Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2015 Kia Optima, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Kia Optima year.
NHTSA warns this vehicle can catch fire while parked and switched off (3 recalls). Park outside and away from structures until it is repaired.
Recalls are issued per model. Confirm whether this specific car has already been repaired using its VIN, free, at any franchised dealer or on nhtsa.gov/recalls.
NHTSA lists 4 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
Risk: If the HECU short circuits, there is an increased risk of an engine compartment fire.
Remedy: Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.
Campaign 20V519000
Issue: Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
Risk: An electrical short in the HECU increases the risk of a fire while parked or driving.
Remedy: Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.
Campaign 21V331000
Issue: Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
Risk: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Campaign 23V652000
Issue: Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000
NHTSA frontal crash test
4 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2015 Kia Optima 4 DR FWD
Over 5 years this costs $2,000 more in fuel than an average new vehicle.
The parts named most often across 1,009 owner complaints filed with NHTSA for this make, model and year.
2 crashes · 24 fires · 1 injured
1 crash · 4 fires
2 fires
6 fires · 2 injured
6 fires · 2 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
1 complaint-reported fatality on this model.
The contact owns a 2015 Kia Optima. The contact stated that while pulling into the driveway, the ABS warning light remained illuminated after the vehicle was powered off. The contact stated that the parking brake warning light unexpectedly illuminated while the vehicle was being operated. The contact stated that the brake lights illuminated while the vehicle was turned on or off. The contact's son inspected the vehicle and became aware that the rear of the vehicle near the brake pedal was extremely hot and that the area under the hood was extremely hot. The vehicle was taken to the dealer but was not diagnosed. The dealer informed the contact that the failure could be associated with a light switch failure; however, the contact stated that the failure was not related to the light switch and that the vehicle needed to be diagnosed to determine the cause of the failure. The approximate failure mileage was 231,000.
My energy in my car started messing up with only 150,000 miles it had a long knocking sound and it would not got over 20 miles while driving
My 2015 KIA optima experienced a catastrophic engine fire while I was driving. There was no warning, I just heard a boom in the engine bay the breaks stopped working and all electrical cut out. As I'm coasting, because I'm unable to stop, flames started to come in through under the dash. I couldn't turn the car off, nor put it in park so the doors stayed locked. The driver window was opened just enough for me to grab the top and break it, allowing me to crawl out. The car coasted itself to the shoulder then blew up (I had a full tank of gas.). All this happened in the manner of 30 to 35 seconds. It's important to note that KIA just replaced the engine 2 months prior to this incident.
The contact owns a 2015 Kia Optima. The contact stated that for over 8 years, the vehicle was experiencing excessive oil consumption. There was no warning light illuminated. The contact became aware that there was an oil leak on the ground underneath the vehicle. The vehicle was taken to the dealer on several occasions for the oil consumption failure; however, the dealer was unable to find a fault with the vehicle. The dealer had not yet provided a cause for the oil leak. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 123,000.
The engine in my vehicle failed while putting the car into reverse to back into my garage. I thank God I wasn't on the road when this happened. I took the car into a mechanic who confirmed that the engine was locked and that the car was very low on oil(even though I had my oil changed by him a few months prior). There was an undetected oil leak that led to the engine failure. The warning indicators didn't appear on my dash until after my engine failed.
This is a formal vehicle safety complaint regarding a manufacturer's active refusal to remedy a known safety defect under an active recall campaign guidelines.My 2015 Kia Optima Turbo experienced an active internal mechanical engine knock, violent sputtering, and a complete engine seizure. The vehicle is currently sitting un-driveable at an authorized Kia dealership.The required Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the incident, legally qualifying it for a 100% free long-block engine replacement under the manufacturer's active Lifetime Warranty extension. However, the dealership service department is actively withholding the safety warranty paperwork and refusing to submit the diagnostic photos and engine seizure data to corporate for warranty approval unless I agree to pay an additional $800 out of pocket for an external throttle body and O2 sensor.I have explicitly declined the retail accessory charges five separate times. I only authorize the replacement of my front sway bar links. Instead of separating the ticket and processing the free engine block safety remedy, the dealer is holding my safety warranty hostage to force a retail sale. Furthermore, a manufacturer consumer care representative recently refused to listen to my request on this matter and dropped the call.The manufacturer is using internal technical advice to block a court-ordered safety remedy and is allowing a dealership to use unauthorized retail accessory charges to deny me a safe, operating vehicle. I request immediate federal intervention to force the manufacturer to release the free engine block safety replacement order to the dealer and halt these predatory dealer practices.
The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the rear taillight socket wiring harness failed to function as intended. The contact was informed that the brake lights were inoperable. The contact stated that the failure had occurred every 6–7 months. The contact stated that the repair was completed by the contact. The dealer was not made aware of the failure but provided no assistance. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.
The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. During the failure, several unknown warning lights flashed on the instrument panel and there was smoke coming from under the hood of the vehicle. The contact exited the vehicle, and there were flames coming from underneath the hood. The Fire Department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A Police report was filed, and the vehicle was towed to a tow lot. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The contact stated that the original engine was previously replaced by the local dealer due to a previous recall. No further information was available. The failure mileage was 140,000.
My girlfriend was driving on interstate 95 to pick me up from the metro. The engine suddenly cut off in a manner that appears to have melted the wiring harness of the vehicle, risking fire. She was able to safely get to the side of the road and call a tow. After taking it to a local repair shop, they diagnosed the issue as related to the KSDS recall. We had it towed to the dealership that has also confirmed it is related to the recall. The engine is completely seized following this incident and it's worth noting that Kia is completely denying the engine repair claim as the KSDS update was not installed prior.
I would say that the time this incident happened I was driving and me and me nephew were in car at time taking to shop to see why it was making a sound like air and all of sudden the car started swerving and slowing down and then it made a pop sound and smoke started coming from the car and I was thankful that I didn’t get hit but affraid and also hit my head in car due to the sudden jerk car mad and then it popped sound a d smoke came from good. The next day I have to pay to get back on the other side and also tow it home which it been parked since but I see a recall on my vin and want to find out how to get it to the nearest Kia to fix the recall
The contact owned a 2015 Kia Optima. The contact stated that while driving to the residence, the vehicle caught on fire. The contact stated that while at a traffic light, the vehicle suddenly shut off. After exiting the vehicle, the hood was opened, and there was smoke coming from the engine compartment. The contact called an independent mechanic and, within two minutes, became aware of the fire. The contact called 911 for the Emergency Services. The Fire Department arrived and extinguished the fire. There was no injury sustained. There were no warning lights illuminated. The vehicle was previously taken to an unknown local dealer, where it was diagnosed that the engine was leaking with a blown head gasket. The engine was replaced. The vehicle was towed from the scene and was deemed a total loss by the insurance company. The manufacturer was contacted and opened a case. The failure mileage was approximately 212,000.
My 2015 white Kia Optima is having terrible paint peeling problems. It is peeling and chipping on the hood, along the sides of the windshield, above the wind shield, on my back bumper, above my back tires, and just about every place in between. PLEASE HELP!
Showing 12 of 1,009 complaints.