2023 Jeep Wrangler Unlimited 392

On two separate occasions, the vehicle shut off while driving. Error messages indicated "electrical failure" and to "service charging system". In the second instance the check engine light came on. Both times I was able to get safely to the shoulder. The car was restarted by powering the vehicle off and then on again. October 2025- in Massachusetts on I290 heading back to CT from Maine February 2026- in CT on [XXX] The vehicle has been in and out of repair for several months at a time without repair or replacing parts. Software flashes clear the codes but have not fixed the ongoing issues. The manufacturer is aware and multiple cases have been opened with them without resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ECH CODE poe15

Aug 6 2026 turtle limp mode came on. Lost power. Sept 5,6 turtle mode came on. Slowed to a crawl with several cars behind me. Oct 3 turtle limp mode came on. Lost power thru intersection. Thankfully no oncoming traffic. Oct 4 turtle limp mode came on. Had to pull over and restart vehicle in traffic

The contact owns a 2023 Jeep Wrangler. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 26V363000 (Steering); however, while driving at an undisclosed speed, the vehicle experienced a total loss of motive power. Warning messages stating "Service Shifter" and "Check Hydraulics" along with other unknown warning lights displayed on the instrument panel. Additionally, the contact felt that the recall repairs contributed to the failure. The vehicle was towed to the same local dealer; however, the failure could not be identified. The manufacturer was notified of the failure via email and telephone. The failure mileage was approximately 49,000.

while driving my 2023 Jeep Wrangler Willys 4xe at approximately 40 mph in electric mode with approximately 26% battery charge remaining, the vehicle suddenly and unexpectedly lost propulsion. The green indicator on the instrument cluster that normally shows electric operation changed to yellow. Immediately afterward, the Jeep abruptly lost power and began rapidly decelerating. I was NOT applying the brakes. The dashboard displayed "Service Charging System" along with a red warning symbol resembling a charging cord. I was able to get the vehicle off the roadway and into a parking lot. The Jeep then came to a stop. The vehicle remained powered on and the dashboard remained illuminated, but pressing the accelerator produced no response. The Jeep would not move. I turned the vehicle completely off and waited several minutes. When I restarted it, the Jeep started and operated normally again. The Jeep spent approximately three months at an authorized Jeep dealership for multiple electrical/charging system problems and diagnostic trouble codes. During that time, the 12-volt battery was replaced and the Integrated Charging Dual Module (ICDM) was replaced. The Jeep operated normally for approximately three months following those repairs before this incident occurred. This was an extremely serious safety event. The vehicle unexpectedly lost propulsion while actively traveling on a public roadway. If this had occurred at highway speeds, while merging, crossing traffic, or in heavy traffic, I may not have been able to safely get the vehicle off the roadway. I am particularly concerned because the malfunction disappeared after shutting the vehicle off and restarting it, making the failure intermittent and unpredictable. I am requesting that NHTSA investigate this sudden loss-of-propulsion incident and determine whether it is related to other reported loss-of-motive-power problems involving Jeep Wrangler 4xe vehicles. The photograph included is not my Jeep but shows what happened

From a stop sign vehicle would only accelerate to 4 mph and then completely lost forward propulsion, forcing a tow to the dealership.

On September 24, 2026, Recall 68C was completed on my Jeep Wrangler 4xe by an authorized Jeep dealership. Following completion of the recall, the first attempt to charge the vehicle resulted in an electrical fire at the charging location. During the charging event, the charger and electrical outlet melted, and the wiring connected to the outlet began to burn. The fire appears to have originated at the charging equipment and outlet. No visible damage occurred to the vehicle itself; however, the charger, outlet, and wiring sustained significant damage. Post-Recall Vehicle Performance Concerns: Since completion of Recall 68C, the vehicle has not operated correctly in Electric Mode. The following conditions were not present prior to the recall service: The internal combustion engine (ICE) repeatedly cycles on and off while the vehicle is displaying "Electric" mode on the instrument panel. Acceleration and overall vehicle performance are significantly reduced. The vehicle experiences severe throttle lag and delayed accelerator response. In some instances, there is little or no throttle response, followed by sudden engine engagement at engine speeds exceeding 3,000 RPM. Vehicle operation in Electric Mode is inconsistent and unpredictable. These performance issues began immediately following completion of Recall 68C and have persisted since the recall service was performed. Additional Information: I have become aware of reports from other Jeep 4xe owners who have described similar drivability and Electric Mode concerns after completion of Recall 68C. Given the charging-related fire event and the significant changes in vehicle operation that appeared immediately after the recall was performed, I am requesting that NHTSA investigate whether these conditions may be related to the Recall 68C remedy or associated software and system changes. Safety Concerns: Fire hazard during charging. Loss of expected vehicle performance. Delayed or unpredictable throttle response.

1. Vehicle loses power when accelerating in full electric causing serious unpredictable delays. Dealer applied bulletins 08-262-26 and 08-039-26, which hard-coded a dangerous throttle lag into the vehicle, creating a severe safety hazard when merging into highway traffic. The dealership will be unable to fix this issue from this point moving forward.

While driving my 2023 Jeep Wrangler Sahara 4xe at approximately 70 mph in Hybrid mode the vehicle suddenly and without warning experienced a complete loss of propulsion while I was traveling in traffic. The vehicle would no longer respond normally to the accelerator and I was unable to maintain speed. The Drive (D) indicator began flashing and multiple warning lights and messages appeared on the instrument cluster. I specifically remember the red battery/charging-system warning being illuminated. The dashboard also displayed a warning relating to the power/charging system and a message instructing me to shift or put the vehicle into Park. I had to get the vehicle safely out of moving traffic. This was extremely frightening because the loss of propulsion occurred suddenly at highway speed and could have resulted in a serious collision. This vehicle has previously been brought to an authorized Jeep dealership multiple times for recalls/service involving the battery/electrical/12-volt system. On a previous occasion, the vehicle also failed to start while parked in my garage. After this highway incident occurred and after I was eventually able to get the vehicle operating again, my husband disconnected the 12-volt battery in an attempt to perform a hard reset. The battery was disconnected AFTER the loss-of-propulsion event and therefore did not precede the highway failure. The vehicle is currently at an authorized Jeep dealership for diagnosis. I have asked the dealership to document the complete loss of propulsion, retrieve any available stored, pending, history or permanent diagnostic trouble codes, and determine the cause of the failure. I am reporting this incident because I am very concerned that an electrical, hybrid, battery, charging or powertrain defect may cause the vehicle to suddenly lose motive power again while being driven. A sudden loss of propulsion at highway speed presents a serious safety risk to the occupants of this vehicle and to other motorists.

After a recent recall for the battery, the vehicle did not operate as it did before with regards to ‘Electric only’ mode. The vehicle engine would intermittently start under seemingly normal conditions ( no major hills or hard pressing of gas) despite being in the electric mode. There would be a noticeably high rpm cycle when this happened.

Whatever I am driving in electric mode usually when I’m down to under 40% electricity, the vehicle decides to shut electricity off and start to load the motor. It’s still flashing on the dash that it’s an electric mode and I tend to lose significant power. I try to give it gas there is no reaction with the gas pedal and then all of a sudden the engine will kick on and I will go into the gas motor running the vehicle why it’s still in electric mode. This happens every day and this is getting ridiculous with the problems that this Jeep is having it seems like Jeep and Solanus do not care. We call Jeep care and they just ignore all of our problems and I know this is a widespread problem throughout the US and Canada these vehicles are unsafe to drive when you’re on the highway and electric mode and it all of a sudden you have no gas pedal in the vehicle significantly slows down and the regenerative braking does not work anymore either at any time after the 68C recall can you please help us

After receiving the 68c recall, which was a software update to protect Jeeps defective HV battery maintenance system, I have experienced two dangerous situations while driving in electric mode. After this recall when driving in electric mode the vehicle will start moving from a stop and then stall. The only way to continue after this high risk delay is to put the accelerator to the floor so the gas engine will kick in. This delay can be a couple seconds. My two circumstances are as follows. Once when crossing an intersection after stopping at a stop sign my jeep moved into the intersection and stalled in the middle of it. There was traffic from the cross road that needed to stop to miss me. The second occurrence was when I was taking a right into moving traffic. Again I was able to enter the road but the Jeep stalled and I was idle as 50 mph traffic was bearing down on me. They too needed to slow to avoid hitting me. The only work around is to not drive in electric mode which is not how the vehicle was intended. Please look into this problem before people are hurt or killed. Thanks