2021 Jeep Wrangler Unlimited 392

The One Touch Power Roof has rails from side to side. Several of these have broken at their attachment to the track system. This has created several issues: 1) the roof is no longer leak proof, 2) it creates excessive noise at high way speed. I have not used this system much, so it is unclear why this failed. When I presented the car to the Jeep dealer service area, I was told the only solution is to replace the entire roof - several thousand dollars. There is no other fix. This is out of warranty, but it clearly is a manufacturing issue common with this roof. I believe Jeep should replace this roof system at their cost , not mine. They have not shown me why this happened nor have they claimed it is my fault.

The contact owns a 2021 Jeep Wrangler. The contact stated while seated inside the vehicle while the vehicle was stationary, the contact heard a pop and then saw flames coming from underneath the hood. The contact safely exited the vehicle. The fire was extinguished by bystanders nearby with fire extinguishers and water. The fire department arrived on the scene, but the fire was already extinguished. The fire department pried the hood open. The vehicle was inspected by the Police and the Fire Department. A police report was filed. The contact stated sustained smoke inhalation, but medical attention was not sought. The failure mileage was 170,000.

Was driving on the interstate at about 65 mph went over some small bumps in the road and got the jeep death wobble. It happened a total of four times on that trip within an hour. Thought I was going to crash.

On the highway, at Highway speeds of 70 mph, going over small bump my jeep goes into a death wobble. Both tires bouncing erratically steering wheel racing back-and-forth. To stop the death wobble I Have to let off the gas and slowly break to a complete stop before the death wobble stops. The frustrating part is, the Jeep Wrangler, is only five years old, and it has never been off-road, and has less than 28,000 miles on it, not to mention how dangerous the situation is. I have had this happen 6 times.

The contact owns a 2021 Jeep Wrangler. The contact stated that while operating the vehicle, the engine overheated, and the vehicle was driving sluggishly with the temperature gauge indicating that the engine was overheating. The vehicle was taken to an independent mechanic who determined that the coolant reservoir was cracked and was leaking coolant. The coolant reservoir was replaced, and the vehicle was repaired. The contact stated that the vehicle failed to immediately start due to battery failure. No further information was available. The local dealer was notified of the failures, but no assistance was provided. The failure mileage was 56,700.

When using electric mode, repeatedly and consistently, when I try to accelerate (for example to get onto a highway) despite having the acceleration fully depressed, the car does not accelerate. After some time, the gas powered engine will rev, the RPM will shoot up and then the car will start to accelerate. If I slow down the electric engine will take back over, but then if I try to accelerate again the same thing will occur. I have videos of the dashboard confirming electric mode, delay to accelerate and eventual activation of the gas motor and RPMs. This same issue was noted by Jeep technicians after the fix for a previous recall on the battery. This is dangerous, If I am not able to accelerate I can not safely drive change lanes, go onto highways, or avoid danger. it has been occurring, but my first video is from Feb 2026, and most recently July 2026.

After dealer recall 21D inspection on 7/30/2026 I have experienced 2 electrical failures in the recall system, and/or systems associated with recall. The first incident on 7/31/2026 at approximately 9:00 PM my wife, 2 kids, and a neighbors kid were at a stop light for a 4 lane road when the Jeep unexpectedly made a popping sound and shut down. When I arrived I pushed the vehicle into a parking lot and attempted to restart. I was able to restart the vehicle but instantly started seeing multiple warnings including Service Power Steering (code associated with the recall), Throttle body warning, and Warning that the vehicle would shutdown for safety. After the vehicle shutdown the electrical system went crazy (gauge cluster lights flashing, windshield wipers turned off and on, relays clicking). I had the vehicle taken to my mechanic on 8/6/2026 where they determined that the AUX battery was bad (previously replaced in 05/2026) AND the main fuse array fuse N3 was blown. The mechanic replaced both components, tested the vehicle, and rechecked for any new error codes. On 8/11/2026 my wife and 2 kids attempted to leave soccer practice and the Jeep would not start. I brought them home and returned to the Jeep. As it was near closing time for most auto parts retailers I decided to start by having the main battery tested. When I opened the hood to remove the battery I noticed that the engine compartment seemed abnormally hot. I removed the battery and had it tested by AutoZone (failed-only 6 CCA). I purchased a new battery and when I installed I still noticed an abnormally high temperature in the engine compartment. After installing the new battery the Jeep started & instantly displayed a power steering warning. I shut the vehicle down and let it rest approximately 30min. When restarted a low voltage warning displayed immediately. I returned the next day to a dead Jeep. I returned the Jeep to the dealership that inspected for 21D. (Aux batt. bad & main fuse array blown AGAIN)

Acceleration lag: either bucking or temporary loss of motive power when attempting to pull into traffic has almost caused us to be hit several times. We had the problem almost immediately after purchase, but the lag was short and the Jeep would leap forward and back tires would squeal which caused the back tires to wear quickly compared to front. The bucking and loss of power while accelerating became dangerous after I took to the dealership in Feb 2026 when they also did recall 68C related to the battery. We stopped charging it completely and still had the issue. Took back to the dealership in March 2026 and they said they could not replicate issue. Tried to schedule an appt last week and they never got back to me. We have avoided several accidents so far but I am now afraid to drive it. Assuming these are unrelated but just in case: at 10k miles the check engine light came on, and I couldn’t add ANY fuel (automatic shut off happened immediately) and the fuel cap wouldn’t open. Foss Motors wrote: "CHECKED FOR CODES IN SYSTEM. VEHICLE HAD CODES P2451 FUEL TANK ISOATION VALVE A STUCK, PO4EC EVAP SYSTEM LARGE LEAK DETECTED AND P04EE EVAP SYSTEM SMALL LEAK DETECTED. PERFORMED EVAP SYSTEM SMALL LEAK VERIFICATION TEST. TEST EVAP SYSTEM AND FOUND ISOLATION VALVE STICKING. COMPLETED REPLACEMENT OF ISOLATION VALVE. Replaced fuel filler tube 68413327AD and 68412848AC fuel cap." In Sept 2025 (~45k miles) - Check engine light came on again soon after with errors: PO4EC EVAP SYSTEM LARGE LEAK DETECTED and P04EE EVAP SYSTEM SMALL LEAK DETECTED. They could not find leak or issue.

Our Jeep has a death wobble that has almost caused me to have three wrecks where it is taking me out of my lane of travel and put me in Lanes where other people are had to get to the side of the road and try to get it to stop wobbling it. Every time I hit a pothole or a bump it throws me into a death wobble. I'm worried that this might cause me to get into an accident or cause me to die this happens every time I drive it. I cannot go above 40 mph without causing a death wobble so now I have no use of my Jeep. It just sits

The harmonic balancer on the motor failed and flew off the motor causing catastrophic damage to the radiator. The failure resulted in immediate disabling of the vehicle, which could have happened at high speeds or on a highway with limited access. The part that flew off the motor was also a large piece of solid metal that luckily landed in the bumper cavity, but if it would have left the engine compartment, would most certainly be a fatal projectile. Once taking it to the dealership, they told me that this is a known problem with the Hemi 392 motor. Research shows this has been an issue since 2003 with this motor. The motor is found in several different Stellantis vehicles. There were no warning signs of the failure prior to it occurring.

I am writing to express my concern regarding the handling of the urgent safety recall affecting my Jeep Wrangler. This recall has been classified as an urgent fire and safety risk, yet no remedy is currently available. The recall notice stated that owners would receive notification regarding the remedy by July 9. As of today, August 4, I have not received any follow-up communication, and the NHTSA website continues to list the recall as unresolved with no available repair. I find it deeply concerning that a recall deemed urgent due to the potential risk of fire has remained without a remedy for approximately two months. Owners are expected to continue operating vehicles that have been identified as posing a serious safety hazard while having no meaningful way to mitigate that risk. This places consumers in an unreasonable position, especially those who rely on their vehicles for work and daily transportation. I respectfully request that NHTSA review whether the manufacturer is complying with its obligations under federal motor vehicle safety recall requirements. Given the severity of the identified risk, I also ask that NHTSA determine whether additional oversight or enforcement is warranted to ensure affected owners receive a timely remedy. Additionally, I ask NHTSA to consider whether the manufacturer should provide interim accommodations, such as loaner vehicles or rental reimbursement, while a permanent remedy remains unavailable. I respectfully request that this matter be escalated and that I receive an explanation for the continued delay, an estimated timeline for when a remedy will be available, and guidance for owners who are left with no practical way to address this known safety hazard. Thank you for your time and attention. I look forward to your response.

The contact owned a 2021 Jeep Wrangler. The contact stated that while driving on the highway at 45 MPH, the instrument panel cluster went out and the vehicle experienced a slight loss of automotive power, and the front headlights failed, the contact was then involved in a head on collision, where the front passenger side was impacted. The vehicle came to a stop upon impact. The air bags were deployed. The vehicle was towed to a junk yard. A police report was filed. The vehicle was destroyed. The contact was seated in the passenger seat while her husband was seated in the driver seat. No individuals outside of the vehicle were reported to be injured. The contact stated that her husband had sustained injuries to his knees, neck, and back, the contact has sustained injuries to their neck and shards of glass in her face. Medical treatment was needed for the injuries. The impact of the crash was the front passenger side. The local dealer was not contacted, and the vehicle was not diagnosed. The manufacture was notified of the failure. The failure mileage was 60,000