware of the failure. The contact was informed that parts were unavailable to repair the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, parts were unavailable for the recall repair. The manufacturer was made aware of the failure. The contact was informed that parts would be unavailable until 2027. The failure mileage was approximately 100,000.
Recall hasn't been fixed since January when I purchased the vehicle
The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the driver’s side A-pillar trim had detached from the vehicle and the passenger’s side A-pillar trim was loosened. The failure mileage was 130,000.
My 2017 Ford Explorer is subject to Ford Safety Recall 24S02 / NHTSA Recall 24V031 for exterior A-pillar trim that may detach from the vehicle. I presented the vehicle to an authorized Ford dealer, and the dealer confirmed that my vehicle is covered by the recall. However, the dealer informed me that the required Ford recall replacement part is unavailable and that they have not received these parts for an extended period of time. The A-pillar molding on my vehicle has actually detached and flown off the vehicle while driving on TWO separate occasions. Replacement aftermarket molding has not provided a reliable solution. This is therefore not a hypothetical or cosmetic concern. The failure described in Ford's safety recall has occurred twice on my vehicle. Ford's recall identifies detached A-pillar trim as a potential road hazard that can increase the risk of a crash. Despite the known safety defect and the repeated occurrence on my vehicle, I cannot obtain the Ford recall repair because the authorized dealer cannot obtain the required Ford replacement part. I am requesting that NHTSA review Ford's inability to provide a timely recall remedy for Recall 24S02, including the continuing unavailability of the required replacement parts. My vehicle currently remains subject to an acknowledged safety recall for a failure that has already occurred twice.
Showing 12 of 1,691 complaints.