ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM07/20/2026
The contact owns a 2022 Kia Sportage. The contact stated that while the vehicle was parked with the engine running, there was an alert on the instrument panel that stating "Warning - System Overheating". The contact checked the coolant level, and the level was at the operational level; however, the A/C was not operating properly. While driving the vehicle, the external temperature gauge started lowering. The vehicle was taken to a dealer, where it was diagnosed with blower motor failure that affected the wiring harness and the cooling fan assembly. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 97,000.
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE07/18/2026
I am submitting this complaint regarding the positive battery terminal fuse block (battery terminal/fusible link assembly) on my 2022 Kia Sportage. The component is currently installed on the vehicle and is available for inspection upon request. I purchased this vehicle in 2024, when it was only about two years old. Because of the vehicle's age, I did not expect to experience major electrical problems. Approximately one year after purchasing it, in June, the battery failed and I had to purchase a brand-new replacement battery. Then, only about three months later, that replacement battery also failed and had to be replaced with another new battery. Having two batteries fail within such a short period on a relatively new vehicle made me believe there was an underlying electrical problem rather than simply defective batteries. As the problem continued to worsen, I discovered that the issue appeared to be related to the positive battery terminal fuse block connection. The connection became intermittent, and the vehicle would not reliably start because electrical power was not consistently passing through the battery terminal assembly. To temporarily restore the connection, a small metal key was carefully placed between the fuse block connection and the battery terminal. This was never intended to be a repair, but it was the only way to make the electrical connection so the vehicle would start. With the metal key in place, the vehicle would start and operate. Recently, the vehicle was exposed to snow and moisture. After that, the temporary connection stopped working and the vehicle would no longer start. I removed the metal key, allowed the connection to dry, and then inserted a small folded piece of aluminum foil into the same location to temporarily restore the electrical connection. The aluminum foil is still in place because it is currently the only way I can start the vehicle and drive it to a Kia dealership for inspection and replacement of the failed component. I
ENGINE05/27/2026
Engine failure at 93,000 miles. Timing chain jumped, causing internal engine damage. Dealer (Capitol Kia, San Jose CA) diagnosed engine as failed and quoted $11,843 for short block replacement. Vehicle is a 2021 Kia Sportage 2.4L. This is a known issue with the Theta II 2.4L engine.
ENGINE04/02/2026
The engine failed completely, it has to be replaced. Yes, it’s available The engine could start a fire. It’s confirmed by an independent service. No, hasn’t been inspected by the manufacturer. The suv started shaking and making a sound, the engine light started flashing all of this in just one hour, and I have to stop.
ENGINE03/17/2026
Had my oil changed less about 3k miles ago and my oil like flashed on and then off. I check my oil and I have no oil. I should be able to go 5k miles. Took it to Goodyear and he check for leaks and other things and it's an oil consumption issue and said there should be a recall on my engine. I will be taking it to the dealership. My car has about 70k miles on it. It should not be burning through oil like this.
ELECTRICAL SYSTEM,SEATS,UNKNOWN OR OTHER02/01/2026
On Feb. 1, 2026 my 2022 Kia Sportage caught fire while parked and turned off. The vehicle had been stationary and was not running at the time the fire started. There were no warning lights, no prior overheating, and no collision or external cause. The fire appears to have originated from the engine/electrical area. This incident resulted in a total loss of the vehicle and posed a serious safety risk, as the fire occurred without warning. The vehicle was properly maintained and had no known modifications. This incident is concerning due to previous reports of Kia vehicles experiencing spontaneous fires related to electrical or engine components. I am requesting this incident be investigated for potential defects in electrical systems or engine components that may cause fires while the vehicle is parked and turned off.
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM01/30/2026
Vehicle developed a cylinder 3 misfire that progressed to engine failure. The engine began running rough and lost power during normal operation. Dealer diagnosed internal engine damage and advised that a complete engine replacement is required. Prior to failure, the vehicle experienced significant oil loss, with oil leaking and rapidly depleting despite proper maintenance. Oil levels dropped abnormally between services. No adequate warning was provided before the engine condition worsened. Failure resulted in loss of engine performance and required towing. Vehicle was properly maintained. Repair cost exceeds reasonable expectations for vehicle age and mileage. Dealer advised that required engine parts are on backorder, leaving the vehicle inoperable for an extended period.
ENGINE01/18/2026
intake camshaft position actuator circuit alert went off I have had the engine replaced 3 times in this car in the past year now, the first time in February of 2025 then in August of 2025 and again in October of 2025 and I am now having further engine troubles with this vehicle. All replacement engines have been re-manufactured and I have been told be the Kia dealership that the first 2 were sent with faulty parts. They claimed they switched to another company for the 3rd replacement but this engine is having issues as well.
UNKNOWN OR OTHER01/16/2026
THE DEALER FAILED TO COMPLETE THE ANTI-THEFT DET IGNITION CYL PROTECTOR, NOW MY CAR WAS STOLEN. THE DEALER TOLD US THAT THE RECALL WAS TAKEN CARE OF, THEY EVEN ADDED BOTH DECALS ON EACH WINDOW, THE DRIVERS AND PASSENGERS, THAT SAID ANTI-THEFT DECAL INSTALLATION COMPLETED, BUT THE MAIN REASON WE BROUGH IT IN WAS BECAUSE WE HAD RECEIVED A LETTER IN THE MAIL STATING THAT OUT 2022 KIA SPORTAGE HAD A RECALL ON ANTI THEFT KEY IGNITIONS. THE CAR WAS LEFT AT THE DEALER FOR MORE THAN 8 HOURS, TOLD US IT WAS READY AND COMPLETED AND THAT WAS NOT TRUE!
ENGINE12/06/2025
Engine began to knock on [XXX] on my way home from work. Drove to work and back the next day, but heard a loud CLUNK when I started it to head home. Stopped at auto parts store and checked oil. Completely dry dip stick (after wiping it clean). Added 2 qts of synthetic since I had an appt the next morning ([XXX]) at 7:30am at dealership where I purchased it. Knocking stopped but only drove about 12 miles total from that time until appt in the morning. Kia now tells me that engine failed and based on their records, insufficient maintenance. Kia dealer changed hands recently so not sure of the recordkeeping on their end. I've only ever had my vehicle serviced there. Also, no engine light nor oil light ever came on to warn me of low oil pressure. Service tech says he will email me video of their inspection. Not yet received. Currently requesting warranty coverage. Expect it to be denied, based on what service techs have said. I cannot believe Kia didn't get their act together after the Theta II engine debaucle. My car is a 2022 Kia Sportage with ~50-51k miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ELECTRICAL SYSTEM,SERVICE BRAKES,FUEL/PROPULSION SYSTEMcrash11/24/2025
While driving my 2022 Kia Sportage, the brakes suddenly stopped responding. I pressed the brake pedal hard several times and the vehicle did not slow down or stop at all. There was no braking pressure and no warning lights. Because the brakes failed completely, I crashed directly into a guardrail. The airbags deployed on impact. This was not driver error, it was a sudden and total brake system failure. The vehicle is currently in a wreck yard and requires immediate manufacturer inspection.
VISIBILITY08/25/2025
The contact owns a 2022 Kia Sportage. The contact stated that while driving at an undisclosed speed, the contact heard an explosion and observed that the moon roof glass had shattered, sending glass down into the interior of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, but it had not yet been diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 42,000.
Showing 12 of 44 complaints.
